2015 MINI COOPER Complaints

Anytime the wipers are on and the speed is above 50 mph, this car periodically applies the brakes to keep the rotors dry. It's an automated system that BMW's and Mini's have. However, for some reason, the vehicle now pulls hard to the right, which veers the car into the other lane. The brake pads and rotors are all new. The tires are new and the alignment is good. The brake fluid was just changed and bled. There is literally nothing wrong except for this bizarre system which is now only applying some brake pressure to the front right rotor. The car slows and pulls right suddenly without applying the brake lights. I'm worried I will get rear ended or side swipe somebody. I've resorted to using Rainx and not using the wipers or simply avoiding driving in the rain. This is a serious issue that should be a recall. Thank you!

On my 2015 MINI Cooper Hardtop 4 Door (VIN: [XXX]), the driver's side halogen headlight suddenly stopped working. When I attempted to replace the bulb, I discovered that the headlight connector/pig tail had melted on one side, one of the electrical wires had burned completely through, and there was a strong odor coming from the rear of the headlight assembly. This was not simply a burned-out bulb. The connector and wiring sustained heat damage that appears to have resulted from an electrical failure. Because of the melted connector, burned wiring, and strong burning small, I believe this created a potential fire hazard. It must be noted that there have not been any changes to the lighting or electrical system since purchasing my car and I am the first and only owner. I contacted my mini dealership and was informed that the connector is not available separately for my year, make, and model for my car and the only option is the purchase the entire headlight assembly. The cost for the assembly is $615 and while the exact charge for labor is not known at this time, from my experience, it will be between $200-$500. After researching his issue. I found reports from other MINI owners describing similar failures involved melted headlight connector and burned wiring on vehicles with halogen headlights. Based on these reports and my own experience, I am cornered this may represent a recurring safety-related defect rather than normal wear and tear. I am submitting this complaint so NHTSA can evaluate whether this issue warrants investigation. I have photographs documenting the melted connector, burned wiring, and resulting damage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear windshield fell out of the top of my convertible. There was no accident or foul play involved. The glue that bonds the window to the top became unglued. This happened at 70,000 miles. The top is made of fabric and the window is made out of glass. Have to you replace the entire top to repair it. Not sure why this is not a recall. It is a well-known problem for the car.

The fuel filling nozzle turns off repeatedly (as if already full) while filling the fuel tank. About 1/4 to 1/3 of a gallon of fuel will go in before it turns off, backs up, and the gas overflows onto the outside of the car and onto the concrete. It happens regardless of the pump being used. It started happening occasionally a few months ago if the tank was refilled when a quarter full. It now happens consistently, no matter the fuel level. I had the car put on a lift and the system diagnosed today. The mechanic said the cause is a faulty service valve within the fuel tank assembly. They also said it is a known issue with F56 Mini Coopers.

Selector lever wrongly not locked in park. Put up a code for transmission (egs). I believe it falls under the transmission control unit recall on mini coopers 2 door hardtop.

The back window comes unglued to the convertible top when the car is parked outside in warm weather. Ive seen this in several other mini cooper roadsters within the past few weeks. This causes the car to have a hole in the convertible top and leaves the glass hanging from the sensor. To fix it you need to buy a whole new top. This HAS to be a design defect.

Lower Engine Support and Passenger Engine Mount damaged as per routine inspection by dealer in Feb2025. Never diagnosed before. Repair done by independent service center in Feb2025 and I have receipt of approximately 1K. Also, since 22feb2025, I am not able to add fuel to the tank because the pump stops constantly and causes spill of fuel. This can cause fire. Never happened before. Tried at least 4 different gas station and same result. Dealer charges over $200 to perform inspection/diagnostics. Not done yet. Repairs to fuel tank are in the thousands. No warning in the car dashboard for none of the issues. Car with less than 80k miles.

While driving in the rain (light rain) front right and rear left brakes locked up. No warning lights came on, it was a very dangerous situation. The car is currently at a repair shop getting looked at, I had to have it towed there because those wheels will not turn while in neutral even. Reading forums this is a common problem, very serious and dangerous especially with no warning.

Defect in passenger frontal airbag-The front passenger seat occupancy detection mat is not functioning correctly. This was recalled but not for my VIN and needs to be part of the recall.

While driving the rear view mirror suddenly tilted downward (drooped). What happened, was that the tension ring popped off. As it turns out, this is a known issue per internet Mini Cooper pages. On hot days the ring loosens and, since the design does not include anything to prevent the ring from sliding off, it does slide off, resulting in the rear view mirror drooping. I reinstalled the ring. This occurred again the next day. I ended up uninstalling the rear view mirror, reinstalling the ring and gluing it in place. Thus far this has held.