2009 MINI COOPER Complaints

MULTIPLE TIMES, HOWEVER, NEVER WHEN THE DEALER LOOKS AT IT, MY "AIRBAG OFF" LIGHT COMES ON WHILE A PERSON OF ADEQUATE WEIGHT IS SITTING PROPERLY IN THE SEAT. ONCE IT COMES ON IT DOES NOT COME OFF UNTIL THE SEAT IS EMPTY OR THE CAR IS TURNED OFF. DEALER WON'T DO ANYTHING IF THERE ISN'T A FAULT CODE AND CAN NOT DUPLICATE ERROR. IT'S IN FOR THE FOURTH TIME FOR THIS PROBLEM. SEEMS TO BE A MAJOR SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED THAT WHILE REVERSING, THE POWER STEERING WARNING LIGHT ILLUMINATED. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED. THE FAILURE WAS LOCATED AT THE POWER STEERING ELECTRICAL COLUMN, WHICH WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 45,000.

TL* THE CONTACT OWNS A 2009 MINI COOPER S CLUBMAN. THE CONTACT STATED THAT WHEN SOMEONE SITS IN THE PASSENGER SEAT THE YELLOW AIR BAG LIGHT DOES NOT SHUT OFF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD SINCE THERE WAS NO ERROR CODE THERE WAS NOTHING THAT COULD BE DONE TO REPAIR THE FAILURE. THE CONTACT SAID THAT THE MANUAL STATED IF THE FAILURE OCCURRED THE AIR BAG MAY NOT DEPLOY. THE CONTACT WAS CONCERNED ABOUT THE SAFETY ISSUE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 18,600. UPDATED 03/14/12*LJ

WHY IS MY VIN # NOT ADDED TO THIS RECALL? IT HAS ALL THE SAME SYMPTOMS.. I CALLED MINI USA WITHOUT GETTING ANYWHERE. DID I JUST A BUY A LEMON? SEE INFO BELOW: THE COLD START ISSUE HAS BEEN A COMMON THEME POPPING UP IN THE FAULTS AND FIXES THREADS ON VARIOUS MINI FORUMS. SPECIFICALLY, MCS OWNERS COMPLAINING ABOUT A PECULIARLY LOUD ENGINE RATTLE ON START-UP. NOW THE R56 IS A N?INTERESTING" SOUNDING ENGINE TO BEGIN WITH. THE DIRECT FUEL INJECTION SOLENOIDS GIVE THE CAR A VERY DIESEL-ESQUE SOUND AT IDLE. BUT THIS IS A VERY DIFFERENT SOUND ALTOGETHER. BMW HAS DETERMINED THAT THE COLD START RATTLE WAS/IS BEING CAUSED BY THE TIMING CHAIN TENSIONER (WHICH IS IN TURN POWERED BY AN OIL-PRESSURIZED PISTON). MORE SPECIFICALLY THE SOUND IS CAUSED WHEN THE TENSIONER PISTON DOESN'T EXTEND ALL THE WAY (OR AT ALL) WHICH THEN ALLOWS THE TIMING CHAIN TO COME IN CONTACT WITH THE GUIDES ON THE ENGINE COVER. AFTER TWO YEARS OF RESEARCH INTO THE ISSUE MINI NOW HAS OFFICIAL REPAIR INFORMATION AT DEALERS THAT WILL ELIMINATE THE ISSUE. THE PUMA MEASURE NUMBER THAT WILL NEED TO BE REFERENCED IS 10686850-13 (WE'VE SEEN 10686850-12 MENTIONED BUT WE BELIEVE 13 IS THE LATEST) AND THE PART NUMBER IS 11.31.7.598.956. ACCORDING TO THE INFORMATION WE'VE SEEN, ALL CARS AFFECTED IN WITH THE ISSUE WILL GET A NEW TIMING CHAIN, CHAIN GUIDES, CAM SPROCKETS AND VANOS UNIT. AT THIS STAGE MINI IS HANDLING THIS ON A CASE BY CASE BASIS WHEN THE OWNER COMPLAINS ABOUT THE SOUND. WERE GUESSING THEY WOULD LIKE TO STEER CLEAR OF SOMETHING ALONG THE LINES OF A RECALL (VOLUNTARY OR OTHERWISE) DUE TO THE COST OF THE SERVICE. HOWEVER DON'T BE SURPRISED TO SEE AND HEAR MORE ABOUT THIS ISSUE AND THE OFFICIAL FIX SOON. IN THE MEAN TIME IF YOUR 2007-2009 MCS IS AFFECTED WED URGE YOU TO CALL AND MAKE AN APPOINTMENT AT YOUR LOCAL DEALER. *KB

