2009 MINI COOPER S Complaints

DRIVING VEHICLE HEARD SOME ENGINE NOISE AND OBSERVED RED OIL INDICATOR CAME ON. PULLED OVER AND CHECKED OIL LEVEL, APPEARED TO BE LOW.. I IMMEDIATELY PUT IN TWO QUARTS OF OIL ONLY TO SEE IT ALL SEEP OUT AND THROUGH BOTH FRONT WHEEL WELLS. APPEARED TO BE AN ISSUE WITH THE TIMING CHAIN TENSIONER. *TR

CHECK ENGINE LIGHT CAME ON AND THERE WAS BIG DECLINE IN PERFORMANCE. ALSO, THE ENGINE HAS BEEN MAKING A RATTLING SOUND LIKE A DIESEL ENGINE FOR SEVERAL MONTHS NOW WHEN THE ENGINE IS COLD. THE CAR JUST EXCEEDED ITS 50,000K MILE WARRANTY, OF COURSE. I TOOK THE CAR IN FOR SERVICE AT AN INDEPENDENT DEALER. GOT A CALL TODAY SAYING THAT MY TURBO NEEDED TO BE REPLACED AT THE TUNE OF ABOUT $2700! ALSO, THE TIMING BELT NEEDS TO BE REPLACED AT A TUNE OF ABOUT $1300. I SPOKE WITH THE TECHNICIAN AND HE TELLS ME THAT HE SEES THESE PROBLEMS IN BMW/MINI ALL TOO FREQUENTLY ON VEHICLES WITH LOW MILEAGE. HE SAYS MINI KNOWS THERE IS A PROBLEM WITH THE ORIGINAL TIMING BELT SO MINI DOESN'T EVEN MAKE THAT MODEL OF TIMING BELT ANYMORE. HE SAID THEY ALSO KNOW THERE IS A PROBLEM WITH THE OIL SUPPLY LINE TO THE TURBO BEING TOO CLOSE TO THE EXHAUST WHICH COOKS THE OIL AND CLOGS THE LINE WHICH EVENTUALLY LEADS TO OIL STARVATION FOR THE TURBO. MINI RECOMMENDS OIL CHANGES AT 15,000 MILE INTERVALS WHICH COULD ALSO BE AN ISSUE BUT I'VE READ ABOUT PEOPLE WHO HAD THE OIL CHANGED EVERY 5,000 MILES AND STILL HAD PROBLEMS. MINI HAS RECALLED THE AUXILIARY WATER PUMP ONLY BECAUSE IT BECAME A SAFETY ISSUE. MY CAR IS DEFECTIVE AND OUTSIDE OF THE WARRANTY SO NOW I'M STUCK WITH A $5500 BILL FOR REPAIRS. *TR

