2009 MINI COOPER S Complaints

ONCE YOU SEARCH THE 'DEATH RATTLE' ON GOOGLE, YOU CAN GET LOTS OF INFO ABOUT WHAT IS GOING ON AND THE DEATH RATTLE IS REALLY COMMON ON THE R56. IT IS REALLY A COMMON PROBLEM AND MINI SHOULD TAKE THE RESPONSIBILITY OF THAT. *TR

TOOK VEHICLE IN FOR INSTALLATION OF THE HEAT SHIELD FOR TURBO FEED LINE. THIS IS A RECALL AND NEWLY INSTALLED PART TO PROTECT THE TURBO FEED LINE DUE TO OVERHEATING. ONCE IT WAS INSTALLED I WAS INFORMED THAT THE TURBO LINE IS FAILING AND THE DEALER WANTS TO CHARGE ME $1500 TO REPAIR THE LEAKING LINE. THE FAILURE OF THE LINE IS OBVIOUSLY DUE TO EXCESSIVE HEAT AROUND THIS LINE... THE SAME REASON THEY ARE INSTALLING A HEAT SHIELD. THIS IS RIDICULOUS AND THE ITEM SHOULD BE RECALLED AND REPLACED! *TR

WHILE IDLING AT A RED LIGHT, VEHICLE RPMS VARIED DRAMATICALLY AND THE ENGINE SHUT OFF. VEHICLE WAS ABLE TO BE RESTARTED AND MOVED WITH THE CHECK ENGINE LIGHT ILLUMINATED. UPON FURTHER INVESTIGATION THE VALVE COVER WAS FOUND TO HAVE A VACUUM LEAK, WHICH HAS BECOME A COMMON ISSUE WITH MINI COOPER S MODELS. *TR

DURING LIGHT ACCELERATION AT INTERSTATE SPEEDS, THE ENGINE LOST SOME POWER AND THE SERVICE ENGINE LIGHT CAME ON. THE DEALER FIRST REPLACE THE VACUUM HOSES. IT HAPPENED AGAIN, THE DEALER REPLACED THE VACUUM PUMP. IT HAPPENED AGAIN IMMEDIATELY, THE DEALER REPLACED THE TURBOCHARGER UNIT BECAUSE THE WASTEGATE WON'T CLOSE COMPLETELY. THE TURBOCHARGER AND WASTEGATE SHOULD LAST MUCH LONGER THAN 5 YEARS (THE CAR WAS DELIVERED IN APRIL 2009) OR 70,000 MILES. *TR

THIS HAPPENED TWICE, THE FIRST TIME IT WAS COVERED UNDER THE WARRANTEE. I WAS DRIVING AT NIGHT AND HIT A POTHOLE. I NOTICED THAT MY LEFT FRONT HEADLIGHT WAS POINTED AT THE ROAD. WHEN I GOT HOME I NOTICED THAT THE HOLE ASSEMBLY INSIDE HAD BEEN DISENGAGED AND IS POINTED DOWN. THERE IS NO WAY TO ADJUST IT AND SINCE I WAS NOT COVERED BY THE WARRANTEE I DECIDED TO OPEN THE UNIT. I FOUND THAT THE SMALL PLASTIC PART THAT HOLDS THE INNER LIGHT ASSEMBLY FROM FALLING PULLED APART. I WOULD THINK THAT THIS MUST BE TESTED AND THEREFORE I MUST HAVE A DEFECTIVE UNIT. I CONTACTED MINI WHO SENT ME TO THE DEALER AND SAID THAT THEY WOULD LOOK INTO IT. IT HAS BEEN A COUPLE OF MONTHS AND I HAVE NO RESOLUTION. IF THIS HAPPENED TO ME TWICE I THINK THERE MUST BE OTHER UNITS THAT HAVE FAILED THIS WAY. IS THIS CAUSE FOR A RECALL? *TR

