2008 MITSUBISHI LANCER EVOLUTION Complaints

AYE/ HYDRALIC PUMP WAS NEVER CHANGED OUT WAS TOLD WHEN I WENT TO DO A MANUFACTURING RECAL THAT IT WORKED FINE WHEN IT DIDNT AND AFTER WARDS HIT PAST THE 100,000 MILES AND WAS AUTOMATICALLY UNABLE TO GET THE REPLACEMENT.

ACD/ AYC PUMP FAILURE, ONE TIME I WAS DOING FLUID INSPECTION ON MY CAR WHEN I NOTICE THE CARS ATF FLUID RESERVOIR IN THE TRUNK IS LOSING OIL. LOOKED AT THE FLOOR FOUND SOME RED OIL DRIPPING. IT MAY HAVE SEEM THAT PUMP MAY HAVE BEEN FAILING TO HOLD PRESSURE AND LOSE OIL. POSSIBLE GASKET FAILURE OR PUMP CRACK. BEEN SEARCHING ONLINE FOR SIMILAR PROBLEMS, I FOUND OUT IT SEEMED TO BE MOSTLY EVERY OWNERS PROBLEM. IS THIS SUPPOSE TO BE COVERED BY MANUFACTURER? SEEM LIKE POOR MATERIAL BUILD. *TR

VEHICLE WAS IN COLD WEATHER, AYC SYSTEM LIGHT TURNED ON. I CHECKED THE FORUMS AND FOUND THAT THIS IS A COMMON ISSUE THAT INDICATES THE PUMP IS BAD. THIS IS A VERY COMMON PROBLEM. *TR

IT WAS A COLD WINTER DAY, I STARTED DRIVING MY EVO TO A NEARBY GROCERY STORE. ENROUTE, THE AWD SYSTEM WOULD THROW A WARNING AND A DASHBOARD LIGHT LIT UP. I WAS CONCERNED, STOPPED THE VEHICLE AND FOUND NO LEAKS OR NO WEIRD NOISES. THE VEHICLE WAS UNABLE TO SHIFT INTO SNOW/TARMAC/GRAVEL MODE. FORTUNATELY I WAS NOT STRANDED ON THE ROAD SIDE. UPON FURTHER INVESTIGATION I CAME TO KNOW THAT THE ACD PUMP FAILED AND HENCE IT THREW AN AWD ERROR. ITS COSTING ABOUT 2200 DOLLARS TO FIX THIS ISSUE. *TR

WHEN STARTING MY 2008 MITSUBISHI LANCER EVOLUTION GSR, I RECEIVED A WARNING MESSAGE ON THE CLUSTER DISPLAY SHOWING A YELLOW-ORANGE SYMBOL THAT SHOWS 4 WHEELS CONNECTED BY AXLES AND THE MIDDLE-SHAFT, WHERE THE FRONT TWO WHEELS ARE FACING AT AN ANGLE TO THE SIDE. THE ERROR CODE READ AS C161E: DTC C161E: ELECTRIC PUMP RELAY CIRCUIT SYSTEM (STUCK). THIS HAS BECOME A VERY COMMON ISSUE WITH THE 2008 MITSUBISHI LANCER EVOLUTION. SO COMMON THAT WHEN YOU SEARCH FOR THE CODE C161E, YOU CAN FIND COUNTLESS FORUM DISCUSSIONS ON MULTIPLE WEBSITES COMMENTING ON THE FREQUENCY OF THIS ISSUE. INCLUDING MYSELF, A SINGLE DISCUSSION IDENTIFIES AT LEAST 48 UNIQUE CARS, 42 OF WHICH ARE THE 2008 MODEL YEAR, WHERE THE ACD PUMP FAILED, ALL OF WHICH HAVING DRIVEN FEWER THAN 75,000 MILES AND NEARLY 60% WITH LESS THAN 50,000 MILES (HTTP://WWW.EVOXFORUMS.COM/FORUMS/SHOWTHREAD.PHP?T=58221&HIGHLIGHT=C161E&PAGE=1). SEVERAL OF THESE VEHICLES REQUIRED MULTIPLE REPLACEMENTS OF THE SAME PART. THIS PROBLEM AFFECTS THE SAFETY AND EFFECTIVENESS OF THE VEHICLE'S ALL-WHEEL-DRIVE SYSTEM, LIKELY INCLUDING THE VEHICLE'S TRACTION CONTROL AND NEEDS TO BE RECALLED IMMEDIATELY. *TR