RECALL CAMPAIGN NO: 12V-008 ELECTRIC AUXILIARY WATER PUMP HTTP://WWW-ODI.NHTSA.DOT.GOV/DEFECTS/RESULTS.CFM THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WEBSITE SAYS WE ARE ALSO NOTIFIED TO TAKE THE VEHICLE TO A BMW DEALER FOR REPAIR. WHY CANNOT I NOT DO THIS? WE HAVE A BMW DEALER IN BOISE. OWNERS OF THE RECALLED VEHICLES ARE NOTIFIED TO TAKE THEIR VEHICLE TO A BMW DEALER, WHO WILL REPLACE THE AUXILIARY WATER PUMP TO PREVENT ANY INCIDENTS RELATED TO THIS ISSUE. THIS PRELIMINARY EVALUATION IS CLOSED. THE ODI REPORTS CITED ABOVE CAN BE VIEWED AT WWW-ODI.NHTSA.DOT.GOV/COMPLAINTS UNDER THE FOLLOWING IDENTIFICATION NUMBERS (ODI NOS.): 10286597, 10286663, 10289793, 10310677, 10314796, 10342365, 10394808, 10394192, 10403982, 10418325, 10422646, 10429003. I CANNOT TELL YOU HOW MANY HOURS I HAVE SPENT ON THE PHONE WITH MINI, MINI OF MURRAY, AND MINI ROADSIDE ASSISTANCE, MY LOCAL BMW DEALER, AND SEVERAL REPAIR SHOPS AND A TOW TRUCKING COMPANY.MINI IS COMPLETELY LEAVING THOSE CUSTOMERS IN THE LURCH THAT DO NOT HAVE MINI DEALERS IN THEIR STATE. NOW MINI OF MURRAY IS TELLING ME THAT IF I FIX MY CAR IN BOISE AFTER I HAVE RECEIVED THE RECALL NOTICE THAT I AM STILL ON THE HOOK FOR PAYING FOR THIS EVEN IF A MINI DEALER WERE TO INSPECT THE REPAIR FROM ANOTHER REPAIR SHOP. HOW IS THIS LEGAL? ALL I WANT IS TO HAVE THE REPAIR DONE AS SOON AS POSSIBLE AND BE REIMBURSED FOR IT, WITHOUT HAVING TO DRIVE A POTENTIALLY DANGEROUS VEHICLE 700 MILES TO DO IT. IT'S A SERIOUS WASTE OF RESOURCES, TIME AND MONEY! SOMEONE PLEASE DO SOMETHING TO MAKE THIS RIGHT WITHOUT TELLING ME THAT THERE'S NOTHING THEY CAN DO.? *TR

THE TIMING CHAIN TENSIONER BACKED OUT DURING MORNING COMMUTE AND THE CAR LOST ITS OIL AND CAME TO A COMPLETE STOP. THIS IS A RECURRING PROBLEM THAT MINI SHOULD ADDRESS WITH A RECALL! *TR

THIS ALL STARTED LATE 2009 OR EARLY 2010 WHEN I STARTED MY MINI AND IT SOUNDED LIKE A DIESEL INSTEAD OF A GAS ENGINE, AFTER THE CAR RAN A FEW MINUTES THE RATTLING SOUND DISSIPATED. I CONTINUED TO HEAR THIS DAILY DURING COLD STARTS SO I CONTACTED A MINI DEALER WHO INSTRUCTED ME THAT THERE WAS A RECALL IN THE WORKS FOR FAULTY TIMING CHAIN TENSIONERS BUT THE PARTS WERE NOT AVAILABLE YET SO CONTINUE TO DRIVE IT SINCE IF OTHER THINGS FAIL IT IS UNDER WARRANTY. AFTER A FEW WEEKS THE TENSIONERS WERE REPLACED AND EVERYTHING SOUNDED NORMAL AGAIN. THEN I RECEIVED ANOTHER RECALL NOTICE CONCERNING POSSIBLE FIRES IN THE WATER COOLER FOR TURBO? BEFORE I COULD GET THE VEHICLE IN FOR THE RECALL, IN SEPTEMBER OF 2012 I NOTICED A VERY LOUD METALLIC RATTLE AND EXTREME LOSS OF POWER AT 2,000RPM COMING FROM THE PASSENGER SIDE OF THE ENGINE COMPARTMENT AND ASSUMED IT WAS THE RECALL CAUSING THE ISSUE. I TOOK THE MINI IN FOR THE RECALL OCT 13, 2012 AND MENTIONED THE LOUD RATTLE NOISE-POWER ISSUE, AFTER HAVING MY CAR TWO DAYS THE DEALER INFORMS ME THAT THE TENSIONERS/TIMING CHAIN IS OUT OF SPECIFICATIONS AND CREATING THE EXTREME NOISE AND POWER LOSS. DEALER IS REQUESTING $2500.00 TO REPAIR SOMETHING THAT OBVIOUSLY HAS BEEN/IS AN ISSUE WITH MINI CARS. I WRITING YOU BECAUSE THIS SITUATION WAS SCARY WHEN I WAS TRYING TO ACCELERATE IN FAST FLOWING TRAFFIC CONDITIONS OR CROSSING TRAFFIC AND THE POWER WOULD CUT OUT AT 2,000RPM LEAVING ME SHORT SHIFTING AND STRUGGLING NOT TO CAUSE A WRECK. IT REALLY NEEDS INVESTIGATED SINCE THERE ARE SO MANY COMPLAINTS AND SAFETY CONCERNS. THANK YOU. *TR

