2006 TOYOTA HIGHLANDER Complaints

The ABS/Brake Actuator is going out. There is a stuttering as I'm coming to a stop, but when I brake from normal speeds to slow down, there is no stutter/vibration. Only when I'm going very slow and about to stop the car is when I feel a vibration/stutter in the vehicle. When pressing the brakes all the way down, there is a weird chirping/clicking noise that comes from under the hood towards the passenger side of the car. I do not have and did not get any warning lights about this, even still I don't have any. I have taken it to 2 mechanic shops now and they both have diagnosed the brake/ABS actuator failing.

ABS actuator/accumulator issue on 2006 Toyota Highlander hybrid limited. Internal component failure there are recalls on others but not this particular year. Was driving along hit the brakes and got hard pedal. Yes there were other indicator lights on including the VSC system and traction control I came to an intersection and I couldn't stop I couldn't even kind of stop it was all hard pedal were before it was normal as if there wasn't an issue. I've done a lot of research and I've seen a lot of forums and people are complaining that Toyota isn't backing this problem my 2006 Toyota is in perfect condition not a single problem except for this break issue and if you take it to Toyota the park cost $2,200 in about roughly over $5,000 to fix it well who wants to put that kind of money into a car of that year the problem is it's just a shame and a safety deal that it put my family's life at risk we could have crashed it if I wasn't an actual driver by trade I wouldn't have known how to react in other families could be harmed in this. It's worth looking into I did not need to make her police report because I veered off into a field that saved my family's life. As of now I'm hoping to open a recall campaign and just have that part replaced I could have a car that could drive another 100,000 miles and give and keepToyota good name

The contact owns a 2006 Toyota Highlander. The contact stated that while driving approximately 60 MPH, the vehicle failed to decelerate while the brake pedal was depressed. The contact stated that excessive pressure was needed on the brake pedal to stop the vehicle. The ABS and ESC warning lights were illuminated. In addition, there was an abnormal sound coming from underneath the vehicle. The vehicle was towed to a local independent mechanic, where it was diagnosed and determined that the ABS unit needed to be replaced. The vehicle was towed to another independent mechanic for a second opinion, and it was confirmed that the ABS unit needed to be replaced. The vehicle was taken to a local dealer, where it was diagnosed and determined that the brake actuator needed to be upgraded. The vehicle was diagnosed, and parts were ordered for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 195,000.

The contact owns a 2006 Toyota Highlander Hybrid. The contact stated that while driving 72 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine and traction control warning lights were illuminated. Additionally, the "Check Hybrid System", "Check AWD", and "Check VCS" messages were displayed. The contact was able to coast to the side of the road and had the vehicle towed to the residence. The contact notified an independent mechanic of the failure, and the mechanic stopped by the residence. The independent mechanic retrieved a DTC that the power inverter for the hybrid system had failed and caused the vehicle to go into LIMP Mode. The vehicle was not repaired. The contact called the dealer and was informed that there were no recalls associated with the VIN. The contact stated that when the dealer searched the VIN on the NHTSA.gov website, the VIN search showed that the VIN was included in NHTSA Campaign Number: 13V396000 (HYBRID PROPULSION SYSTEM). The manufacturer was made aware of the failure and informed the contact that the recall did not apply to the VIN. The vehicle remained at the residence unrepaired. The failure mileage was approximately 150,455.

My 2006 Toyota Highlander Hybrid Limited has an ABS fault that has caused my vehicle to undergo several maintenance issues and poses a serious safety hazard. My vehicle has less than 150,000, and over the course of the last year, my ABS light, my emergency brake light, my TSC light, and my tire pressure sensor light have all come on and refuse to go away. Additionally, the maintenance light, along with a "CHECK VSC SYSTEM" message has been on my dash for months and will not reset. My ABS has been making an intermittent buzzing sound that cycles every ten seconds when my car is on. That has been going one since shortly before the lights. When the lights came on, I noticed a serious change in my braking. The pedal would become spongy one moment and rock solid the next, or my car would brake intensely with the lightest pressure or require my foot basically to the floor to stop it. This has caused a serious issue for the safety of myself and my family. After using and OBDII scanner with ABS capabilities, the codes I received point to the ABS assembly failing to retain pressure, hence the persistent cycling to compensate for it loosing pressure. This was confirmed after the battery voltage/connection, relays, fuses, and speed sensors had all been tested. After doing further research, several other owners of similar configurations to mine share the same issue. My dashboard even makes an incredibly distracting ringing noise that can only be stopped by removing all the fuses and relays to the ABS entirely. This has not been caused as a lack of proper maintenance as this vehicle has only been in my possession for the past 3 years, of which before it came from the Toyota dealership. The dealership wants over $3,000 to fix the issue, and the part alone is $1,850 since the part has been discontinued. This fix costs more than the car is worth given its age and mileage. During any inclement weather, or in traffic, the car is unpredictable in how hard it might brake.

Toyota’s part number 44050-48190 brake actuator assembly failed, as it has in other models and is very commonly doing in the Highlander model. It is triggering other warning lights issues in the vehicle. Vehicle safety is at risk. Many others have reported the same issue.

I was on the interstate driving about 72 mph when the car just shut off all the dash lights came on and the dash it said check hybrid system I had no brakes or steering I got it off the road turned it off and back on again it started up and I drove it home but the dash still displayed check hybrid system , a week later I get in it to go to work and there’s an alarm that won’t cut off and the abs , traction control and brake light and warning light and tire pressure light are all on and the brakes are hard and there’s a weird noise coming from somewhere when u push on the brake and it says check VSC system on the dash now

The vehicle suffers from an ABS module failure. I've been researching that this is common problem with the Toyota Highlander Hybrid and presents a danger of failing brakes while driving. My brakes partially failed with my [XXX] son in the car. When attempting to stop, I had no hydraulic pressure and luckily was able to get the vehicle stopped after the car had regained some pressure. The vehicle had been running for several minutes, so it wasn't related to a fresh start and the system not having time to pressurize, if that's a thing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The brakes on my 06 Highlander hybrid AWD have been finicky at best since I’ve owned the vehicle. The car lunges forward when braking, all the way until a complete stop. While driving at around 55 MPH a medium sized dog ran out into the road. I braked hard but the brakes just lunging and trying to stop. At one point feels like it’s not braking anymore and just hope to veer out of the way. This can be fatal not only to the driver but to others driving as well. The fact that people are still having this issue, and Toyota hasn’t come up with a proper long term solution speaks to how much Toyota cares about its customer bases’ safety. It is honestly disgusting that people have had accidents and may have fatal and Toyota continues to not care. Please urge Toyota to look into this further and attempt to fix this permanently!

The driver's side sun visor does not stay up against the roof of the car and falls down obstructing the driver's view. It will not stay up and falls down immediately when pushed up against the roof. We have resorted to tying the visor up but then are unable to use the sun visor while driving.