TL* THE CONTACT OWNS A 2009 MINI COOPER S. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL AND THE VEHICLE WOULD MAKE A LOUD NOISE. THE DEALER DIAGNOSED THAT FUEL LINE WAS CLOGGED, WHICH MADE IT DIFFICULT FOR THE FUEL TO FLOW FREELY. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 29,643.

AFTER DRIVING TO WORK FOR 30 MINUTES, I PARKED MY CAR. I THOUGHT I SMELLED SOMETHING AS I WALKED AWAY, SO I STOPPED AN LOOKED, BUT I DID NOT SEE ANYTHING. FIVE MINUTES AFTER WALKING INTO MY BUILDING, SOMEONE TOLD ME MY CAR WAS ON FIRE. THE FIRST WITNESS TO SEE SOMETHING (A CO-WORKER) SAID HE SAW SOMETHING ON FIRE DROP FROM THE BOTTOM OF THE CAR. WHEN I RAN OUTSIDE, THE CAR WAS PUTTING OFF A SIGNIFICANT AMOUNT OF SMOKE. WE TRIED TO USE A FIRE EXTINGUISHER, TO NO END, AND WITHIN MINUTES WE WERE SEEING FLAMES. FIVE MINUTES LATER, THE FRONT OF THE CAR WAS ENGULFED IN FIRE. IT WAS FAST AND HOT. THE FIRE DEPARTMENT PUT IT OUT, BUT IT WAS A TOTAL LOSS. I HAVE PHOTO DOCUMENTATION OF THE EVENT. *TR

I DROVE THE CAR FOR LESS THAN A MILE AT CITY SPEEDS AND PROCEEDED TO PARK TO RUN ERRANDS. ABOUT 5 MINUTES LATER I NOTICED SMOKE COMING OUT OF THE ENGINE COMPARTMENT OF THE CAR, UPON CLOSER INSPECTION I REALIZED THE CAR WAS ON FIRE AND CALLED 911. BY THE TIME THE FIRE DEPARTMENT ARRIVED TO THE SCENE (ABOUT 5 MINUTES LATER) THE FIRE HAD SPREAD THROUGH THE VEHICLE. THE CAR SHOWED NO WARNING SIGNS BEFORE THE FIRE STARTED AND ALL SCHEDULED MAINTENANCE HAD BEEN PERFORMED. THE CAUSE OF THE FIRE IS TO BE DETERMINED. *TR

ENGINE OIL SPRAYING FROM CAMSHAFT CHAIN TENSION-ER SEAL. OIL WAS SPRAYING OUT UNDER PRESSURE. I WOULD CONSIDER THIS TO BE A FIRE HAZARD, AS HOT EXHAUST COMPONENTS ARE NEARBY. *TR

I HAVE A 2009 MINI COOPER S WITH 27,000 MILES. TWICE THE ENGINE VALVES HAS BEEN CLEANED BECAUSE OF EXCESS CARBON BUILD UP. JUST LOOK AT THE DISCUSSIONS ON THE WEB. SEEMS TO BE A MAJOR PROBLEM WITH CAR. *TR

2009 MINI S. FLYWHEEL AND CLUTCH BURNED UP AT 9000 MILES. WENT TO DEALER AND HAD TO HAGGLE TO GET THIS COVERED. THEY MADE ME SIGN OUT THAT IT WAS POSSIBLE IT WAS MY FAULT. I WOULD NOT SIGN IT. THIS ISSUE IS ON MANY OF THE 2009S. WHAT I DID WAS TO HOLD STRONG THAT ANY CAR AT 9000 MILES SHOULD NEVER USE UP A FLYWHEEL/CLUTCH AND IT WAS THEIR ISSUE WITHIN THE MODEL. *TR