2023 TESLA MODEL X Complaints

My 2023 Tesla Model X suffers from severe, intermittent safety system failures. Specifically, the Automatic Emergency Braking and Steering Assist randomly become unavailable while driving. Tesla Service refuses to repair this, claiming they are "unable to replicate" the intermittent alerts. However, the vehicle's history proves severe safety flaws: Tesla previously had to replace the entire steering wheel assembly and the driver's seat belt lap pretensioner due to failures, and had to recalibrate the forward ADAS camera because it went out of spec causing Autopilot failures. These unresolved, randomly occurring defects pose a severe crash hazard that Tesla is ignoring.

The second-row seat does not latch properly and cannot lock into position. This is a safety-related issue affecting occupant restraint and crash safety. The vehicle is a 2023 Tesla Model X with 59,035 miles now, when report this issue Tesla, it was only 57,326 mile, still within the 5-year / 60,000-mile Supplemental Restraint System warranty. Tesla has declined warranty coverage and requested customer-paid seat replacement. I am concerned the vehicle may be unsafe to operate due to the seat not latching. Requesting investigation into potential safety defect.

On February 17 at approximately 9:30 AM, while my wife was driving uphill, the vehicle abruptly shut down and became completely disabled. It began rolling backward despite her attempting to accelerate. Multiple warning alerts activated simultaneously, and the vehicle would not respond to forward input. Our [XXX] child was in the vehicle at the time. A total loss of power while in motion, combined with unintended rollback on an incline, represents a catastrophic safety defect. This was not a minor malfunction — it created a direct and immediate risk of collision and serious injury. Compounding this concern, on the morning following the incident at approximately 6:00 AM, I discovered one of the vehicle doors open without any user interaction. The vehicle had been secured the night before. This raises serious questions regarding electronic reliability and system integrity. Given the severity of these failures, I have lost confidence in the safety and dependability of this vehicle. My family’s safety cannot be subjected to further uncertainty. If this matter is not resolved promptly and satisfactorily, I am prepared to pursue all available legal and regulatory remedies, including formal complaints to appropriate federal safety authorities. Please confirm receipt of this letter and provide a written response outlining next steps within five business days. This situation placed my wife and child in direct danger. I expect a resolution that reflects the seriousness of that fact. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a catastrophic suspension failure resulting in complete wheel separation on my 2023 Tesla Model X Plaid shortly after Tesla service. While driving, the front left wheel separated from the hub, rendering the vehicle not drivable and creating an immediate risk of loss of control, collision, and serious injury or death. Tesla towed the vehicle back to its service center and issued written service documentation stating (verbatim): “The front left wheel had separated from the hub. The issue was caused by missing hardware on the upper control arm, leading to further damage.” Tesla did not attribute the failure to impact, road debris, wear, or misuse. The missing hardware was at a critical suspension attachment point. As a result, Tesla replaced multiple major safety-critical components under Goodwill / Internal Service, including the front left active damper/air spring, upper control arm bracket, halfshaft, wheel speed sensor, and multiple structural fasteners. A wheel-off event caused by missing suspension hardware represents a severe safety defect with high risk of catastrophic injury or fatality. This incident raises serious concerns about suspension assembly, post-service quality control, and whether other vehicles may be operating with missing or unsecured hardware. I respectfully request NHTSA review this as a suspension/wheel retention safety defect and evaluate whether additional investigation or corrective action is warranted.

FSD hw3 is so f ing dangerous. It’s tried to kill me many times. It forces lane charge or a jerking wheel wrestling disengage or swerve

1. The Horn Button in NOT located in the center of the steering wheel but is located as a separate button off to the side and therefore is difficult to located in times of emergency when it is needed. 2. Where the button is located it is not intuitive in times of panic and emergency to try and located where to press the horn button. If you happen to be turning the wheel, it is almost impossible to find the button. 3. On future Tesla X models. Tesla the Manufacture decide to relocate the horn back to the center of the steering wheel. 4. We have had several close calls and missed accidents partly due to the fact we could not located the horn button in times of emergencies. 5. It seems like it would be a simple fix for the manufacturer to install an updated steering wheel for the safety of all occupants and other drivers.

Vehicle: 2023 Tesla Model X Component: Power-operated doors / door latching (auto-close / “cinch” close) Incident type: Finger pinch injury during powered door closing Summary of incident: While using my 2023 Tesla Model X, a powered door closing sequence resulted in a finger pinch injury. The door appeared to close normally and then performed an additional “cinch”/pull-in motion to fully latch. During this final motion, my thumb was caught in a very narrow gap and was pinched. There was no adequate pinch detection/anti-pinch reversal before contact and compression occurred. The gap was extremely small, leaving little time to react. Injury: Thumb crush injury with immediate blood under the nail (subungual hematoma), swelling, and altered sensation/numbness. I obtained medical evaluation and an X-ray, which showed no fracture. A splint was prescribed to protect the thumb. Safety concern: This is a significant pinch hazard because the powered closing/cinching can occur quickly and unexpectedly, and the door does not reliably detect or reverse when a finger is in the closing path. This presents a risk of more severe injury (fracture, nail-bed injury, nerve damage), especially for children. When it happened / conditions: Normal use, low speed/parked. (Add date/time/location if you want.) The incident occurred during the final powered latch/close step (“close then push/pull for full close”). What I want investigated / remedy requested: Request NHTSA to investigate the Model X powered door closing/cinching behavior and pinch detection effectiveness, including whether there are known blind spots or missing/insufficient anti-pinch protections. Recommend Tesla provide a software update or hardware change to improve pinch detection/reversal and/or limit cinch force/speed, and provide clearer warnings/settings to prevent unexpected powered closure.

Recurring front passenger safety restraint system fault that Tesla cannot permanently repair despite 4 service attempts over 16 months. ISSUE: Vehicle intermittently displays "Front Passenger Safety Restraint System Fault - Service Required" with persistent warning chimes and airbag warning indicator. Occurs with and without passenger present. Causes significant stress/anxiety and erodes confidence in restraint system reliability during a collision. REPAIR HISTORY (all under warranty): [XXX] (30,638 mi) - Invoice #[XXX] - Connector grease treatment. Recurred after ~3 weeks. [XXX] (32,399 mi) - Invoice #[XXX] - Replaced Restraint Control Module. Recurred after ~3 weeks. [XXX] (36,106 mi) - Invoice #[XXX] - Pin retention repair. Recurred after ~3 weeks. [XXX] (43,204 mi) - Invoice #[XXX] - Harness tension adjustment. Recurred late Nov 2025. CURRENT STATUS: Fault resurfaced 5th time. Service appointment scheduled ~Dec 14, 2025. Vehicle at ~48,000 miles, approaching 50,000-mile warranty limit. PATTERN: Each repair temporarily resolves issue, but fault consistently returns after 2-4 weeks. Tesla unable to identify root cause despite multiple different repair approaches. ADDITIONAL: Original owner. Also had driver-side restraint wiring repaired Feb 2024 (23,310 mi). Issue may relate to known Tesla restraint system concerns. Requesting NHTSA review whether this pattern warrants investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While using Full Self Driving (FSD) for autoparking, the car backed into and sideswiped a pole

Reat seatbelts become twisted and are not safe. Tesla claims this is a maintenance issue and not a defect in the mechanism. I disagree and this should be investigated by the government as it is a safety issue.