2003 MITSUBISHI OUTLANDER Complaints

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000(SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. DORSETT AUTOMOTIVE IN TERRE HAUTE, IN REFUSED TO PERFORM THE REPAIR BECAUSE THE PASSENGER SIDE OUTER TIE ROD AND LOWER CONTROL ARM NEEDED TO BE REPAIRED BEFORE THE RECALL REPAIR COULD BE COMPLETED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT THE COMPONENTS HAD TO BE REPAIRED BEFORE THE REMEDY COULD BE PERFORMED. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE DRIVING UNKNOWN SPEEDS, THE CONTROL ARM, BALL JOINT, CROSS MEMBERS, AND CV AXLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND LATER TOWED TO SAVANNAH MITSUBISHI (8203 WHITE BLUFF RD, SAVANNAH, GA 31406, PHONE NUMBER: (912) 226-6200) WHERE IT WAS DIAGNOSED THAT THE CROSS MEMBERS WERE CORRODED THROUGH AND CAUSED THE CV AXLE, BALL JOINT, AND CONTROL ARM TO DETACH. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WOULD NOT REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

HEAVY SMELL OF GASOLINE WHEN FUEL TANK IS FILLED. FILL GARAGE WITH FUMES. CHECK ENGINE LIGHT IS ON. IF FILLED TO A HALF TANK OR SO, NO INDICATION OF FUEL SMELL. DOES NOT APPEAR TO BE LEAKING. I HAD AN ASE CERTIFIED MECHANIC LOOK AT IT AND THE FUEL TANK AS WELL AS FILLER NOZZLE ARE DETERIORATED. I CALLED MITSUBISHI MOTORS NORTH AMERICA AND THEY ACTED AS IF THIS WAS THE FIRST TIME THEY EVER HEARD OF THIS PROBLEM. I CALLED MULTIPLE DEALERS, AND ALL HAVE EXPERIENCED THE SAME PROBLEM WITH THEIR CUSTOMERS. THE INTER-NET IS FULL OF SIMILAR COMPLAINTS ON 2003 TO 2006 OUTLANDERS. I HAVE HAD A RECALL FOR THE FRONT END BECAUSE OF EXCESSIVE RUST MAKING IT UNSAFE TO DRIVE. I DO NOT THINK THIS IS A NORMAL WEAR AND TEAR WITH THE FUEL TANK. MITSUBISHI SHOULD ACKNOWLEDGE THIS PROBLEM AND CORRECT IT FOR THEIR CUSTOMERS. I AM THE ORIGINAL OWNER. THE CAR IS ALWAYS GARAGED WHEN NOT BEING DRIVEN.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE CONTACT STATED THAT THE RECALL SHOULD ALSO COVER THE FRAME THAT HELD THE REAR AXLE, WHICH THE CONTACT STATED WAS MORE RUSTED THAN THE FRONT FRAME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE RECALL DID NOT COVER THE REAR FRAME. THE FAILURE MILEAGE WAS 193,000. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE SEAT BELT RETRACTOR MECHANISM FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 164,241.

RECEIVED A SAFETY RECALL NOTICE IN AUGUST 2016. AS OF THIS DATE THE PART TO REPAIR THE VEHICLE IS NOT AVAILABLE. HAVE CALL MITSUBISHI SEVERAL TIMES AND THEY KEEP SAYING THE PART IS BEING PROCESSED. CONFUSION AS TO WHETHER THE PARTS ARE SENT TO A DEALER FOR REPAIR OR IF THE VEHICLE NEEDS TO BE INSPECTED FIRST AND THEN THE PART IS ORDERED BY THE DEALER. THE DEALER CLAIMS THAT THE VEHICLE NEEDS TO BE INSPECTED FIRST THEN THE PART IS ORDERED IF NECESSARY. MITSUBISHI STATES THAT THEY WILL DETERMINE HOW MANY PARTS TO SEND TO WHAT DEALERS. CONFUSION. NEAREST DEALER TO ME IS 3 TO 4 HOURS ONE WAY TRIP. IF THE VEHICLE NEEDS TO BE INSPECTED FIRST BEFORE THE PART IS ORDERED THEN IF WILL HAVE TO MAKE TWO 6 TO 8 HOUR ROUND TRIPS. HOW THE DEALER KNOWS HOW MANY PARTS TO SEND TO WHAT DEALERS DOES'T MAKE SENSE. THIS PART IS NEEDED TO PREVENT THE VEHICLE'S STEERING FROM FAILING. THE PART IS THE LOWER CONTROL ARM. PLEASE CLEAR THIS UP FOR ME.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE REAR SUSPENSION AND CROSS MEMBER WERE CORRODED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT A TRAVEL-ARM HUBBERING WAS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000(SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

I AM REFERRING TO A WELL KNOWN "STICKY HVAC MIX DOOR" ISSUE IN THE MITSUBISHI OUTLANDER AND LANCER VEHICLES IN MODEL YEAR 2003 (PERHAPS AMONG OTHER YEARS AND MODELS). THIS ISSUE CAN RESULT IN AN INABILITY TO DEFROST THE WINDSHIELD DURING COLD WEATHER DRIVING. I HAVE HAD THE "STICKY" ISSUE FOR SOME TIME, WHICH, WHILE IT WAS DIFFICULT TO TURN THE KNOB, WAS NOT A HUGE ISSUE. HOWEVER, RECENTLY WHILE DRIVING, THE DOOR WENT FROM "STICKY" TO "STUCK," ON THE "COLD" SETTING. MY WINDOWS GRADUALLY STARTED TO FOG AND I WAS UNABLE TO DEFOG THEM SINCE THE SYSTEM COULD NOT BLOW HOT AIR DUE TO THE STUCK MIX DOOR. I WAS DRIVING ON AN INTERSTATE HIGHWAY (I-39) IN CENTRAL WISCONSIN AT THE TIME, ON AUGUST 27, 2016 IN THE EVENING. IN LATE SUMMER / EARLY AUTUMN, THERE IS A WIDE TEMPERATURE SWING DURING THE DAY AND NIGHT, SO FLIPPING FROM HOT TO COLD SETTINGS IS VERY COMMON. FORTUNATELY IT WAS NOT EXTREMELY COLD SO I WAS ABLE TO TURN OFF THE HVAC AND OPEN ALL MY WINDOWS IN ORDER TO GET BY DURING MY SHORT DRIVE. HOWEVER, IN THE WINTER, I NEED TO HAVE IT SET ON "HOT" AT ALL TIMES: THEREFORE, FOR WINTER DRIVING, MY CAR WILL NOT BE DRIVABLE AT ALL DUE TO THIS ISSUE. PLEASE ISSUE A RECALL IN COLD WEATHER STATES ASAP. THIS IS A VERY WELL KNOWN ISSUE WITH THESE VEHICLES, BUT ONLY AT THIS TIME DID IT BECOME A SERIOUS CAUSE OF CONCERN: WHEN THE HVAC MIX DOOR IS STUCK ON THE COLD SETTING, THE INABILITY TO DEFOG THE WINDSHIELD IS A SERIOUS SAFETY ISSUE FOR THE DRIVER AS WELL AS FOR ANYONE ELSE SHARING THE ROAD.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TAKEN TO BE INSPECTED FOR NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION), THE TECHNICIAN INFORMED THAT THE FRONT CROSS MEMBER WAS CORRODED AND NEEDED TO BE REPLACED HOWEVER, THE PARTS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.