2003 MITSUBISHI OUTLANDER Complaints

HEADLIGHTS HAVE NUMEROUS STRESS CRACKS, UNABLE TO GET 2007 INSPECTION DUE TO HEADLIGHTS. HAVE CONTACTED DEALERSHIP NUMEROUS TIMES, WAS GIVEN MITSUBISHI DISTRICT MANAGER NAME AND NUMBER, WILL NOT RETURN CALL. HEADLIGHTS NOW HAVE WATER INSIDE . HAVE TAKEN NUMEROUS PICTURES OF OTHER MITSUBISHI OUTLANDERS WITH SAME PROBLEM. WAS FIRST QUOTED $750.00 FOR REPLACEMENT, NOW QUOTED $850.00. CONSUMERS SHOULD NOT HAVE TO REPLACE SOMETHING THAT NEVER SHOULD HAVE HAPPENED IN THE FIRST PLACE. *TR

I BOUGHT MY 2003 MITSIBUSHI OUTLANDER IN JANUARY 2005 WITH 32,000 MILES ON IT. THE HEADLIGHTS WERE SHOWING SOME STRESS CRACKS FROM THE HEADLAMP HEAT. I NOW HAVE 69,000 MILES ON THE CAR AND THE HEADLIGHTS HAVE SEVER STRESS CRACKS IN THE LENSES THAT ARE EXTREMELY NOTICEABLE. I HAVE HEARD THIS IS A COMMON PROBLEM FOR THESE CARS. *JB

NO EVENTS. HEADLIGHT GLOBES ARE INADEQUATE. THEY CRACKED FOR NO REASON OTHER THAN POOR QUALITY. THIS ALLOWED MOISTURE TO INTER THE HEADLIGHT ASSEMBLY CAUSING THE BULBS TO FAIL. PAID $850.00 TO REPLACE DEFECTIVE HEADLIGHT ASSEMBLIES. UNABLE TO DRIVE THE CAR AT NIGHT FOR FEAR OF TRAFFIC CITATIONS AND OBVIOUS SAFETY REASONS. *TR

TL*- CONTACT OWNS A 2003 MITSUBISHI OUTLANDER, FOR WHICH HE HAD TO REPLACE THE REAR LOWER SUSPENSION ARM 4 TIMES. FIRST TIME IT WAS AT 30,000 MILES, SECOND TIME AT 48,000 MILES, AND THE THIRD TIME AT 89,000 MILES, AND CURRENTLY AT 106,000 MILES. THE CONTACT TOOK VEHICLE TO THE SAME DEALERSHIP , ARNOLD AUTOMOTIVE GROUP IN ROSEVILLE, MI 4 TIMES, AND THEY STATED THAT THEY DIDN'T KNOW WHY THE PART KEPT GOING BAD. THE CONTACT THE CURRENT MILEAGE WAS 106000.*AK THE LEFT REAR SEAT BETL WOULD NOT RETRACT. THE SWAY BAR WERE REPLACED AND THE LOWER CONTROL ARM WAS WORN. UPDATED 03/30/07. *JB

I HAVE CRACKS IN THE HEADLIGHT LENS IN BOTH HEADLIGHTS. THERE HAS BEEN NO WRECKS, BANGS, OR BAD TREATMENT OF THIS VEHICLE. I WAS TOLD BY A SOURCE CLOSE TO THE COMPANY THAT THEY ARE STRESS FRACTURES, I AM CONCERNED THEY MAY BEGIN TO LEAK AND TAKE ON WATER. PLUS THEY ARE $400 EACH TO REPLACE. I CALLED MITSUBISHI AND ALL THEY WANTED TO TALK ABOUT WAS WARRANTY. THEN I WAS TOLD THEY DO NOT DO RECALLS UNLESS YOU FOLKS BRING IT TO THEIR ATTENTION. ANY HELP WILL BE APPRECIATED. I TALKED WITH LOCAL MITSUBISHI DEALER ABOUT IT IN MID DECEMBER 2006. *NM

DT*: THE CONTACT STATED WHEN THE VEHICLE WAS STARTED, THE COOLING FAN DID NOT ENGAGE COMPLETELY. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHERE IT WAS DETERMINED THAT THE FAN WAS A DEFECTIVE PART. THE VEHICLE WAS THEN TAKEN TO A SERVICE DEALER, WHERE THE DEALER INFORMED THE CONTACT THAT BECAUSE THE VEHICLE WAS OUT OF WARRANTY, THE REPAIRS WOULD NOT BE MADE. THERE WERE NO IMMEDIATE REPAIRS MADE.

