2004 MINI COOPER Complaints

POWER ASSISTED STEERING WILL CEASE WORKING WHILE DRIVING, MAKING THE CAR VERY, VERY DIFFICULT TO STEER/CONTROL. THIS PROBLEM IS CURRENTLY INTERMITTENT, BUT WHEN IT DOES HAPPEN IT IS VERY SCARY. CURRENTLY, I WILL NOT ALLOW MY WIFE OR GRANDCHILDREN IN THE CAR UNTIL I FIX THIS PROBLEM. MINI USA THRU MAIN LINE MINI, BALA CYNWYD, PA STATED NO RECALL FOR THIS VEHICLE VIA EMAIL. RESEARCH OF NHTSA ONLINE DATA BASE SHOWS 113 REPORTED COMPLAINTS FOR YEAR 2004 MINI'S AND 120 FOR YEAR 2005 FOR STEERING PROBLEMS AND NO FIX BY BMW. THIS IS A SERIOUS SAFETY PROBLEM AND SUGGEST READERS FILE COMPLAINTS AND HOPE IT DOES NOT TAKE A DEATH TO GET SOMEONE'S ATTENTION. *TR

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT IMMEDIATELY AFTER STARTING THE VEHICLE, THE POWER STEERING FAILED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ON THREE OCCASIONS. DURING THE MOST RECENT FAILURE, THE POWER STEERING PUMP CONTINUED TO RUN AFTER THE VEHICLE WAS TURNED OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 89,000.

WHILE DRIVING IN A 35MPH ZONE, SMOKE STARTED COMING OUT FROM UNDER THE HOOD (BONNET). DRIVER NOTICED ODD STEERING RESPONSE SHORTLY BEFORE SMOKE APPEARED. REPAIR SHOP NOTED POWER STEERING PUMP FAILURE CAUSING WIRING LOOM FIRE. RESEARCH HAS FOUND NUMEROUS POWER STEERING PUMP FAILURES ON MINI COOPERS. WHEN POWER STEERING FAILS, DRIVING IS NEXT TO IMPOSSIBLE GIVEN SIZE OF STEERING WHEEL AND POWER ASSIST DESIGN. *KB

I AM THE ORIGINAL OWNER OF A 2004 MINI COOPER S, NOW WITH A POWER STEERING PROBLEM. THE POWER STEERING REPEATEDLY FAILS FOR NO DETECTABLE REASON--THIS ACCORDING TO MY MINI/BMW MECHANIC. I DRIVE THE CAR FOR APPROXIMATELY 15 MILES AND THE POWER STEERING FAILS. I SHUT THE CAR OFF, LET IT COOL AND RESTART IT. IT RETURNS TO NORMAL AND THEN AGAIN FAILS AFTER A FEW MILES. THE ON-BOARD COMPUTER RECORDS THE FAILURE, BUT DOES NOT EXPLAIN IT IN A WAY THAT WOULD SUGGEST A SOLUTION. THE CAR'S COMPUTER READS: "FAULT STORED: SHORT CIRCUIT/OPEN CIRCUIT AT CONTROL UNIT." HENCE, MY MECHANIC HAS NO IDEA OF HOW TO FIX IT SHORT OF REPLACING THE ENTIRE SYSTEM WHICH, AS HE SAYS, IS NO GUARANTEE THAT THE PROBLEM WILL STOP. AS IT IS, THE CAR IS UNSAFE TO DRIVE, AND I WILL NO LONGER PERMIT MY WIFE TO DRIVE IT. I DO HOPE THE NHTSA WILL LOOK INTO THIS ISSUE. I READ ONLINE THAT ALLEGEDLY IS INVESTIGATING THE ISSUE, AND I WOULD BE HAPPY TO PROVIDE MY MECHANIC'S WRITTEN EVALUATION IF IT WOULD CONTRIBUTE TO YOUR RESEARCH. THE STEERING NOW FAILS EACH TIME I DRIVE THE AUTOMOBILE. THANK YOU FOR YOUR ATTENTION. *KB

