2018 RAM 1500 Complaints

The contact owns a 2018 Ram 1500. The contact stated that the vehicle failed to start. The system failed to go through regeneration. The contact stated that the EGR cooler and radiator were leaking. The check engine warning light was illuminated. Additionally, the service electronic control message was displayed. The vehicle was taken to the local dealer where it was diagnosed that there was a crack in the EGR cooler, and that the cooler was leaking. The contact stated that the exhaust was stuck and clogged. Additionally, the fuel filter was clogged. The turbo boost sensor also had malfunctioned. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 19V757000 (Engine and Engine Cooling). The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 115,000.

The problem is with the whole DEF System in the truck. for the last 6 months I can't go a week or less without getting some kind of code. Every time it effects the electronic throttle control and the truck goes into limp mode, I can be going 70 mph and it drops down to 30-40 mph no matter where I am at. I have almost been rear ended several times. I fix that code and a week later another code pops up and we do it all over again. I think I may have gone 2 weeks without a problem in the last 6 months. This time it is the DPF and DEF system, and here we go back into limp mode. I have had it to the dealer last week for issues which they couldn't figure out but thought that reprogramming would fix. So I leave to go out of state to work and here we go again less than 100 miles from home. Exhaust filter is full with no regen for over 400 miles. Now I'm stuck out of state with this problem. I think this really needs to be addressed because after all of my research this seems to be a normal problem.

The contact owns a 2018 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Tailgate on truck will randomly open, including while driving. This can cause debris in the bed to become unsecure and fall out of the back. I have had this happen several times in the past. Most recently it fell while I had my trailer on cause damage to the tailgate which will now need replacing.

The contact owns a 2018 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Ram 1500 interiors are damaged and destroyed when water intrudes into the cabs, a problem Fiat Chrysler allegedly knows about. The water leaks allegedly cause electronics to short-circuit which damages the rear airbags and propellant. And the water leaks cause mold and mildew which sickens occupants and makes the Ram 1500 trucks health hazards. In addition to the rear airbags, the Ram 1500 water leaks can allegedly cause problems with the "push-to-start ignition system, locks, windows, headlights, taillights, interior lights, windshield wipers, climate control, infotainment system and navigation, and back up camera." Ram 1500 drivers should allegedly expect failures of the headlights and tail lights, issues with starting the trucks, turn signal and brake light failures, faulty backup cameras and infotainment system problems. The Ram 1500 water leak lawsuit further claims drivers can lose the windshield wipers and the ability to lock or unlock the trucks. Fiat Chrysler has allegedly known about the Ram 1500 water leak problem since 2016 but actively concealed the alleged defects. TSBs - TSB S2023000024, TSB 23-016-21 titled, “Water Leaks At Sliding Backlite.

The active grill shutters and related wiring components are defective. The check engine light came on around 52000 and issued a code for U11E9- “replace active grill shutter.” I replaced it with a brand new part and the CEL remains on. Further investigation into similar instances in online forums suggest problems with the design of the wiring harness and pigtail that connects to the PCM. Many other consumers have reported this problem and were unable to resolve using the associated code, requiring further, expensive electrical repairs.

The touchscreen for the UConnect and all on board systems (ac/heat, audio controls, back up camera, clock, phone and device interface, etc.) is delaminating. This began at about 53,000 miles and has worsened (currently at about 56,000) to the point that it creates phantom button pushes. This presents a safety hazard as it can change radio and volume settings, cause repetitive, unpredictable menus to populate(clock settings), make unintended phone calls, and change other settings that present a distraction to the driver. Once the problem begins, it cannot be stopped without powering the vehicle off and the monitor cannot be powered off as the phantom commands rewake the screen. This is a well known, well documented problem that is due to a design and manufacture defect that is expensive to replace. Please issue a recall!

2018 Ram 1500 8.5 inch U-Connect center screen that shows the back-up camera video is delaminating. This causes the back-up camera to become non-functional when the delamination progresses to the point of rendering the screen unusable.

I received a bubble in my Uconnect infotainment system. After researching this appears to be a major problem. I was advised by my service dealership, Lithia Ram in Santa Rosa, that the bubble will spread across the screen and eventually uncontrollably turn the radio up and down as well as the heater and A/C. This is completely unsafe as it will distract the driver constantly and make matters unsafe to drive. This appears to be a major flaw with these infotainment systems.