2007 MINI COOPER S Complaints

2007 MINI COOPER S SPONTANEOUSLY CAUGHT FIRE WHILE TURNED OFF AND PARKED IN MY GARAGE. I HAD TRAVELED LESS THAN TWO MILES WHEN I PARKED THE CAR. FIRE STARTED UNDER THE HOOD AND COMPLETELY TOTALED THE CAR BY THE TIME THE FIRE DEPARTMENT ARRIVED AND PUT IT OUT. *TR

2007 MINI COOPER S - MANUAL TRANSMISSION WOULD NOT ALLOW GEARSHIFTS AND COULD ONLY BE DRIVEN IN FIRST GEAR. DEALERSHIP STATED CLUTCH CAME APART AFTER 8 MONTHS OF OWNERSHIP. DEALERSHIP REPLACED WITH REMANUFACTURED CLUTCH, FLYWHEEL, GEARBOX OIL AND CLIP UNDER WARRANTY. IN JULY OF 2009 I NOTICED THAT THE TRANSMISSION WAS SHIFTING ROUGH AND THE CLUTCH WAS MAKING A SQUEAKING SOUND WHEN APPLIED. DEALERSHIP GOT A WORK ORDER FROM MINI USA TO REMOVE THE CLUTCH/TRANSMISSION. ON AUGUST 12, 2009 THE DEALERSHIP REMOVED THE CLUTCH/TRANSMISSION AND REPLACED THE PLASTIC PART CAUSING THE NOISE, BUT NOTICED THE FLYWHEEL HAD HEAT DAMAGE AND CRACKING AGAIN. THIS TIME THE DEALERSHIP AND MINI USA STATE THAT THIS WAS CAUSED BY "WEAR AND TEAR" AND NOT COVERED UNDER THE MANUFACTURES WARRANTY DESPITE BEING COVERED 15K MILES EARLIER. CURRENT MILES ON VEHICLE ARE 31K WITH 19K REMAINING ON MANUFACTURERS WARRANTY. *TR

PASSENGER AIRBAG LIGHT COMES ON INDICATING THAT THERE IS A FAULT WITH THE AIRBAG SYSTEM AND THE SYSTEM IS INACTIVE. *TR

I PURCHASED A 2007 MINI-COOPER S AND AT 10K MILES (1 YEAR OLD) THE CLUTCH NEEDED TO BE REPLACED. I DON'T UNDERSTAND HOW A NEW CAR WITH 10K MILES NEEDS A NEW CLUTCH. THE DEALERSHIP AND THE MANUFACTURER BOTH SAID IT WAS MY FAULT AND THERE WAS NOTHING WRONG WITH THE CAR. THEY QUOTED ME OVER $3K TO REPAIR. I HAVE BEEN DRIVING MANUAL CARS FOR 15 YEARS AND HAVE NEVER HAD A PROBLEM WITH A CLUTCH. *TR

VERY NOISY CLATTER WHEN STARTING ENGINE WHEN COLD. ENGINE SOUNDS LIKE A DIESEL WHEN COLD. GOES AWAY AFTER A COUPLE OF MINUTES. DEALER SAYS ITS NORMAL ??? PROBLEM OCCURS EVERY MORNING. *TR

ENGINE EXHIBITS HARSH NOISE DURING STARTUP 50% OF THE TIME AFTER MINIMUM OF 8 HR SHUTDOWN OR IF PARKED NOSE LOW. THE ISSUE IS A DEFECTIVE TIMING CHAIN TENSIONER WHICH THE DEALER WON'T REPLACE BECAUSE 1) THEY HAVEN'T RECEIVED AN EFFECTIVE REPAIR KIT FROM BMW OR 2) TRY TO EXPLAIN IT AWAY WITH THE EXCUSE THAT THIS TIMING CHAIN METAL-ON-METAL RATTLE IS "NORMAL." AN INCREASING WORLD-WIDE NUMBER OF VEHICLES OF THIS MAKE, MODEL, AND ENGINE HAVE EXPERIENCED CATASTROPHIC LOW MILEAGE ENGINE FAILURES BECAUSE OF DEALER INACTION AND SUBSEQUENT TIMING CHAIN FAILURE. *TR

ENGINE EXHIBITS HASH NOISE DURING STARTUP 50% OF THE TIME AFTER MINIMUM OF 8 HR SHUTDOWN AT BELOW FREEZING TEMPERATURES. THE ISSUE IS A DEFECTIVE TIMING CHAIN TENSIONER WHICH THE DEALER WON'T REPLACE BECAUSE 1) THEY CAN'T REPRODUCE THE STARTUP NOISE OR 2) THIS IS "NORMAL." OTHER VEHICLES OF THIS MAKE, MODEL, AND ENGINE HAVE EXPERIENCED CATASTROPHIC ENGINE FAILURES BECAUSE OF DEALER INACTION AND SUBSEQUENT TIMING CHAIN FAILURE. *TR

ENGINE NOISE ON COLD STARTS. MY CAR HAS MADE DIESEL LIKE NOISES ON COLD START UP FOR THE PAST YEAR. AT FIRST THE DEALER SAID IT WAS NORMAL. UPON INSISTING THEY ADVISED OF A BLEEDING PROCEDURE AND THEN OF A FAULTY TIMING CHAIN TENSIONER. AFTER 7 MONTHS THEY FINALLY REPLACED THE TENSIONER (THEY HAD TO HEAR IT BEFORE THEY COULD REPAIR IT). THE DEALER HAD IT FOR A WEEK AND SAID IT WAS ALL FIXED. THE NOISE CAME BACK THREE DAYS LATER. I TOOK IT IN A SECOND TIME AND THEY GOT BMW ENGINEER TO LOOK AT IT. THEY REPLACED A CHECK VALVE THAT WAS SUPPOSED TO TRAP OIL IN THE VANOS SYSTEM AND SAID ONCE AGAIN IT WAS FIXED. THE NOISE WAS BACK THREE DAYS LATER. I TOOK IT BACK TO THE DEALER AND THEY WERE NOT ABLE TO DUPLICATE THE NOISE. I HAVE BEEN IN TOUCH WITH MINI OF NORTH AMERICA AND THEY HAVE ASKED ME TO KEEP A LOG AS TO HOW I DRIVE AND WHEN IT HAPPENS WITH TEMPERATURE. THE ENGINE HAS OIL AND WATER ON DEMAND RATHER THAN ALL THE TIME LIKE REGULAR ENGINES. STARTING THIS UP WITH NO OIL IN THE HEAD IS BOUND TO CAUSE DAMAGE. *TR

CAR CLUNKS WHILE GOING OVER ROUGH ROADS. AS PER DIAGNOSIS FROM MINI DEALERSHIP, THE "TRANSMISSION MOTOR MOUNT IS TOO SMALL AND DOES NOT DAMPEN SHOCK FROM ROAD BUMPS OR ACCELERATION TORQUE" AND WAS REPLACED. *TR

COLD START CHATTER. VERY NASTY DIESEL ENGINE SOUND UPON STARTUP WHEN ENGINE IS COLD. SOUND LASTS FOR UP TO 1 MINUTE IF I START DRIVING RIGHT AWAY, OR 5 MINUTES IF I LET IT SIT IDLE. OCCURS BETWEEN 800 AND 3000 RPM. REPRODUCIBLE EVERY TIME THE ENGINE IS COLD (IE, HAS NOT BEEN USED RECENTLY). *TR