2016 TESLA MODEL S Complaints

The doors are not opening/closing properly. I have had intermittent issues that are now more constant. When the doors unlock they do not unlatch when I pull the exterior handle. Yesterday on 9/13/26 my front drivers side door was not closing. Each time I closed it the latch released and it would pop back open slightly on its own. I had to hold it closed and eventually it stayed shut while making strange electrical sounds. Now it only opens with the interior handle, not the exterior.

I had a new windshield installed by a official Tesla Service Center that has a large distorted area in the center of the windshield. I complained about the large distortion and I was told that all the of stocked parts for my car are affected by the issue and they don't have any estimates or information that the items in stock will be replaced or updated. I am attaching a video of the distortion that I believe is a significant safety issue. The affected area is in the center below the rearview mirror and is approximately 4 x 3 inches in size. This issue needs to be resolved by Tesla by getting the supplier to correct the issue and replace their stock so they can replace my windshield.

UPDATE to Complaint XXX. Reference VIN [XXX] Tesla Model S 2016. Incident XXX [XXX] XXX Report XXX. Tractor [XXX] Unit XXX + Trailer XXX. 11 sec forward camera video proves Tesla BEHIND trailer at Time 0, 30ft gap. Tesla travels 88ft (30ft gap + 53ft trailer + 5ft to diesel tank/step) in 3-4 sec to lateral impact at driver diesel tank/step. Calculation: 88ft/3sec=29ft/sec avg requires 50-60 mph peak. At 5 mph (7.33 ft/sec) would need 12 sec - impossible. Proves Sudden Unintended Acceleration. Lateral impact, video shake rightward, NOT CVC 21658(a) lane change. AEB failure + FCW failure, no braking/warning. Request EDR preservation. Contact [XXX] [XXX] [XXX]. OMB [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This complaint covers a 13-month continuous chain of severe electrical system failures stemming from a deficient federal safety recall remedy on my vehicle's Media Control Unit (MCU) architecture. Tesla's corporate policy has been to replace only the isolated center screen explicitly tracked by the recall while leaving connected legacy components intact on mismatched architecture. This creates an uneven electrical strain loop that has systematically destroyed my vehicle’s electronics over the last year.In July 2025, the initial recall failure required a VCM processor card swap. In September 2025, the resulting voltage strain forced a center navigation screen upgrade, during which the facility held my car for two full weeks. In December 2025, this continuous parasitic power drain burned out my 12V auxiliary system, forcing me to pay out of pocket for a replacement battery. Now, in August 2026, the 2016 dashboard instrument cluster has completely blacked out while traveling at highway speeds (70 MPH), leaving the vehicle completely illegal and unsafe to drive with zero speedometer visibility.The service facility is actively attempting to evade its 12-month workmanship and parts warranty obligations. Their official technician notes confirm the dashboard screen arrived completely black, yet their recorded remedy was to execute a temporary software reboot and officially instruct me in writing to 'perform scroll wheel resets as needed' while actively operating the vehicle on public highways. Following my official written rejection of the vehicle due to this safety hazard, the local facility even attempted an unauthorized forced delivery transport of the vehicle to my house to hide their failed repair before turning back. They are using temporary software patches to run down the remaining days on my parts warranty and dodge an incomplete federal recall remedy. I am requesting a formal federal investigation into this facility.

The contact owns a 2016 Tesla Model S. The contact stated that while driving approximately 55 MPH, the hood inadvertently opened and blocked the windshield. The vehicle was pulled over to the side of the road while the windshield was blocked. The hood was securely closed after several attempts. Upon inspection, the contact became aware that the hood was bent, and the hood arms were bent. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 131,700.

