2004 MINI COOPER Complaints

MY 2004 MINI COOPER S POWER STEERING PUMP JUST FAILED AND HAS TO BE REPLACED AFTER ONLY 45K MILES. *TR UPDATED 08-29/11 *BF

TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT STATED THAT THE POWER STEERING FAILED WHILE DRIVING APPROXIMATELY 45 MPH CAUSING LIMITED STEERING CAPABILITY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE POWER STEERING PUMP AND COLUMN WOULD NEED TO BE REPLACED. THE REPAIRS WERE PERFORMED AT THAT TIME. THE FAILURE DID NOT RECUR. THE MANUFACTURER OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 70,000.

NEAR THE END OF A 500 MILE TRIP FROM NORTHERN TO SOUTHERN CALIFORNIA, THE POWER STEERING FAILED. I COMPLETED THE TRIP WITHOUT THE POWER STEERING. THE NEXT DAY I TOOK THE VEHICLE INTO AN AUTHORIZED DEALER FOR REPAIR. THE POWER STEERING PUMP WAS REPLACED. THE OLD PART IS NOT AVAILABLE. *TR

TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING APPROXIMATELY 35 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED; THE FAILURE LASTED ANYWHERE FROM A FEW MINUTES TO 45 MINUTES. THE FAILURE OCCURRED SIX TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE DIFFERENT STEERING PARTS WERE REPLACED (THE CONTACT WAS UNSURE OF WHICH PARTS). THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 74,000. UPDATED 2/17/11 *CN

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT THE POWER STEERING INTERMITTENTLY MALFUNCTIONED CAUSING A LOSS OF POWER STEERING ASSIST CAPABILITIES. ON ONE OCCASION, THE CONTACT STATED THAT THE POWER STEERING COOLING FAN REMAINED ON AFTER THE VEHICLE WAS SHUT OFF AND DRAINED THE BATTERY. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE THE CONTACT WAS AWAITING REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 58,325.

I HAVE A 2004 MINI COOPER S BUILT IN LATE SEPTEMBER OR EARLY OCTOBER 2003. AT APPROXIMATELY 54,000 MILES IN SPRING OF 2010, I LEFT TO GO ON A TRIP ACROSS TOWN. AFTER ABOUT 2 MILES OF THE UP TO THEN NORMAL DRIVE, THE POWER STEERING SUDDENLY AND WITHOUT WARNING STOPPED WORKING IN THE MIDDLE OF A CURVE. FORTUNATELY I WAS ABLE TO RETAIN CONTROL OF THE CAR AND MAKE IT TO MY DESTINATION A COUPLE MORE MILES AWAY. AFTER SITTING ABOUT 15 MINUTES, UPON RESTART, THE CAR PERFORMED NORMALLY AS FAR AS I CAN TELL. CHECKING THE INTERNET, IT SEEMS THAT THIS IS A SOMEWHAT COMMON PROBLEM WITH THIS VEHICLE AND THAT IT WILL CONTINUE ON AND OFF UNTIL THE POWER STEERING DOES NOT FUNCTION AT ALL. THIS CAN ALSO LEAD TO A FIRE AT THE POWER STEERING PUMP THAT MAY LEAD TO COMPLETE LOSS OF VEHICLE AND OR ADDITIONAL PROPERTY DAMAGE. SOME WITH FIRES HAVE NOT HAD ANY PRIOR HINTS OF AN ISSUE AND SOME HAVE HAD THE INTERMITTENT PUMP GOING OUT. IN SPEAKING TO THE MINI SERVICE CENTER, THEY OF COURSE SAID THEY HAD NEVER HEARD OF THE PROBLEM AND REFUSED TO GIVE ME ANY HELP UNDER GOODWILL WARRANTY. I HAD THEM REPLACE THE PUMP AT MY EXPENSE TO AVOID THE RISK OF FIRE. *TR

1. POWER STEERING STARTED FAILING 2. OCCURS RANDOMLY THROUGHOUT MY DRIVING ~ DAILY 3. REPAIR/REPLACE POWER STEERING PUMP. *TR

TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING 5 MPH, THE CONTACT STATED THAT THE STEERING FAILED WHEN HE TRIED TO MAKE A RIGHT TURN. THE CONTACT WAS ABLE TO KEEP THE VEHICLE UNDER CONTROL AND PULLED OVER. THE CONTACT TURNED OFF AND RESTARTED IT; THE STEERING SEEMED TO RESET ITSELF. THE FAILURE SEEMED TO OCCUR WHEN THE ENGINE WAS HOT. THE DEALER STATED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 63,140.

TL* THE CONTACT OWNS A 2004 MINI COOPER. HE CONTACT NOTICED AN UNKNOWN FLUID LEAK ON THE GROUND UNDER THE VEHICLE WHILE PARKED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT POWER STEERING FLUID WAS LEAKING. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE MECHANIC REPLACED THE POWER STEERING PUMP, STEERING HOSE, PRESSURE HOSE, RETURN HOSE, AND THE SUCTION HOSE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS 61,400.

POWER STEERING FAILED WHILE DRIVING NORMALLY ON THE FREEWAY AND IT BECAME VERY DIFFICULT TO CONTROL THE CAR. POWER STEERING RETURNED AFTER LETTING THE CAR SIT IN A PARKING LOT, BUT FAILED AGAIN WHILE DRIVING HOME. WE HAVE NOT DRIVEN THE CAR SINCE. THE CAR IS OUT OF WARRANTY AND WE HAVE TALKED TO MINI, BUT THEY HAVE NOT OFFERED TO HELP REPAIR THE CAR. WE WERE TOLD THAT IT WILL COST AROUND $1500 TO REPLACE THE MALFUNCTIONING PARTS. *TR