2016 TESLA MODEL S Complaints

I was slowly backing up to charge my car and heard a thump then my wheel was rubbing against the wheel well. When I looked under the wheel to see what was happening, I discover the metal suspension had snapped off. This was the front passenger side.

2016 Model S started making clunking sounds when turning and braking. Tesla service center inspected the vehicle and observed visible defects on the front left and right fore and aft links. Tesla recommended replacement of and quoted almost $2000 for parts and labor, including inspection fee. Vehicle only has 89000 miles and never had high impact incidents over obstacles.

while parking the vehicle, a loud shot gun like noise eminated from the front of the car. The car was being driven at less than 5 mph. After this there was loud noises from the front of the cars suspension. The car seemed unsafe to drive farther. I took it to the tesla service center the next day driving at a very low speed. they replaced the right and left front contol arms and charged me $1204.98 on October 26, 2023. The vehicle had 77,626 miles at that point. I queried them as to why this would ocurr at such low mileage and vehicle age? I got not response other than these things happen and the car is out of the normal warranty and the extended warranty. I paid the invoice since i agreed to the repair estimate earlier.

The contact owns a 2016 Tesla Model S. The contact stated that while driving at undisclosed speeds, the instrument cluster became inoperable on several occasions. The contact stated that the failure had occurred several times. The vehicle was taken to the dealer; however, the contact was informed that the failure would reoccur unless the vehicle was updated with a new infotainment center and a faster processor. In addition, the contact stated that the vehicle had been taken to the dealer several times due to the failure. The contact stated that recently the instrument cluster and the ECM were replaced. In addition, the vehicle recently received a software update. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 73,000.

The lower control arm on my left rear tire broke. Specifically, the aluminum of the knuckle joint snapped. This occured in my driveway while backing up. This caused extensive damage to the rest of the rear left suspension.

The contact owns a 2016 Tesla Model S. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Received and OTA notice on the dashboard that states "Battery Fuse replacement" is required. The fuse is due to a Li-ion battery that wears out for a safety system. Life expectancy of the battery is 10 years. It has not lasted 8 full years. This is stated as a safety issue and Tesla has since redesigned this item to not required the batteries. I have alerted Tesla about this issue, have not had a reply, as yet. The vehicle can be operated without this safety device, which seems inappropriate. I feel this should be replaced under warranty and/or recall - but it appears Tesla will want to charge an excessive amount of money.

Incident Tesla Model S was up to date on recalls as far as we can tell, including the recent autopilot update via Tesla internet vehicle update releases. While driving in autopilot mode on the freeway in the lane next to the HOV lane, the autopilot got confused as to which lane it should keep and failed to maintain its lane. Incident vehicle drifted across the double lines into the HOV lane, where another Tesla Model S was driving. Both cars were damaged in the ensuing side bump impact, then the incident vehicle made a slight impact to another car rear bumper in front of the incident vehicle. No injuries were reported. A subsequent Traffic Crash Report was filed as required with CA Highway Patrol. We are awaiting this report in the mail. Our safety and others was put at risk due to the failure of the autopilot to maintain its lane. Insurance was contacted. The insurance company, USAA, has deemed the incident vehicle (our vehicle) damage too expensive to fix due to the very high cost of replacement/repair parts and has deemed our vehicle a "total loss." We have not been able to access the software of the vehicle. Since USAA has deemed the vehicle a total loss, they are selling the car for salvage and thus we have no further access to the vehicle for legal purposes. As far as I know, USAA has not pulled the vehicle software records nor has requested such records and has completely ignored the autopilot issue. That is part of the reason for our complaint here as well. Since there were no injuries, legal representation in this case has not been forthcoming. We ask the NHTSA to investigate since we can get no help from Tesla, USAA or any other legal advocate.

1.) Passenger Side Door is a potential hazard. Door latch and door mechanism does not open from the outside. 2.) Lane keep assist on Autopilot veers off to the right when it is first engaged and does not want to stay centered until it's been on for awhile.

When I was driving in the parking lot and turned to park at a parking spot I heard a sound from the passenger side front wheel. After I heard the sound the wheel felt stuck and was not moving freely. There were two other passengers in the car along with the driver. This is the second time that this happened. It happened first on Oct 2021 when the car's mileage was 51k and the second time when the mileage was 77k. The Model S was purchased in 2016. Tesla service center fixed it the first time and the repair listed the following 1>Fore Link Assembly LH(1041570-00-B) 2>Washer Nordlock(1033093-00-A) 3>Nut HF M14x1.50 ZnNi NL Insert(1004358-00-C) Tesla charged me $495 for it. The second time this happened the damage was a lot more extensive and Tesla recommended I take the car to a Tesla-approved body shop. I took the car to Brooks Automotive in Fremont and they charged me $10,000 for the repairs. My insurance refused to pay for the damages after I filed a claim with the insurance. Tesla refused to pay for it claiming it was not a manufacturing defect and the car was not under warranty. This car is driven by me and my wife and neither of us are rash drivers. We did not hit any debris on the road or remember an incident that could have led to this happening not once but twice. The car has been driven normally and used for normal family activities on public paved roads.