ON THE MORNING OF MAY 2, WHILE IT WAS RAINING A CAR THAT WAS TWO CARS IN FRONT OF MY WIFE DECIDED TO MAKE A LEFT TURN ON THE HIGHWAY WITHOUT ANY ADVANCED NOTICE; MY WIFE ENDS UP RUNNING INTO THE CAR IN FRONT OF HER AND SERIOUSLY DAMAGING THE FRONT OF THE CAR. THE AIRBAGS, HOWEVER DID NOT DEPLOY. MY WIFE SUFFERED A CONTUSION ON HER HEAD. MY 17 MONTH OLD DAUGHTER WAS ALSO IN THE CAR BUT WAS NOT SERIOUSLY HURT. MY INSURANCE COMPANY ESTIMATES THAT THE REPAIRS WILL COST $8000 AND THE SENSORS FOR THE AIRBAGS WAS ONE OF THE PARTS THAT NEEDED TO BE REPAIRED. THE SENSOR IS CURRENTLY BEING REPLACED. *JB

THE RADIATOR BLEW APART WHILE DRIVING ON THE HWY CAUSING THE ENGINE TO QUICKLY OVERHEAT. THERE WERE NO WARNING LIGHTS TO INDICATE THERE WAS A PROBLEM. UPON INSPECTION BY MY MECHANIC IT WAS DISCOVERED THAT THE CYLINDER HEAD ALSO CRACKED. HE WAS AWARE OF A POSSIBLE KNOWN ISSUE AND CONTACTED MITSUBISHI WHO VERIFIED A PROBLEM WITH THE COOLING FAN CONTROLLER. AFTER HAVING THE VEHICLE TOWED TO THE MITSUBISHI DEALERSHIP I WAS TOLD BY THEM THAT THEY WOULD ONLY COVER THE COST OF THE PARTS AND NOT THE LABOR. I WOULD HAVE THOUGHT THAT IF A DEFECTIVE PART CAUSED THESE PROBLEMS THAT I SHOULDN'T HAVE TO PAY ANYTHING MUCH LESS OVER $1,100 IN LABOR.

DT: THE CONTACT'S VEHICLE WAS INVOLVED IN A THREE CAR COLLISION. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE FRONT END OF THE VEHICLE WAS DAMAGED. THE VEHICLE WAS TOWED TO THE MECHANIC, AND HE DETERMINED THAT THE WIRE FOR THE SENSOR WAS TORN. THIS SHOULD HAVE MADE THE AIRBAGS DEPLOY. A POLICE REPORT TAKEN AT THE SCENE.*AK

ON SEPT 3 MY WIFE WAS DRIVING OUR 2003 MITSUBISHI OUTLANDER WHEN IT VEERED TO THE RIGHT SO SHARPLY THAT IT ALMOST PULLED THE STEERING WHEEL FROM HER GRASP. THE COULD NOT DUPLICATE THE OCCURRENCE,WE DECIDED WE WOULD GET IT CHECKED OUT NEXT WEEK. BEFORE WE COULD GET THE VEHICLE CHECKED OUT,DUE TO HURRICANE KATRINA,ON SEPT.9 MY YOUNGEST DAUGHTER WAS JUST LEAVING SCHOOL, HAD ONLY GONE A FEW HUNDRED YARDS WHEN THE CAR SUDDENLY VEERED TO THE RIGHT,CAUSING HER TO GO OFF THE ROAD AND FLIP THE CAR. A WITNESS SAID SHE SAW SOMETHING FLY OUT FROM UNDERNEATH THE CAR JUST BEFORE THE CRASH. WITH THE CAR UPSIDE DOWN WE ALL SAW THE CV JOINT BROKEN. I LOOKED ON THE SIDE OF THE ROAD DOWN FROM THE ACCIDENT SITE AND FOUND A PART THAT MAY BE THE CAUSE OF THE CRASH,I AM CHECKING THIS OUT,BUT HAVE ALSO FOUND OUT THROUGH INTERNET RESEARCH THAT THIS IS A PROBLEM WITH THIS MODEL VEHICLE. DOES SOMEONE HAVE TO DIE BEFORE AN INVESTIGATION IS DONE CONCERNING THIS SERIOUS FLAW IN CONSTRUCTION.