ENGINE ALL OF A SUDDEN STARTS MAKING A RATTLING NOISE. TOOK IT IN TO DEALER, TIMING CHAIN GUIDES HAD BROKEN AND CHAIN WAS STRETCHED. WAS INFORMED THERE WAS A MINI CAMPAIGN ABOUT THIS BUT MY VEHICLE WAS NOT INCLUDED. EXPENSIVE REPAIR AND POTENTIALLY DANGEROUS SITUATION IF CHAIN HAD BROKEN. WAS INFORMED AFTER WORK WAS DONE THAT CLUTCH WAS BAD AS WELL. HAD DRIVEN THE VEHICLE THE DAY BEFORE WITHOUT ISSUE BUT AFTER ONLY 10 MILES FROM THE DEALERSHIP CAR WOULD NOT MOVE FROM STOPPED SINCE CLUTCH WOULD NOT ENGAGE. EXTREMELY EARLY FOR THIS AMOUNT OF REPAIRS TO BE NEEDED, I QUESTION THE DURABILITY OF THESE PARTS AND THIS BRAND. BOTH OF THESE SUDDEN WEAR FAILURES COULD HAVE BEEN EXTREMELY DANGEROUS IF THEY HAD OCCURRED ON THE HIGHWAY. *JS

TURBO OIL FEED LINE LEAKING ONTO ENGINE/MANIFOLD. POSSIBLY COULD HAVE CAUSED A FIRE. *TR

DRIVING ON 405 FWY IN SOUTHERN CALIFORNIA TURNING OUT OF FREEWAY OFF RAMP IN THE POURING RAIN. THE CAR DEAD STOPPED. VERY DANGEROUS, CARS COMING OFF FREEWAY BEHIND ME WAS A 911 SITUATION. AFTER SOMEONE PUSHED ME OFF TO THE SIDE OF THE ROAD HAD CAR TOWED. NO ENGINE LIGHT WARNING TO INDICATE PROBLEM OF TENSIONER (TIMING CHAIN BREAKAGE). ENTIRE ENGINE WAS REPLACED/REBUILT BECAUSE OF EXTENSIVE DAMAGE TO ENGINE. BMW APPARENTLY IS AWARE OF THE TIMING CHAIN DEFECT AND HAS NOT ISSUED SERVICE BULLETIN OR RECALL. I'M HEARING THERE IS A CLASS ACTION SUIT BECAUSE OF THE MANY COMPLAINTS. THE FACT THAT I COULD HAVE VERY EASILY BEEN KILLED OR SERIOUSLY INJURED IS WHY I AM ISSUING A COMPLAINT (NOT TO MENTION MY BILL FOR $6200.00 I HAVE ON MY CREDIT CARD) AND THE THREE WEEKS IT TOOK TO FIX. NATURALLY I WAS 6 MONTHS OUT OF MY WARRANTY. *TR

THE PROBLEM FIRST STARTED AS A NOISE WHEN STARTING THE ENGINE IN THE COLD. THIS "RATTLE" NOISE WOULD CONTINUE UNTIL THE ENGINE GOT A BIT WARMER AND THEN WOULD GO AWAY. EVERYTIME THE ENGINE STARTED COLD THE NOISE WOULD COME BACK. I TOOK MY (NOW OUT OF WARRANTY) CAR TO THE MINI DEALERSHIP FOR INSPECTION AND REPAIR AND THE TENSIONER WAS REPLACE. UNFORTUNATELY THE REPAIR DID NOT LAST LONG. ONLY 2 MONTHS LATER THE NOISE RETURNED. I AM STILL LIVING WITH THIS "RATTLE" NOISE HOPING MY CAR DOES NOT BURST INTO FLAMES WHILE DRIVING. I CAN NOT AFFORD THE (OVER $1000) QUOTE FOR REPAIRING THE TIMING CHAIN ASSEMBLY AT THIS TIME. I FEEL, AFTER READING THROUGH MANY MANY COMPLAINTS ON THE INTERNET, THAT THIS SHOULD BE A RECALL AND ALL TIMING CHAINS OF THESE VEHICLES SHOULD BE REPLACE. THERE IS NO REASON THAT A CAR WITH LESS THAN 75,000 SHOULD NEED A NEW TIMING CHAIN! I HAVE NEVER USED ANYONE BUT MY LOCAL MINI DEALER TO FIX ANY ISSUE WITH MY CAR, I FEEL THAT MINI HAS LET ME DOWN. I WILL BE LOOKING INTO JOINING THE CLASS ACTION LAWSUIT AGAINST MINI. *TR

I WAS DRIVING HOME FROM WORK ON US 75 SOUTH (DOWNTOWN DALLAS) AND THE VEHICLE (2009 MINI COOPER S) JUST STOPPED, AND ALL OF THE OIL WAS LEAKING OUT FROM UNDERNEATH THE CAR. I RECENTLY FOUND OUT THE ISSUE IS WITH A MINI ISSUE RELATING TO THE TENSIONERS/TIMING CHAIN. *TR