2004 NISSAN TITAN Complaints

IMAGINE DRIVING DOWN A MOUNTAINOUS ROAD IN IDAHO STATE. YOU ARE GOING DOWN A HILL IN A PICK-UP TRUCK PULLING A CAMPER. ALL OF A SUDDEN YOUR VEHICLE GOES INTO LIMP MODE - IT WON'T REV OVER 1000 RPM. YOU LOOK TO PULL OVER BUT THERE IS ONLY A SMALL SHOULDER. VEHICLES ARE SKIDDING TRYING TO AVOID AN ACCIDENT AS YOUR VEHICLE IS DISABLED AND ONLY PARTIALLY OFF THE ROAD. AFTER FIXING THE PROBLEM, I REALIZED THE TRUCK SHOULD NEVER HAVE GONE INTO LIMP MODE. IT IS A CRITICAL DESIGN FLAW WITH THE VEHICLE. I WAS PUT IN HARMS WAY FOR NO REASON. ALL VEHICLES USE TO HAVE THE ENGINE SPEED CONTROLLED VIA MECHANICAL LINKAGE OR CABLES FOR THE GAS PEDAL. VERY FEW FAILURES EXISTED WITH THIS DESIGN. TODAY GAS PEDAL RUN BY A WIRE THAT SENDS AN ELECTRONIC SIGNAL TO THE VEHICLES COMPUTER. THE COMPUTER IN TURN EVALUATES THE GAS PEDAL POSITION WHICH THEN SENDS A SIGNAL TO THE FUEL INJECTORS AND THROTTLE BODY TO CONTROL THE ENGINE. THE CRITICAL DESIGN FLAW COMES INTO PLAY WHEN VEHICLE DESIGNERS COMBINE OTHER ELECTRONIC SENSORS ON THE SAME CIRCUIT AS THE GAS PEDAL. NON-CRITICAL COMPONENTS LIKE GAS EVAPORATOR SENSORS, POWER STEERING SENSORS, AIR CONDITIONER SENSORS. WHEN ANY OF THESE NON-CRITICAL ITEMS EXPERIENCE AN ELECTRICAL SHORT, THE VEHICLE GOES INTO LIMP MODE POTENTIALLY PUTTING DRIVERS IN HARM'S WAY DOES THIS RECOMMENDED SOLUTION FIX ALL PROBLEMS RELATED TO THE GAS PEDAL? NO IT DOES NOT. IT IS A LOT SAFER. I BELIEVE NHTSA SHOULD EVALUATE & ASSESS THIS CRITICAL DESIGN FLAW. I HAVE BEEN A CONTROLS ENGINEER FOR 28 YRS AND THIS DESIGN IS NOT SAFE. PLEASE REFER THEIR MODEL A60 SERIES MANUAL. NOV 2003 EDITION, REV-APRIL 2004, PUB NO. SM4E-1A60U1. SECTION B , PAGES EC-423 THRU 427. I WOULD FIND IT SATISFACTORY IF NISSAN REDESIGNED AND FIXED ALL VEHICLES BY SEPARATING CIRCUITS WITH CRITICAL ENGINE COMPONENTS FROM NON-CRITICAL COMPONENTS. *TR

ON 6/20/2008 I WENT TO A NISSAN DEALERSHIP TO RESOLVE A RECALL ITEM TO REPLACE REAR DOOR WIRING HARNESS, RECALL # R0616. THE RECALL WAS PERFORMED AND IN THE PROCESS THE DEALERSHIP ALSO REPLACED LH-PRETENSIONER, SEATBELT AND BODY HARNESS, AND RESET AIRBAG WARNING LIGHT. ON 6/03/2013, THE AIRBAG WARNING LIGHT CAME ON AND I WENT TO A NEARBY NISSAN DEALERSHIP AND WAS ADVISED THAT I WOULD HAVE TO REPLACE THE LH-PRETENSIONER, SEATBELT AND BODY HARNESS, I INFORMED THE SERVICE ADVISOR THAT THIS WORK WAS ALREADY ACCOMPLISHED ONCE AND THAT I HAD THE DOCUMENTS IF HE NEEDED THEM. THE SERVICE ADVISOR THEN STATED THAT SINCE THE WORK WAS ACCOMPLISHED FIVE YEARS AGO THAT EVEN THOUGH THE PARTS ARE A SAFETY ITEM THAT THEY WERE NO LONGER UNDER WARRANTY, RESULTING IN A 574.30 CHARGE OF WHICH I PAID. MY CONTENTION IS THAT THIS IS A SAFETY ITEM, AND THUS SHOULD NOT HAVE A WARRANTY RESTRICTION, I AM NOT SURE IF THE TRUCK IS EVEN SAFE TO DRIVE. *TR

