2013 MITSUBISHI OUTLANDER Complaints

THE CATALYTIC CONVERTER WAS RECALLED AND REPLACED IN NOVEMBER OF 2017, BUT NOW THE EXHAUST MANIFOLD IS RUSTED FROM THE INSIDE WHICH CAUSED BITS TO BREAK OFF AND FALL INTO THE NEW CATALYTIC CONVERTER. NOW THE EXHAUST MANIFOLD NEEDS TO BE REPLACED (THERE ARE ONLY 4 PARTS IN THE NATION FOR THIS??) AND THE NEW, LESS THAN A YEAR OLD, CATALYTIC CONVERTER HAS TO BE CLEANED OUT OF ALL THE RUSTY METAL BITS. THERE IS A RATTLING NOISE IN THE ENGINE WHEN IDLE (RPMS JUMP UP AND DOWN SLIGHTLY IN IDLE), QUIETS A BIT ONCE YOU HIT 2-3K RPMS AND THEN IS LOUD AGAIN AROUND 1-2K RPMS. THE EXHAUST MANIFOLD IS NEARLY A THOUSAND DOLLARS TO REPLACE! I DON'T LIVE NEAR THE OCEAN OR A PLACE WHERE IT SNOWS FREQUENTLY. MY 5 YEAR OLD CAR SHOULDN'T HAVE RUST IN THE EXHAUST MANIFOLD ESPECIALLY CONSIDERING THE OTHER RECALL JUST LAST YEAR. SERVICE ENGINE SOON LIGHT HAS BEEN ON FOR WEEKS SINCE THE PROBLEM STARTED. THEY TOLD ME IT'S OUT OF MY WARRANTY BECAUSE MY CAR IS AT 75K MILES.

AFTER A LONG DRIVE, EVEN MORE SO UPHILLS, THE TRANSMISSION STARTS SLIPPING AND THE CAR HESITATES TO GO AFTER A STOP. A WARNING MESSAGE THAT THE TRANSMISSION IS OVER HEATING APPEARS AND THE CAR RUNS AT HIGH RPMS AT ONLY 60 MPH. ERROR CODE P1778 HAS APPEARED TWICE. THE CAR ONLY HAS 71,000 MILES

KEEPING THIS SIMPLE, THE CAR HAS LESS THAN 60,000 MILES ON IT, AND I WAS SMELLING GAS. TOOK IT TO THE GARAGE, AND WAS TOLD THAT THE GAS TANK, NEAR THE TALK, RUSTED AS IT PROBABLY WAS NOT SEALED PROPERLY. HOW COULD THIS HAPPEN, IT SEEMS IT IS RIGHT AROUND WHERE IT CONNECTS TOGETHER. THIS IS RIDICULOUS, AND SHOULD BE RECALLED. I NOTICED THAT IT WAS ON CARS, BUT NOT ON THIS PARTICULAR VEHICLE. THIS NEEDS TO BE LOOKED INTO, AS IT JEOPARDIZED THE SAFETY OF MYSELF AND MY CHILD.

TL* THE CONTACT OWNS A 2013 MITSUBISHI OUTLANDER SPORT. WHILE OPERATING THE VEHICLE, THE "SERVICE AIR BAG REQUIRED" MESSAGE DISPLAYED AND REMAINED ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 56,000.

MY CAR WAS TOTALED A FEW DAYS AGO I WAS DRIVING HOME AND HIT A DEAR AT 55MPH AND MY AIR BAGS DID NOT DEPLOY MY FRONT END WAS DESTROYED MY RADIATOR WAS DESTROYED ALONG WITH OTHER PARTS OF THE CAR AND THE CAR WAS CONSIDERED TOTALED. I WAS INFORMED MY AIR BAGS SHOULD OF DEPLOYED BUT THEY DID NOT

ON APRIL 12TH, THURSDAY NIGHT AROUND 8 PM, I WAS HEADING NEAR THE I-290/ I-90 INTERSECTION, RIDING ON I-90 WEST. I HEARD A SHARP CRACK IN THE FRONT OF THE CAR. I LOST POWER STEERING, CHECK BATTERY CHARGE LIGHT CAME ON AND WITHIN 2-3 MINUTES, ENGINE OVERHEATING LIGHT CAME ON. I BROUGHT MY CAR TO A STOP IN A SAFE AREA BETWEEN THE INTERSECTING HIGHWAYS. A HIGHWAY WORKER PROTECTED ME WITH HIS SAFETY TRUCK TILL AAA TOW TRUCK TOOK MY CAR TO THE LOCAL SCHAUMBURG MITSUBISHI DEALER ANY STEPS YOU TOOK TO ISOLATE THE PROBLEM, SUCH AS CHECKING FOR FLOOR MATS. BE SPECIFIC ABOUT WHAT YOU DID AND HOW YOU DID IT. THE DEALER/SERVICE PERSONNEL FOUND THAT THE BELT TENSIONER BEARING WAS PULLING OUT AND THE BELT WAS NOT RIDING ON THE PULLEY CORRECTLY. THE TENSIONER WAS REPLACED AND THE SERPENTINE BELT WAS REPLACED I BELIEVE THIS IS A DESIGN FAULT WITH THE BELT TENSIONER/ BEARING AND SHOULD BE FIXED FOR THESE CARS. A SIMPLE GOOGLE SEARCH WILL SHOW THIS IS A FAIRLY COMMON PROBLEM

TL* THE CONTACT OWNS A 2013 MITSUBISHI OUTLANDER. WHILE DRIVING 30 MPH, THERE WAS AN ABNORMAL GRINDING NOISE AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 99,000.

CAR WOULD RANDOMLY SHUDDER AND RPMS FLUCTUATE WHILE IDLING. THEN WOULD JUST DIE WHEN ATTEMPTING TO GO FROM IDLE. EVENTUALLY ASC SERVICE REQUIRED WARNING CAME ON WITH SERVICE ENGINE LIGHT. TRANSMISSION TUNNLER WAS REPLACED. CAR RAN FINE FOR A FEW WEEKS AND PROBLEM HAS STARTED AGAIN. PULLING INTO GAS STATION, CAR STARTED TO SHUDDER. RPMS FLUCTUATED AND ASC SERVICE REQUIRED CAME ON AGAIN.

WITHOUT WARNING THE RPM WILL DROP TO ZERO. AT FIRST IT WOULD START RIGHT BACK UP WITHOUT HAVING TO RESTART IT. NOW WITHOUT WARNING IT WILL JUST DIE AND RPM GOES TO ZERO AND I HAVE TO RESTART IT. CHECK ENGINE LIGHT WILL COME ON BUT NO DIAGNOSTIC CODES ARE STORED AS TO WHAT THE PROBLEM IS. IT HAS HAPPENED WHILE STOPPED AS WELL AS DRIVING DON THE ROAD AT 50 MPH.

TL* THE CONTACT OWNS A 2013 MITSUBISHI OUTLANDER. WHILE DRIVING IN RAINY CONDITIONS AT APPROXIMATELY 65 MPH, THE WINDSHIELD WIPERS STOPPED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER TO WAIT FOR THE RAIN TO STOP. THE VEHICLE WAS TAKEN TO THE DEALER (RAY BRANDT CHEVROLET, WESTBANK EXPY, HARVEY, LA 70058 (504)-229-6013). THE DEALER DIAGNOSED THAT THE WIPER MOTOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 16V792000 (VISIBILITY) AS A POSSIBLE SOLUTION; HOWEVER, THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 65,000.