THE TIMING TENSIONER ON MY MINI COOPER S BACKED OUT, RESULTING IN A MASSIVE OIL LOSS WHILE AT HIGHWAY SPEEDS. THIS IS APPARENTLY A KNOWN ISSUE BY MINI, BUT NO KNOWN RECALL HAS BEEN ISSUED AT THIS POINT. *TR

NOTICED A LOUD RATTLING NOISE COMING FROM THE FRONT PASSENGER SIDE AFTER A COLD START. THE NOISE WENT AWAY AFTER DRIVING FOR ABOUT A MINUTE SO, IT WAS ATTRIBUTED TO THE SAME LOUD NOISE THAT MINIS MAKE AFTER COLD STARTS. HOWEVER, NOTICED THAT THE NOISE SEEMED LOUDER THAN NORMAL AFTER A COUPLE OF OTHER COLD STARTS AND DECIDED TO TOW THE CAR IN AFTER THE CHECK ENGINE LIGHT (YELLLOW) CAME ON AND THE ENGINE WAS JERKY (AS THOUGH THE ENGINE WAS ABOUT TO STALL). DROVE THE CAR HOME WITH NO INCIDENT (ABOUT 5 MILES). I TOWED THE CAR TO THE DEALERSHIP THE NEXT DAY AND WAS TOLD THE TIMING CHAIN GUIDE(S) BROKE AND DISINTEGRATED INTO THE OIL PAN. ENGINE POSSIBLY NEEDS TO BE REPLACED. A QUICK SEARCH ONLINE AND ON THIS SITE SHOWS THIS HAS HAPPENED TO A LOT OF MINI OWNERS (SINCE 2008) AND COMPLAINTS HAVE BEEN FILED. WHY AREN'T THERE RECALLS YET???? *TR

CAR STOPPED ACCELERATING AS I WAS DRIVING (TWICE THIS HAS HAPPENED - IN A BEND IN THE ROAD--VERY SCARY). ALSO, AROUND THIS TIME, COULD NOT START UP THE CAR--CAR ENGINE WAS ATTEMPTING TO TURN OVER BUT WOULDN'T UNTIL ABOUT MY 6TH ATTEMPT. I NEVER HAD PROBLEMS STARTING MY CAR BEFORE. I MIGHT ADD THAT RECENTLY, BEFORE I HAD THIS PROBLEM, I HAVE NOTICED THAT MY VEHICLE DOES NOT HAVE THE FAST PICK UP THAT IT USE TO. *TR

WATER PUMP FOR TURBOCHARGER REPLACED IN MAY (RECALL) AND TURBOCHARGER WARRANTY EXTENDED VIA MINI OF AMERICA LETTER. TURBOCHARGER FAILED IN AUGUST, BUT MINI OF AUSTIN BLAMED FAILURE ON LACK OF OIL CHANGES. ALL OIL CHANGES PERFORMED BY THAT DEALERSHIP WHENEVER THE CAR TOLD US IT WAS DUE. CRAPPY RESPONSE FROM MINI OF AMERICA AS WELL. *TR

PURCHASED USED VEHICLE IN JUNE 2012. ON TODAYS DATE, UPON COLD START VEHICLE BEGAN MAKING KNOCKING NOISES AS IF LIFTERS WERE INVOLVED. AS CAR WARMED UP NOISE BECAME LESS APPARENT, BUT PROMPTED ME TO TAKE TO LOCAL MECHANIC. MECHANIC ADVISED THAT TIMING CHAIN NEEDS ADJUSTING/REPLACING AND NEEDS TO GO TO DEALER (AN HOUR TRAVEL). UPON PERUSING WEB INFO ON VEHICLE AND YEAR, THIS ISSUE APPEARS TO BE A PREVALENT MAFUNCTION IN THIS VEHICLE CAUSING MAJOR ENGINE FAILURE. *TR