2022 RIVIAN R1T Complaints

I am reporting repeated suspension and structural failures involving my 2022 Rivian R1T. In April 2026, at approximately 90,537 miles, Rivian performed a comprehensive inspection and found both front lower control arm bushings torn, the right rear damper leaking, and the rear subframe cracked. Rivian’s own service documentation specifically stated that the vehicle was “unsafe to operate due to damage to the rear subframe” and recommended that the vehicle be towed. Rivian subsequently replaced the rear subframe, both front lower control arms, the right rear damper, and serviced the hydraulic damper system. The April repair invoice totaled approximately $9,953. Approximately five months later, at approximately 96,956 miles, the vehicle developed another significant suspension problem. The front passenger side began sitting noticeably lower. The ride became extremely rough over bumps, I could feel significant vibration through the vehicle, and the vehicle repeatedly attempted to adjust its ride height. I also received warnings telling me not to move the vehicle while the air suspension was adjusting, and I was unable to properly adjust the ride height. I brought the vehicle back to Rivian in September 2026. The current Rivian service estimate calls for replacement of both front dampers, the air-suspension compressor/ASU, and the left and right front hydraulic suspension jounce lines, along with suspension diagnostics. The suspension repair estimate is approximately $7,121. I was informed that the ASU/compressor was tried as part of diagnosing the problem but did not resolve the condition, and the front dampers are now suspected. I was also informed that because the front suspension functions as a connected system and the replacement components are an updated design, both sides/components may need to be replaced. I am concerned about the repeated failure of safety-critical suspension and structural components on the same vehicle. In approximately five months .

The seat belt came completely dislodged from the seat base as my passenger was getting into the car and fastening their seat belt

After gently removing the fabric cover of our Cybex Eternis S All-In-One car seat to wash it according to the manufacturer's care instructions, and then putting the cover back on, the car ride immediately following, the red plastic pieces designed to hold the cover in place completely snapped off. This structural failure exposed two sharp, unshielded metal screws directly in the child's seating area. Because these screws were left fully exposed by the broken plastic, they created an immediate laceration hazard. As a direct result of this defect, my young daughter's leg was cut by the exposed screws while using the seat.

SYSTEMS AFFECTED: Electrical System (12V Power Supply / Low-Voltage), Climate Control (HVAC System / Thermal Management), Towing / Recovery DESCRIPTION OF SAFETY HAZARD & DEFECT: My 2022 Rivian R1T experienced a sudden, complete electrical failure due to a defective HVAC system, resulting in a dangerous hard-bricked state that rendered the vehicle totally inoperable. Approximately 30 days prior to the incident, the vehicle underwent a comprehensive inspection at a Rivian Service Center where both the HVAC system and 12-volt battery system were tested and cleared. Shortly after, a primary internal failure/glitch within the HVAC equipment created a high parasitic power draw on the vehicle's low-voltage circuit while parked. The HVAC module failed to enter sleep mode, continuously draining the dual 12-volt AGM battery array below critical operating thresholds. This rapid, deep-discharge condition completely disabled the vehicle's primary high-voltage contactors and low-voltage control modules, locking out all vehicle functions, electronic doors, and drive controls. The vehicle could not be restarted, jump-started normally, or safely shifted into neutral, necessitating an emergency flatbed tow to the service center. Technicians confirmed that the primary HVAC equipment failure directly caused the full depletion and destruction of the 12-volt electrical system. This defect presents an immediate safety risk. An uncommanded HVAC-induced power drain that completely depletes the 12-volt system can cause sudden electrical failure, vehicle bricking, loss of hazard lights, and lock-out conditions, potentially stranded occupants in dangerous environments or busy roadways. Rivian is treating this catastrophic multi-system failure as non-warranty maintenance, refusing to address a clear pre-existing latent defect in their low-voltage power management and thermal architecture. REQUESTED ACTION: Investigation into 2022 Rivian R1 HVAC power management defects causing severe 12V drain

In July of 2025 while driving my entire air suspension collapsed on the highway slamming the vehicle down onto it's bumpstops. Rivian covered a "fix" of this under warrant. In December the rear shock was leaking. Now in July of this year while driving the front air suspension collapsed to it's bump stop again.

The R1T has four cameras to assist the driver and provide warnings for lane changes, etc. The cameras are routinely failing while I am driving the vehicle. This started after an OTA software update. A software reset will turn the cameras back on, though they have repeatedly failed. Rivian attempted to correct the issue by replacing the front camera, which they determined was faulty. The cameras have continued to fail since then.

Vehicle gave a warning to service the electrical system and then shut down preventing any operation. Luckily I was in a parking lot and not on a roadway impeding traffic or jeopardizing safety while driving. Could smell burnt electrical from within cabin. Had to have towed to service center and explained that condensation from air conditioner leaked onto high voltage heater coils and shorted out electrical system. Seems like a poor design that this was even possible. Dealer indicated this was not uncommon.

Rear Suspension Dampers leaking prematurely which could cause unsafe driving issues.

Subframe has cracked. It is a known issue for my vehicle as the welded subframe isn’t strong enough to hold the weight of my vehicle over time. Thus compromising the structural integrity over time, leading to severe safety hazards like unpredictable handling, poor stability, and potential failure of critical components. This can lead to accidents if not resolved. Rivian currently knows this is an issue and charges customers who are out of warranty over $11k to repair.

12 volt battery was replaced under warranty on date 07/08/2024 at miles 14059. Again, 12 volt battery needs to be replaced at 29343 miles as of today's date 04/12/2026. This is highly unusual. Please look into it. Prakashkumar Patel, MD