2005 NISSAN XTERRA Complaints

AFTER MY "SERVICE ENGINE SOON" LIGHT WAS ACTIVATED, I PROCEEDED TO TAKE MY NISSAN XTERRA TO THE NISSAN DEALERSHIP IN HAWTHORNE, CA, TO HAVE IT CHECKED OUT. NISSAN CHARGED ME $129 FOR A DIAGNOSTIC TEST, WHICH FOUND AN ERROR CODE OF P0463. THAT ERROR CODED INDICATED THAT THE FUEL LEVEL SENSOR WAS MALFUNCTIONING. I DECLINED TO PAY $570 TO HAVE IT REPAIRED. IN DOING SOME RESEARCH ON THE INTERNET, I FOUND THAT SEVERAL NISSAN VEHICLES, ESPECIALLY ITS TRUCKS AND SUVS, HAVE SUFFERED FROM THIS PRODUCT DEFECT. I WOULD GREATLY APPRECIATE IT IF NISSAN RECTIFIED THE SITUATION BY RECALLING VEHICLES OR COVERING MY CHARGE FOR REPAIRS. *TR

THE CLUTCH FIRST FAILED AT 2800 MILES. NISSAN REPLACED IT BUT TOLD ME IT WAS BAD DRIVING. I HAVE HAD A CLUTCH MY ENTIRE LIFE. THE SECOND FAILURE WAS AT 52000 MILES. NISSAN TOLD ME IT WAS OUT OF WARRANTY SO I HAD IT REPLACED ELSEWHERE WITH OE PARTS. IT JUST FAILED AGAIN AT 78000 MILES AND AGAIN THEY SAID IT WAS OUT OF WARRANTY. I WILL NOW HAVE THE FOURTH CLUTCH INSTALLED AND AM LOOKING AT OTHER THAN OEM EQUIPMENT. *KB

I HAVE A 2005 XTERRA WITH 38K MILES, "SERVICE ENGINE SOON" LIGHT CAME ON, TOOK IT TO THE DEALERSHIP, HOOKED IT UP TO THE COMPUTER, DIAGNOSIS IS A BAD FUEL SENDING UNIT $600.00 TO REPLACE. I'M JUST OVER THE EXTENDED WARRANTY BUT DEALERSHIP CANNOT HELP. THE SENDING UNIT AND GASKET ARE $200.00. $400.00 FOR LABOR SEEMS A BIT STEEP. AT WHAT POINT IN TIME WILL NISSAN RECALL THIS ISSUE? *KB

FUEL SENDING UNIT DIED AT 36800 MILES; APPROXIMATELY 800 MILES OUT OF WARRANTY. NISSAN LATER ADMITTED FAULT (OVER 5 YEARS LATER) AND EXTENDED WARRANTY TO 72000 MILES AS IT APPLIES TO THAT PART, BUT MY VEHICLE WAS WELL PAST THAT MILEAGE BY THAT POINT. VEHICLE NOW FAILS NJ INSPECTION BECAUSE OBD II CODE IS RETURNED FOR FAULTY FUEL LEVEL SENSOR. *TR

"I HAD 1/4 OF A TANK OF GAS AND WENT TO FILL UP. AFTER FILLING UP MY GAS TANK, I TURNED ON THE CAR, AT WHICH POINT THE NEEDLE DID NOT REGISTER THE FULL TANK. AFTER DRIVING A COUPLE MILES, THE CHECK ENGINE LIGHT CAME ON. I WENT DIRECTLY TO THE DEALER AND WAS TOLD THAT IT WAS A FUEL SENDING UNIT/SENSOR AND THAT IT WAS NO LONGER COVERED AFTER 30K MILES. AFTER RETURNING HOME AND DOING RESEARCH, I WENT ONLINE TO X.NISSANHELP.COM AFTER PERFORMING A SEARCH, I CAME ACROSS MANY OTHERS WHO HAVE EXPERIENCED THE SAME PROBLEM. APPARENTLY IT HAS SOMETHING TO DO WITH THE FUEL SENDING UNIT. A SIMILAR PROBLEM WAS FOUND ON THE 2000-2004 XTERRA MODELS AND A RECALL WAS PERFORMED WHEN THE VEHICLE WOULD STOP AFTER NOT GETTING ANY FUEL, POSING A GREAT DANGER. IT SEEMS THAT SOMETHING IN THE UNIT IS FAULTY AND WILL CORRODE OVER TIME. THERE IS A GENERAL CONSENSUS THAT EVERYONE WHO IS HAVING THE PROBLEM IS EXPERIENCING THE SAME THING AFTER HAVING THE VEHICLE FOR OVER 2 YRS AND WITH AROUND 39K-49K. IF THIS PROBLEM EXISTED IN PREVIOUS MODELS, AND IT WAS RECALLED, THE 2005-2007 XTERRAS, FRONTIERS, AND PATHFINDERS SHOULD GET THIS FIXED AT NO CHARGE TO THE CUSTOMER!! WHY WAIT FOR ACCIDENTS AND POSSIBLE DEATHS, ESPECIALLY SINCE THE PROBLEM LIES IN AN INTEGRAL PART OF THE VEHICLE. COST OF REPAIR RANGES FROM $300-600." *TR

HAD A P0463 CODE COME UP FOR FUEL LEVEL SENSOR A CIRCUIT HIGH INPUT. I UNDERSTAND THAT THIS IS VERY COMMON ON SECOND GENERATION NISSANS. *TT

INTERIOR COMPONENTS OF THE RADIATORS (INTERNAL TRANSMISSION COOLERS) BREAK DOWN ALLOWING COOLANT TO MIX WITH THE TRANSMISSION FLUID. AS A RESULT OF THE CONTAMINATION, THE TRANSMISSION AND OTHER DRIVETRAIN COMPONENTS ARE DAMAGED AND FAIL CAUSING POSSIBLE ACCIDENT. *TR

ENGINE LIGHT SERVICE SOON IS ON THE CAR IS STARTING TO STALL. OUT OF WARRANTY BUT WHILE RESEARCHING THIS IS A KNOW ISSUE FOR NISSAN XTERRAS. *TR

THE FUEL LEVEL SENSOR ON MY 2005 NISSAN XTERRA STOPPED WORKING AS I WAS DRIVING TO WORK. THE DEALERSHIP WANTS $500 TO FIX THE SENSOR WHICH WAS A KNOWN PROBLEM AND RECALLED ON EARLIER AND LATER MODELS OF THIS TRUCK. AND IS ALSO A COMMON PROBLEM FOR OTHER XTERRA OWNERS. PLEASE RECALL THIS PART. FUEL LEVEL SENSORS LAST MUCH LONGER THAN THIS IS OTHER MAKES AND MODELS OF VEHICLES. *TR

TRANSMISSION SHUDDERS VIOLENTLY PERIODICALLY BETWEEN SPEEDS OF 40MPH AND 65MPH. BROUGHT TRUCK TO BUCKEYE NISSAN IN HILLIARD, OH WHERE ALL OF MY REPAIRS HAVE BEEN COMPLETED OVER THE ENTIRE LIFE OF MY VEHICLE AND THEY INFORMED ME THAT I HAD COOLANT IN TRANSMISSION AND TRANSMISSION FLUID IN RADIATOR. THIS PROBLEM CAN LEAD TO SUDDEN AND CATASTROPHIC FAILURE OF TRANSMISSION WHILE IN MOTION WHICH COULD HAVE LEAD TO A SERIOUS AUTO ACCIDENT. *TR