2006 TOYOTA HIGHLANDER Complaints

The contact owns a 2006 Toyota Highlander. The contact stated while driving at various speeds, the brake pedal had to be pumped several times to stop the vehicle. The contact stated that the ABS warning light and several other unknown warning lights were illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 175,000.

THE BRAKE ACTUATOR IS FAILING AND IS MAKING LOUD NOISES. THE CAR DOES NOT BRAKE NORMALLY. I HAVE REPORTED BRAKING PROBLEMS SINCE I BOUGHT THE VEHICLE IN 2007. WHEN IT HITS A BUMP IT ACCELERATES AND I MUST STAND ON THE BRAKES SO I DO NOT HIT SOMEONE. IT LURCHES FORWARD WHEN IT HITS A POTHOLE OR SOME KIND OF OBSTRUCTION IN THE ROAD. WHEN I WORKED DOWN NEAR THE BUS STATION I WOULD HIT THE AREAS IN THE ROAD WHERE THE BUSES CREATED BUMPS IN THE ROADWAY AND IT WOULD LURCH FORWARD. I REPORTED THIS NUMEROUS TIMES AT NORTH BAKERSFIELD TOYOTA. I RECENTLY WENT IN TO REPORT THE NOISE I WAS HEARING AND THEY FINALLY FIGURED OUT THAT THE BRAKE ACTUATOR IS FAILING. I WAS TOLD THAT IT WAS NOT A HAZARD BUT THEY COULD NOT TELL ME WHEN IT WILL TOTALLY FAIL. I BELIEVE IT IS A SAFETY HAZARD AND THERE HAS BEEN A PROBLEM FROM DAY ONE

HAVE HAD BRAKE ACTUATOR MALFUNCTION/FAILURE FOR A VERY LONG TIME. STARTED WITH NOISES AND HAS PROGRESSED TO WARNING LIGHTS AND ALMOST COMPLETE BRAKE FAILURE. HAVE CONTACTED LEXUS BC IT A RX400H AND NOT A HIGHLANDER BIT THEY RESPECTFULLY DECLINE TO GET INVOLVED. HAD CALLED OVER A YEAR AGO. HAD CATASTROPHIC BRAKE FAILURE THAT ALMOST CAUSED AN ACCIDENT WITH OTHER MOTORIST AND AM NOW PAYING 3000 TO HAVE THE BRAKE ACTUATOR REPLACED THAT THEY HAVE BEEN TOLD ABOUT FOR YEARS AND REFUSED TO FIX AND CONSISTENTLY REMIND ME I DON'T SERVICE MY VEHICLE AT A DEALERSHIP FOR NORMAL MAINTENANCE. THE PREVIOUS OWNER NEVER RECIEVED NOTICE OR A WARRANTY CAMPAIGN AND ULTIMATELY RID THEMSELVES OF IT BECAUSE OF THE ISSUE AND PRICE OF THE BRAKE ACTUATOR TO BE FIXED.

MY ABS, VSC, (I), AND EMERGENCY BRAKE DASH LIGHTS ARE ON CONTINUOUSLY. IT IS VERY HARD TO STOP THE CAR AS IT FEELS LIKE THE BRAKE ISN'T ENGAGING. WHEN IT DOES ENGAGE YOU ARE JERKED FORWARD.

THE VSC LIGHT, ABS LIGHT, CHECK ENGINE LIGHT AND SOUND IS ARE ON. THE CODE IS BACK AS WELL C1391 FOR THIS BRAKE ACTUATOR. IT IS A WELL KNOWN PROBLEM WITH TOYOTAS . THIS WAS FIXED ONCE ALREADY BY TOYOTA DEALER AND FAILED AFTER 40K MILES AGAIN. HOW CAN A PART HAS FAILED AGAIN IN SUCH A SHORT TIME AND MILES? THIS IS A COMMON PROBLEM AND WE CAN'T GET HELP FROM TOYOTA COMPANY OTHER THAN TO PAY FOR THEIR LACK OF QUALITY ON PARTS? I CAN'T AFFORD $4000 PLUST TO FIX A PART THAT ONLY LASTED 40,000 MILES. WHEN IS TOYOTA GOING TO DO A RECALL ON THIS PART AND FIX IT FOR GOOD?

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING 25 MPH DOWN A HILL, WHILE DEPRESSING THE BRAKE PEDAL, THE BRAKE PEDAL WENT TO THE FLOOR AND THE VEHICLE HESITATED AND STARTED MAKING AN ABNORMAL SOUND. THE CONTACT STATED THAT THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT REGAINED CONTROL AND STOPPED THE VEHICLE. THE VEHICLE WAS TAKEN TO DCH WAPPINGERS FALLS TOYOTA (1349 U.S. 9, WAPPINGERS FALLS, NY 12590, (845) 288-0892) WHERE IT WAS DIAGNOSED WITH NEEDING THE BRAKE ACTUATOR TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 191,000.

THE VSC LIGHT, ABS LIGHT AND NOW THE CHECK ENGINE LIGHT IS ON. THE CODE COMES BACK TO C1391 WHICH IS THE BRAKE ACTUATOR. IT IS A KNOWN PROBLEM WITH TOYOTA THAT OCCURS @118,000 MILES. I WAS TOLD IT WAS GOING TO COST $4,000, BUT THEY FINALLY ONLY MADE ME PAY FOR THE LABOR AND TAX. HOWEVER, IT HAS NOW BEEN 30,000 MILES LATER AND THAT PART HAS FAILED AGAIN. I CAN'T AFFORD $2500-$4000 TO FIX A PART THAT ONLY LASTS 30,000 MILES. I HAVE SEEN THIS COMPLAINT OVER AND OVER. CAN WE GET SOME HELP??

LOUD CONTINUOUS BEEP BEGAN IN CAR WITH NO INDICATION AS TO WHAT IT WAS. WAS DRIVING AT 40 MPH, LET OFF GAS TO GET READY FOR TURN, HIT BRAKES AND THERE WEREN'T ANY. WAS ABLE TO SAFELY MERGE BACK INTO TRAFFIC AND DECELERATE ENOUGH TO TURN ONTO THE NEXT STREET. DIAGNOSED AS FAILED BRAKE ACTUATOR ASSEMBLY.

BRAKES ARE FAILING AND WHEN I BRAKE AT A STOP LIGHT, THE BRAKES SEEM LIKE THEY ARE NOT ACTIVATING AND ARE DANGEROUS BECAUSE I CANNOT STOP IN TIME. TOYOTA MUST REPLACE THIS OTHERWISE IT IS A HUGE SAFETY ISSUE IF BRAKES FAIL.

VSC LIGHTS CAME ON. EVENTUALLY LOST ALL BRAKES. THE ABS ACTUATOR ASSEMBLY HAD FAILED. I WAS DRIVING SLOW ENOUGH TO BE ABLE TO PULL OVER SAFELY. THIS HAS BEEN REPORTED SO MANY TIMES HERE BY DIFFERENT PEOPLE, WHERE IS THE RECALL ON THIS PART?!?! TOYOTA HAD ISSUED AN EXTENDED WARRANTY COVERING THIS PART BECAUSE THEY KNEW THERE WERE PROBLEMS WITH IT. THANK GOD THERE WASN'T AN ACCIDENT, GRATEFUL NO ONE WAS HURT. SICKENED I WASTED MY MONEY ON THIS VEHICLE. NEVER BUYING ANOTHER TOYOTA.