2004 MINI COOPER S Complaints

TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE POWER STEERING WOULD SEIZE. THIS FAILURE RECURRED ON AN INTERMITTENT BASIS. THE VEHICLE WAS NOT INSPECTED NOR REPAIRED FOR THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000. THE VIN WAS UNAVAILABLE.

FAILED STEERING PUMP ASSEMBLY ON 2004 COOPER S WITH 60K MILES. FAILURE OF STEERING PUMP ASSEMBLY CREATED LOSS OF STEERING AND INDUCES UNSAFE DRIVING SCENARIO. FROM THE SHOWROOM, THIS VEHICLE (AND OTHERS OF THIS ERA) HAS PROVIDED A UNIQUE WHINE FROM THE POWER STEERING ASSEMBLY. THE DEALER WOULD LATER INFORM ME THAT THIS WAS NORMAL TO THE BMW MINI LINE. YEARS LATER THIS FEATURE HAS BECOME A KNOWN PROBLEM AND IS CONFIRMED AND BEING INVESTIGATED BY THE NHTSA. BMW (THE MANUFACTURER) HAS YET TO ACKNOWLEDGE OR DEVELOPED A REPAIRABLE SOLUTION TOWARDS THIS FLAWED CHARACTERISTIC. ANOTHER TOYOTA IN THE MAKING?.. I HOPE NOT. *TR

1)WHILE DRIVING MY CAR IN NORMAL WARM DAY TEMPERATURES IN DENVER, CO MY POWER STEERING ABRUPTLY FAILED MAKING IT DIFFICULT TO CONTROL MY CAR. 2)HAS STAYED FAILED 3)WILL HAVE TO GET A REBUILT OR NEW PUMP. *TR

I WAS DRIVING TO WORK, ON A WINDY ROAD WHEN MY CAR LOST IT'S POWER STEERING. THE GARAGE HAS TO REPLACE THE POWER STEERING PUMP, FAN AND STEERING RACK FOR A TOTAL COST OF ABOUT $3,000! I WAS VERY LUCKY TO HAVE NOT RUN OFF THE ROAD. *TR

THE POWER STEERING IN MY 2004 MINI COOPER S FAILED, LEADING TO EXTREMELY DIFFICULT OPERATION OF THE VEHICLE. CAR WAS UNDER EXTENDED WARRANTY BUT FAILURE NOT COVERED.

2004 MINI COOPER S FIRST HAD AN ISSUE THAT DRAINED THE BATTERY. ONCE POWER WAS RESTORED AND THE CAR WAS DRIVEN AND THEN SHUT OFF, THERE WAS A WHIRRING NOISE, SIMILAR TO A FAN RUNNING, THAT CONTINUED AFTER THE KEY HAD BEEN REMOVED FROM THE IGNITION. THIS NOISE AND THE APPARENT POWER DRAIN CONTINUES UNTIL THE BATTERY IS DRAINED ONCE MORE. FOLLOWING THESE ISSUES, THE MINI BEGAN TO BECOME MORE AND MORE DIFFICULT TO STEER. IT IS DIAGNOSED AS A POWER STEERING FAILURE THAT IS APPARENTLY COMMON AMONG THIS GENERATION OF MINI COOPER. NO ACCIDENTS, INJURIES, OR FIRES HAVE OCCURRED DUE TO THIS FAILURE, HOWEVER THE CAR IS NOT SAFE TO DRIVE UNTIL PARTS ARE REPLACED. *TR

THE STEERING PUMP COOLING FAN STARTED TO FAIL AND HAD TO BE REPLACED. THE DEALERSHIP ALSO STATED THE STEERING RACK WAS LEAKING FLUID AND WAS GOING TO NEED REPLACEMENT AT A COST OF OVER $1,000.00.

I PURCHASED MY 2004 MINI COOPER S 5 MONTHS AGO. I WAS TOLD BY THE DEALER EVERYTHING WORKED FINE ON THE CAR. THERE WAS A WHINING NOISE IN THE CAR, WHICH HE TOLD ME WAS NORMAL ON MIN COOPERS. I WAS DRIVING FROM BOISE, ID TO OLYMPIA, WA IN MY 2004 MINI COOPER S. THEN SUDDENLY, ABOUT 200 MILES INTO MY TRIP, WHILE I WAS OVER TAKING A SEMI TRUCK ON A RIGHT HAND CURVE. MY POWER STEERING TIGHTENED AND I HAD TO HOLD ON REALLY TIGHT. I ALMOST RAN INTO THE SIDE WALL. AFTER FURTHER INVESTIGATION I FOUND THAT MY POWER STEERING HAD DIED. IT SEEMS THAT THERE SHOULD BE SOME KIND OF SAFE WAY FOR THE POWER STEERING TO DIE. LOOSING POWER STEERING THE WAY IT DID, AND HOW HARD IT IS TO TURN THE STEERING WITHOUT THE PUMP SOUNDS VERY SCARY. I DROVE DOWN STEEP HILL WITH SHARP CURVES DURING THE TRIP AND I'M SO GLAD THE PUMP DIDN'T DIE THEN. I THEN DROVE THE REST OF THE WAY CAREFULLY AS POSSIBLE WITHOUT THE POWER STEERING. NOW I KNOW THAT THE WHINING NOISE WAS FROM THE POWER STEERING SINCE THE WHINING NOISE WENT AWAY ONCE THE POWER STEERING DIED. IT SEEMS THAT THIS IS A COMMON ISSUE WITH OTHERS AS WELL. NOW MY CAR IS PARKED AND I'M NOT SURE IF I SHOULD REPLACE THE PART OR NOT. I FEEL BMW SHOULD TAKE SOME INITIATIVES TO FIX THIS ISSUE. *TR

UNABLE TO OPEN THE DRIVER'S DOOR FROM THE INSIDE; IMMEDIATE FAILURE. AT ABOUT 36,000 MILES AND AGAIN AT 60,000 MILES, THE DRIVER'S DOOR COULD ONLY BE OPENED BY PULLING ON THE INSIDE DOOR HANDLE MULTIPLE TIMES OR OPENING THE WINDOW & USING THE OUTSIDE HANDLE. THE ISSUE APPEARS TO BE A CABLE THAT COMES OFF A PULLEY IN THE OPENING MECHANISM. THE DEALER REPLACED THE CABLE IN ITS PROPER POSITION; THE FIX LASTED ABOUT 2 YEARS BEFORE RE-OCCURRING CAUSING THE CAR TO FAIL STATE SAFETY INSPECTION. THIS IS A PROBLEM KNOWN TO MINI/BMW AND IS REPORTED IN MANY ONLINE MINI COOPER FORUMS. *TT

LOSS OF POWER STEERING ASSIST WHILE DRIVING MAKING IT DIFFICULT TO STEER THE CAR. AT TIMES, THERE WOULD BE NO POWER STEERING ASSIST; RESTARTING THE CAR WOULD SOLVE THE ISSUE. ULTIMATELY, THE ISSUE APPEARED TO BE A BUILT-IN ELECTRICAL RELAY IN THE ELECTRIC POWER STEERING PUMP THAT STICKS. ONLY REPLACEMENT OPTION WAS TO REPLACE THE ENTIRE PUMP. *TT