2023 TOYOTA HIGHLANDER Complaints

Notice something hanging when looking at the vehicle from the front took vehicle into Toyota dealership for inspection. Informed at that time there was an open recall on the vehicle was told by service director no remedy available to bring vehicle back in once remedy available. Explained there was visible damage to the vehicle. Vehicle in their possession since November 2023 no updated information on remedy available. Have had 3 loaner vehicles some do some don’t accommodate needs and family size. This is my primary vehicle for work as I travel 100% of the time for my job is financially inconvenient. Informed I will be responsible for rental vehicle if loaners become unavailable. Purchased the car new January 2024. Recall listed below. 10/26/2023 Manufacturer Safety recall issued NHTSA: #23V720 Recall: #23TB12 SAFETY RECALL 23TA12 (INTERIM NOTICE 23TB12) - CERTAIN MODEL YEAR 2020- 2023 HIGHLANDER AND HIGHLANDER HV- FRONT LOWER BUMPER COVER ASSEMBLY MAY DETACH WHILE DRIVING Status: Remedy Not Available

I am on CarPlay Maps following direction and suddenly a pop up come up on the screen advertising the Toyota Driver experience connect subscription or asking me to reset the Toyota apps pin. In order to come back to the maps, I need to take my eyes off the road to click a couple of times to CarPlay. This is dangerous as it happens every 5 to 10 minutes.

The contact owns a 2023 Toyota Highlander. The contact stated while driving at an undisclosed speed, the steering wheel was excessively difficult to steer. The power steering malfunction and pre-collision warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with power steering and rack and pinion failure. The contact was informed that the power steering rack and pinion needed to be replaced. The vehicle was not repaired. The parts were ordered to complete the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,050.

The contact owns a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The fact that the dealership was able to sell this car with a recall on is crazy, yes I have blame for not looking as well but now we are having issues with the front bumper hitting the tires when you turn and making a grinding noise. We were told that there’s nothing they could do as of yet but as I see this recall has been open for a while now? This is a big concern to us what if they don’t find anything wrong or so they say and something happens? They need to speed up the process to find a solutions loosing a front bumper while your on the highway is a big risk.

Recall has been out for 6 months still no remedy. Manufacturer Recall Number 23TB12 NHTSA Recall Number 23V720 Can't sell vehicle with open recall, and need to sell.

The right side blind spot warning does not always show a vehicle is in blind spot. The forward collision will alert will start and keep beeping for up to 3 minutes when nothing is in the area. I pulled into driveway and the vehicle started to beep a warning but no warning message showed up on dash. It continued for 30 minutes even after I turned off car. Then started it and drove it a mile and parked it again. I get on the overhead view a generalized warring. But doesn’t say what it is then goes away. This has happened a couple of times when driving. All doors shut, all seat belts locked if someone is in seat, it starts after driving for some time. No apparent reason it starts and stops but is a hazard if trying to drive and figure out why it’s beeping like something is wrong. I also have paint chipping off back bumper on the top for no apparent reason. The back liftgate doesn’t always close even when nothing is in the way. It doesn’t always open when you push the button the first time. The crossbars for luggage installed by Toyota does not keep end cap on on drivers side front and I had to pay to get new ones. The problem is the rail does not hold the cap tight.

The contact owns a 2023 Toyota Highlander. The contact stated that while the vehicle was parked,  unattended an unknown vehicle crashed into the front bumper. A police report was not filed. There was no air bag deployment, fire, or injury. The contact attached the bumper to the vehicle. At the local dealer, where it was diagnosed that the bumper cover had detached. The vehicle was not repaired because the parts were not available. The manufacturer was not notified of the failure. The contact stated that the failure was related to NHTSA Campaign Number 23V720000 (structure). The failure mileage was approximately 8,000.

The plastic bumper cover on the front of the vehicle came detached as I was driving 60mph in a construction zone. It got sucked underneath the front of the vehicle and was grinding against the front tires. There is even damage to the driver side bumper from this. I pulled over as soon as we were out of the construction zone, and we pulled the bumper out from under the car. This could have been a much bigger issue! It could have caused an accident that could have injured or killed someone. What if the bumper flew off into another vehicle and caused the driver to lost control? What if the bumper hit the tire just right and caused me to lose control and have an accident? It is my understanding that there IS a safety recall for this very issue. However, I was made known of the safety recall in OCTOBER OF 2023. It is now MARCH OF 2024, and there is still no “official” remedy available. This is unacceptable! I am told by the dealership and the manufacturer that I am just supposed to drive around without my bumper attached for an unknown amount of time until a remedy is available. I am very concerned about the safety issues at hand and I would urge that a remedy be made available for this matter immediately.

While driving on the freeway, the sunroof just spontaneously exploded. The hole was right on the center of the sunroof. I am suspecting the explosion is due to weak material used on the vehicle not withstanding thermal expansion. In any case, this is very dangerous and can cause accident. How many more incident to you need until you investigate this matter. Please investigate this matter, so the issue can be remediated. Thank you [XXX] By the way, Sunroof option for issue is not even an option on your list.Please put this on your radar. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)