2004 NISSAN TITAN. CONSUMER WRITES IN REGARDS TO FAULTY WIRE HARNESS RECALL NOTICE. *SMD THE CONSUMER STATED THE RECALL REMEDY FAILED AND WAS ONLY A TEMPORARY FIX. THE CONSUMER STATED THE VEHICLE FAILED A STATE INSPECTION, BECAUSE THE AIR BAG LIGHT WAS ON. THE CONSUMER STATED SINCE THE FIX DID NOT ELIMINATE THE POTENTIAL HAZARDOUS CONDITION OF THE FAULTY WIRING HARNESS INSTALLED BY THE MANUFACTURER, HE BELIEVED HE WAS ENTITLED TO REFUND OF $ 185.60 WHEN HE HAD TO PAY FOR THE REPAIRS, THAT SHOULD HAVE PREVIOUSLY BEEN MADE UNDER THE RECALL.

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE PARKED, HE NOTICED A LOUD EXHAUST NOISE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE EXHAUST HEADERS WERE FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,938. *TR

I RECEIVED A RECALL NOTICE IN THE MAIL THIS WEEK: RECALL 06V-459 ABOUT THE AIRBAG WARNING LIGHT FLASHING, SEAT BELTS NOT WORKING PROPERLY, ETC. MY VEHICLE IS HAVING ALL OF THE PROBLEMS LISTED SO AS INSTRUCTED I BROUGHT MY VEHICLE TO THE NISSAN DEALERSHIP ALONG WITH THE LETTER. THEY INFORMED ME THAT THEY WOULD NOT FIX THE PROBLEM BECAUSE IT "WAS NOT IN THEIR SYSTEM". STATING THEY DO NOT UNDERSTAND WHY I GOT A NOTICE IN THE MAIL. CLEARLY MY VEHICLE IS HAVING THESE EXACT PROBLEMS AND THEY ARE REQUIRED TO FIX THEM, BUT THEY STILL REFUSED TO FIX OR DIAGNOSE FOR FREE AS REQUIRED BY LAW. VERY DISAPPOINTING IN NISSAN FOR DISREGARDING MY FAMILY'S SAFETY. *TR..UPDATED 08-07-13 *BF

TL* THE CONTACT OWNS A 2004 NISSAN TITIAN. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS ADVISED THAT THE EXHAUST MANIFOLD WAS CRACKED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000. *TR

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACTED THAT WHILE DRIVING 50 MPH, HE NOTICED THAT THE EXHAUST MANIFOLD WAS CRACKED AND EXHAUST FUMES WERE LEAKING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE EXHAUST HEADERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 43,000. *TR

RIGHT REAR AXLE SEAL LEAKS AND IF NOT REPAIRED IMMEDIATELY, FLUID LEAKS ONTO BRAKE ROTOR. HAS THE POTENTIAL OF LOSING ALL DIFFERENTIAL FLUID FROM REAR END CAUSING A COMPLETE DRIVETRAIN FAILURE. *TR

CATASTROPHIC FAILURE OF THE LEAF SPRING ON DRIVER SIDE REAR OF THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE SEAT BELT SEIZED AND BECAME DIFFICULT TO UNLOCK. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE SEAT BELT WAS WORKING PROPERLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. *TR