2015 MINI COOPER Complaints

Unable to fill gas as pump repeatedly shuts-off while trying to fill and would even over flow out of the filler neck. Tried 2 different pumps at local QT without luck.. Drove up to local Phillips 66 with exact same issue. Found several other owner with similar issue and found the following Service Bulletin posted on "NHTSA": https://static.nhtsa.gov/odi/tsbs/2015/MC-10147283-9999.pdf My vehicle build date is not covered under this Service Bulletin, however, suffering exact same issue.

Crankshaft Pulley burnt while driving. Could not accelerate. Car threw overheating codes and AC blew hot air. Battery Charging Malfunction error shown as well.

The contact owns a 2015 Mini Copper The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the fuel tank needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure. The failure mileage was 78,000. The Vin was not available

Fuel tank did not allow me to input fuel. Pump clicked off immediately. MINI issued a service bulletin on the problem in 2015. I have been advised the entire fuel tank must be replaced, and have heard from other MINI owners this is a systemic problem. If I had been traveling and this problem had surfaced I would have been stranded. The repairs warrant warranty coverage on the part of MINI. See service bulletin SI M16 01 15. https://static.nhtsa.gov/odi/tsbs/2015/MC-10147283-9999.pdf

Engine Mount and right control arm bushings have cracked and need to be replaced below 60,000 miles and only being 4 years old.

CAR STARTED LEAKING OIL EVERYWHERE OUT OF NOWHERE WHILE BOTH MOVING AND STATIONARY. TWO DIFFERENT MECHANICS SAID IT WAS THE OIL FILTER HOUSING AND RELATED PARTS. REPLACED HOUSING, OIL PRESSURE SENSOR AND THE BOTTOM SCREW. WORKS AGAIN. CAR HAD UNDER 45,000 MILES AT TIME OF INCIDENT. SIMILAR PROBLEMS WITH THE OIL HOUSING HAVE BEEN REPORTED FOR OTHER AND RELATED MINIS, INCLUDING SOME SUBJECT TO RECALL.

TL* THE CONTACT OWNS A 2015 MINI COOPER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN PARK, THE GEAR SHIFTER FAILED TO ENGAGE PROPERLY. SECURE GEAR ROLL- A-WAY WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE GEAR BOX NEEDED TO BE REPLACED. MINI COOPER (8360 MIRAMAR PL STE A, SAN DIEGO, CA 92121, (858) 535-9999) WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT UNDER RECALL. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V789000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD NOT BEEN NOTIFIED THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000. THE VIN WAS NOT INCLUDED. ## VIN FAILED ## 2015 MINI COOPER ##

DRIVER SIDE REAR BRAKE LIGHT HAS A SHORT/OVER HEATS AND MELTS CONNECTOR TO THE BRAKE LIGHT HOUSING. NOTIFICATION PROMPTS YOU THAT YOU HAVE A BRAKE LIGHT MALFUNCTION. THE VEHICLE WAS IN MOTION ON A CITY STREET. THE VEHICLE HAS 15K MILES ON IT.

FUEL FILLING NOZZLE SHUTS OFF REPEATEDLY WHILE REFUELING. UPON GASSING UP, VALVE CLICKS IMMEDIATELY AND PUMP SHUTS OFF LIKE IT'S FULL NO MATTER WHICH GAS STATION OR PRESSURE I EXERT. I SAW A BULLETIN "SI M16 01 15" WHICH AFFECTED MINIS PRODUCED IN 2014 BUT DID NOT INCLUDE MY 2015 COOPER S. A COMMENT FROM THE BULLETIN HAD A TEMPORARY SOLUTION WHICH IS TO ANGLE THE PUMP TO 45, THEN PUMP SLOWLY AT THE MAGIC SPEED, THOUGH THIS CAN TAKE ANYWHERE FROM 10 TO 30 MINUTES. THIS IS DANGEROUS ON MY PART AS I TRAVEL PAST MIDNIGHT FOR SEVERAL HOURS AND SPENDING MORE TIME AT A GAS STATION IN THE DARK IS WORRISOME. I DO GET SPILLS OCCASIONALLY WHICH I HAVE TO KEEP WIPING AND IS A STATION HAZARD. REPLACING THE FUEL TANK COMPLETELY AT AN ESTIMATED $2K+ IS TOO COSTLY ESPECIALLY DURING THIS PANDEMIC AND IS DUE TO FAULTY MANUFACTURING.

12/19/19 I BROUGHT MY VEHICLE TO HAVE 2 FRONT TIRES REPLACED HAD THEM MOUNT AND BALANCED AND A FRONT ALIGNMENT DONE. THE DEALER ALSO COMPLETED MULTI POINT VEHICLE CHECK. I GET HOME. THE CAR SITS STILL SATURDAY. I START IT SATURDAY AT 1:30PM AND GET READY TO PULL OUT OF DRIVE WAY. WARNING LIGHT COMES ON DASH STATING BATTERY IS NOT CHARGING. STOP CAREFULLY. CONSULT NEAREST SERVICE CENTER. I CONTACTED SERVICE ADVISOR. HE STATED TO DRIVE IT BACK AND THEY WILL GIVE A LOANER. I SAID NO! THE VEHICLE ISN'T DRIVE ABLE AND I DON'T FEEL SAFE. HE STATED THEY CLOSE IN 30 MINUTES. I WANTED TO SPEAK TO UPPER MANAGEMENT. NO ONE WAS AVAILABLE HE STATED. I SAID I WOULD CALL BACK MONDAY DECEMBER23 2019. I SPOKE TO RECEPTIONIST WHO MAKES APPOINTMENTS. SHE HAD AVAILABLE SPOT ON THURSDAY DECEMBER26,2019. I TOLD HER I WILL HAVE IT TOWED THAT THURSDAY. I GET THERE TOLD THEM ABOUT THE MESSAGE THAT CAME ON DASH. I WAS GOING TO HAVE TO REPLACE BATTERY AND NEEDED A BRAKE FLUSH AND OH BY THE WAY LOOKS LIKE YOUR PULLEY WENT OUT. THE VEHICLE ONLY HAD 37,502 MILES. I HAVE NEVER HEARD OF A PULLEY BEING REPLACE AT THIS MILEAGE. I CONTACTED CUSTOMER RELATIONS FOR BMW MINI THAT FRIDAY. THEY SAID THEY WILL CONTACT IN 1 BUSINESS DAY. THEY DID SAY THERE IS AN OPEN CASE. THEY WILL CONTACT JAN 7. I WAS IN A LOANER FOR 6 DAYS. I SPOKE TO SERVICE MANAGER TUES 31,2019 WHICH WAS NEW YEAR'S EVE. SHE STATED THE DEALERSHIP WILL GIVE 20% DISCOUNT AND BMW MINI WILL STILL CONTACT ME IF THEY ARE GOING TO ASSIST. I MENTIONED TO THEM ABOUT THE DEFECTED PULLEYS ON 2002 THRU 2006 MODELS. THEY WILL LOOK INTO IT.