2022 TESLA MODEL S Complaints

Left side trim to the left of the glass roof I have protruding dents popping outward in metal. I had 3 dents and 1 of 3 was pushed down flush but the other two are still present. I have worked with Tesla service center and they have ignored my issue by not addressing the two additional protruding dents. Normal dents are known to go inward and these are going upward or outward. Tesla service drove to meet me with a same year model S as mine and both the left and right sides were observed to have many protruding dents potentially from the underlying frame. Several visits were made to service center as they continued to ignore my issue but after walking the parking lot they were surprised that other model S long range and plaids have dents protruding out of the metal which is not normal. As I have been told my issue isn't covered under warranty, not sure why. But my perspective something underneath the metal is causing it push upward or outward that should be addressed. I opened a BBB case 18002067 and the Tesla service center never addressed the concern to completion.

My new Tesla Model S, delivered 10/1/22 has frequent emergency breaking events every trip to town, approximately 25 miles on a 2 lane State highway. These breaking events involve severe emergency breaking and happen in cruse control or auto steering, (this car does not have auto driving feature). My concern is that these breaking events could cause an accident if a vehicle following me should rear-end my car because my vehicle breaks hard for no reason, without warning. I requested a service appointment from Tesla but my scheduled appointment was soon canceled by Tesla and instead, I was referred to a long written company explanation on why the breaking might be happening but nothing about when the issue might be corrected. I have a copy available if requested, and the vehicle is available for inspection upon request. Basically, the Tesla shop won’t look at the vehicle. To my knowledge, there is no authority, insurance representative, or independent service in New Mexico that would be interested in inspecting the vehicle, but I would make the vehicle available for such inspection within 100 miles of my residence. The emergency breaking event happened the first time I put the car in auto steering and again in cruse control, every time I drive the vehicle. There are no warnings lights or messages before, during, or after these events. A trip of 25 miles will have about 10 or more of these events. If cruse control or automatic steering is off and the driver has control, these events do not happen.

Factory oem tire separated on the driver side rear. This could have ended badly had i not noticed the difference in handling of the vehicle. It appears the rear camber of the vehicle causes strain on the inner side of the tire and there is zero calibration that can be made to help fix this. Tesla told me it’s a Michelin issue and Michelin says it’s a Tesla suspension issue.

The contact owns a 2022 Tesla Model S. The contact stated while driving at an undisclosed speed with the ADAS Adaptive Cruise Control activated, the vehicle experienced Phantom Braking with an unknown warning light intermittently illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 2,236.

I was driving my Model S from Oregon to Texas, 14-16 Sep. The car was new, picked up on 31 Aug. I had the car in Autopilot when I was on the highway on the drive to Texas. In the first two days I had four incidents of "phantom braking" at highway speeds, as high as 80 mph. There was not a lot of traffic those first two days and the conditions were dry so there was little risk to others and the car stayed straight during the braking. However it's not hard to imagine scenarios where unexpected braking at high speeds could be a problem, such as during wet or dusty road conditions, driving into a high speed turn with other vehicles nearby, etc. The vehicle has not been inspected but the incident has been reported to the dealer and I am awaiting guidance.

PHANTOM BRAKING: I was driving northbound on the I-5 highway south of Sacramento, California using cruise control and traveling at the 70 MPH speed limit on September 14, 2022. At approximately 2:50 p.m., I moved from the right lane into the left lane by using the turn signal to execute the lane change. Once in the left lane, the car immediately began violently applying the brakes. There was a car behind me that appeared as if it was going to rear end me. I pressed on the accelerator pedal which allowed me to regain control over the vehicle and avoid being hit by the vehicle behind me. The weather was clear and visibility was excellent. There was no apparent reason for the emergency braking system to become operative.

The horn "button" on the 2022 Model S steering "yoke" is impossible to engage consistently when the wheel is in any orientation other than straight. I have been in 5 near accidents that have required lane departures and roadway departures to avoid collisions with other vehicles because it has been impossible to find and engage the horn button without removing attention from the road and impending accident. This design essentially leaves the Model S with no operative horn in an emergency situation. There are no tactile keys to find the button in the dark, it is not illuminated, and there is no way to find it when the wheel is in a non-centered orientation. In many cases, I have inadvertently engaged wipers/washer fluid in the midst of an accident scenario, further obstructing my view and causing additional distractions from safely operating the vehicle. Please make them fix this!!!

Having the horn on the right side is a huge safety issue. When I need to push it while turning, it turns out to be impossible to locate in emergencies. I had multiple issues with this. It needs to be in the center of the steering wheel

A driver moving at highway speeds began to change lanes while I was next to him. I tried to honk the horn (which, on my yoke, is a small, haptic feedback touch screen of sorts) to warn him. The horn did not sound, either because it did not respond or because I missed the tiny, physically undistinguished area of yoke that serves as the horn activator.

I have quite a few incidents with fantom breaks on my Tesla. Two night ago I almost caused accident as my Tesla breaked for no reason. Many incidents happened before in the month.