POWER STEERING INTERMITTENTLY WORKING CAUSING SEVERE OVERSTEER WHILE ENTERING HIGHWAY TRAFFIC. HAD NO INDICATION OF PROBLEM WHILE ON INTERSTATE. UPON EXITING INTERSTATE ON A 30 MPH LOOP STEERING FAILED . PRESENTLY POWER STEERING IS INTERMITTENT SO THE WIFE NO LONGER GETS TO DRIVE THE COOPER. GOOD FORTUNE WAS WITH ME AND I HAVE DRIVEN CARS WITHOUT POWERSTEERING. EVEN SO I WAS CAUGHT OFF GUARD AND I AM HOPEFUL THIS REPORT WILL PREVENT OTHERS WHICH MAY BE LESS FORTUNATE OR EXPERIENCED. THE MINI DEALERSHIP DIDN'T SEEM TO CARE. *KB

ABOUT A YEAR AND HALF AGO THE CAR WAS LEAKING STEERING FLUID, THE MECHANIC STATED THAT THE COOLING FAN ON THE STEERING PUMP WAS A BAD DESIGN, HE ADJUSTED IT AND IT LASTED UNTIL NOVEMBER OF 2011 AGAIN THE LEAKING STARTED, GRINDING NOISE FROM THE FRONT LEFT,STEERING WAS DIFFICULT ON TURNS. I HAD ALL THE STEERING COMPONENTS REPLACED AT A COST OF @ $1,100. MECHANIC STILL BELIEVED IT IS A DESIGN FLAW, SHOULD HAVE A RECALL. *TR

POWER STEERING DROPPED OUT UNEXPECTEDLY WHILE I WAS MAKING A LEFT HAND TURN, TRAVELING APPROXIMATELY 10-15 MPH. I WAS ABLE TO REGAIN STEERING CONTROL BEFORE A COLLISION, BUT POWER STEERING NEVER CAME BACK ON. I FOUND OUT THE POWER STEERING PUMP HAD FAILED, PERHAPS BROUGHT ON BY A POWER STEERING FAN FAILURE. BOTH THE FAN AND PUMP WERE REPLACED. *TR

DRIVING AT APPROXIMATELY 45MPH, WHEN POWER STEERING FAILED. POWER STEERING FAILURE ACCOMPANIED BY OTHER ELECTRICAL ISSUES. GAUGE CLUSTER RESET, ALL FAILURE LIGHTS WENT ON. POWER STEERING RESTORED SHORTLY AFTER FAILURE. OCCURRED APPROXIMATELY TWO MORE TIMES AFTER FIRST INCIDENT. AFTER POWER STEERING FAILURE NOTICED, ISSUE WITH CHARGING SYSTEM ALSO. CHARGING SYSTEM VOLTAGE CONSISTENTLY LOW, SOMETIMES EVEN GOING DOWN TO 10V ACCOMPANIED BY LOSS OF POWER AND OTHER MALFUNCTION LIGHTS. *TR

THE POWER STEERING ON MY 2004 MINI COOPER S HAS FAILED SEVERAL TIMES WITHOUT WARNING. THE CAR IS VERY DIFFICULT TO STEER WHEN THE PUMP STROPS WORKING WITHOUT WARNING AND MY WIFE NEARLY HAD AN ACCIDENT BECAUSE OF THIS INTERMITTENT FAILURE. I CHECKED ONLINE AND THERE ARE MANY COMPLAINTS ABOUT THE VERY SAME PROBLEM.. STOPPING THE CAR AND SHUTTING THE ENGINE OFF AND THEN RESTARTING IT, CLEARS THE PROBLEM. *TR

LOST POWER STEERING ON FREEWAY AT 70 MILE AN HOUR. NEXT DAY IT WORK FOR 40 MILES THEN FAILED AGAIN ON FREEWAY AT 70 MILES AN HOUR, THERE IS NO WARNING OR FLUID LOSS,JUST COMPLETE STEERING LOSS . THEN IT IS VERY HARD TO CONTROL. *TR