While driving my vehicle straight approaching an intersection, I lost complete steering capability and feedback from the steering wheel. The lower intermediate shaft on the steering column complete separated from the splines on the rack and pinion. If I wasn't already preparing to stop at the stop sign this could have happened while driving on a curve in the road or at high speeds on a highway. The car was taken to a Tesla service center for repair (towed at my expense). I was told by the service representative that this is issue was not a safety issue nor product fault of Tesla's and the repair would need to be out of pocket ($8,500). There were no indicator lights nor warnings of a steering problem prior to the incident. Tesla has a known safety service bulletin for this model which states the u-joint on the intermediate shaft may become corroded and seize due to exposure to wintery conditions forcing binding in the steering wheel, and this issue is not considered a safety risk. It does not state the shaft may come off while driving the car.

While driving my vehicle straight approaching an intersection, I lost complete steering capability and feedback from the steering wheel. The lower intermediate shaft on the steering column complete separated from the splines on the rack and pinion. If I wasn't already preparing to stop at the stop sign this could have happened while driving on a curve in the road or at high speeds on a highway. The car was taken to a Tesla service center for repair (towed at my expense). I was told by the service representative that this is issue was not a safety issue nor product fault of Tesla's and the repair would need to be out of pocket ($8,500). There were no indicator lights nor warnings of a steering problem prior to the incident. Tesla has a known safety service bulletin for this model which states the u-joint on the intermediate shaft may become corroded and seize due to exposure to wintery conditions forcing binding in the steering wheel, and this issue is not considered a safety risk. It does not state the shaft may come off while driving the car.

Instrument cluster and/or infotainment systems frequently freezing or not showing anything. Instrument cluster freezing/blackout This is a daily occurrence making it impossible to to know if you are in drive, reverse, or neutral. Additionally you not know how fast you are going, charge level, nor any status lights (airbag, low tire, etc.). Infotainment systems freezing/blackout This is also a daily occurrence shutting down environmental controls, backup cameras, speakers, charging, etc. While neither of these issues inhibit the operation of the vehicle both make driving a significant risk. I have taken it in for repair and the only option is a $1,500 upgrade to a completely new system.

On 6/11/26, around 2:10 pm, when i was slowly pulling over to park on a road side, the car suddenly rushed forward unexpectedly. It was so powerful, at the time I could only hear the panic reactions from the two passengers and sense the imminent collision with the parked bmw in the front of several car length away. Right before the collision i steered the wheel to the right to avoid the bmw and my car came to violent halt less than a foot next to the bmw. I came out of my car to check the tire position before backing out to park a bit behind. This was on a country road, a Thursday afternoon with not much traffic. There was no distraction. If not were the enough spacing i would have no doubt crashed into the bmw in the front. When the dust settled, I did a "power off" reset to the model S and drove the rest of the day normally without any incidents. I went to Tesla service center near where i live the next morning, 6/12/26, to report it. They asked the precise time the incident occurred. But did not inspect the car. I was told an inner inquiry will be opened and it would take at least a few days. They said i could continue to drive the car normally which i have not because of not knowing what had caused it. I went to the service center today 6/29/26 after more than two weeks of no feedback. I was very disappointed in the answers given. The guy said basically based on the design of the car the incident could not have been caused by the car ,without providing any info as to what had been found from the promised inquiry. There was no written report on this. The person offered to check the brakes but also said he did not think its necessary. Just to made me feel better he said. At last, he provided the tesla web site to request "private data" during time window of the incident. I told him i will seek help from NHTSA now that tesla is not. I was told by AI, tesla has collected data on every car they sold to the details that can reveal how the paddles were pressed.

I was driving straight down a road at 10 mph approaching a stop sign. When I lost complete control of steering, the steering wheel was completely free. Moving with no response to the wheels. There was zero warning lights or check engine notifications. The intermediate shaft in the steering column completely disconnected from the rack and pinion with both the upper and lower bolts still attached to the intermediate shaft. I was able to stop the vehicle but it remained in the middle of the traveling lane of the road due to zero steering capability. I called AAA to have the vehicle moved out of the public street and towed to my residence. Tesla has a service bulletin for this part stating it needs to be replaced with a new upgraded part but it is not a voluntary recall as they stat it is not a safety or life threatening risk.