LOSS OF ELECTRONIC STABILITY CONTROL. AYC/ACD PUMP FAILURE DUE TO POOR ENGINEERING. CAR HAS NO STABILITY CONTROL AND DRIVER IS MORE LIKELY TO LOSE CONTROL IN SEVERE WEATHER CONDITIONS. *TR

ACTIVE YAW CONTROL (AYC) AND ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILED. NOT COVERED UNDER POWER TRAIN WARRANTY PUMP WAS CORRODED AND COULD NO LONGER PRODUCE ENOUGH PRESSURE. PUMP IN LOCATED DIRECTLY BEHIND PASSENGER REAR WHEEL EXPOSED TO WATER, SALT, AND OTHER ROAD DEBRIS. *TR

WENT TO DEALER FOR TRANSMISSION CHECK AND AFTER A MILE AWC LIGHT CAME ON THEY SAID IT HAD NOTHING TO DO WITH COMPUTER UPDATE THEY DID.MIND YOU MY TRANNY WAS GOING BAD AND DEALER DID NOT WANT NOTHING TO DO WITH IT EVEN UNDER WARRANTY. *TR

ELECTRONIC STABILITY CONTROL / S-AWC (TARMAC/GRAVEL/SNOW) INOPERABLE. TERRAIN SELECTION CAN BE PERFORMED AT 0MPH HOWEVER WHEN THE CAR IS PLACED IN MOTION: FORWARD / REVERSE, THE INSTRUMENT PANEL INDICATES THERE IS SERVICE REQUIRED IN THE AWD TRACTION CONTROL SYSTEM. THIS IS APPARENTLY A COMMON PROBLEM, FROM THE MULTITUDE OF COMPLAINTS FOR THIS SPECIFIC ISSUE POSTED HERE. *TR

ACD (ACTIVE CENTER DIFFERENTIAL) PUMP HAS FAILED AND WITHOUT THIS PUMP PROVIDING PRESSURE TO THE ALL WHEEL DRIVE SYSTEM, THE VEHICLE GETS STUCK ON DRIVEWAYS AT A STOP WHERE THE TIRE AND WHEEL PACKAGES ARE ON DIFFERENT ELEVATED SURFACES. THE REASON THE PUMP HAS FAILED IS DUE TO PLACEMENT OF THE PUMP ON THE VEHICLE. MITSUBISHI HAS DESIGNED THE VEHICLE TO HAVE THE PUMP TO BE LOCATED DIRECTLY BEHIND THE REAR PASSENGER WHEEL. DUE TO THIS, WHILE DRIVING ON SEVERE WEATHER ROADS (PARTICULARLY SNOW SALTED ROADS), THE DIRT, WATER AND SALT GETS KICKED UP TO THE POSITION OF THE PUMP WHICH CORRODES THE FITTINGS AND THE PUMP ITSELF. THIS THEN CAUSES THE PUMP TO FAIL OVER TIME. IT COULD HAVE BEEN EASILY REMEDIED BY RELOCATING THE PUMP OR ANTI-CORROSION PROTECTION AND BETTER SEALING. BEING LOCATED IN SOUTHERN CALIFORNIA, I WOULD HAVE THOUGHT THAT THIS WOULD HAVE NEVER HAPPENED TO ME, BUT EVEN DRIVING ONLY TWICE THROUGH SNOW ROADS IN THE PAST 3 YEARS HAS CORRODED THE PUMP TO FAILURE. MITSUBISHI HAS DENIED THAT THIS IS PART OF THE POWER TRAIN WARRANTY, WHICH MEANS IT WILL BE A $2000+ DOLLAR FIX. *TR