2010 TOYOTA PRIUS Complaints

I was coming to an intersection where two cars were waiting for a right turn. I pressed on the brakes and nothing happened. The car continued to move without slowing down. The brakes felt "blocked" and unresponsive. I engaged the manual break at the last moment and that slowed me down. But I still hit the car in front of me which in turn hit another car in front of it. The police report says "following too close". But I was not following other cars. The two cars were already at the intersection. I was just coming to this intersection and attempted to slow down as usual. Except that the brakes did not respond. My car was a total loss.

Twice while I was driving on the highway, my ABS and brake light came on, and my brakes became less sensitive to pressure. That is to say, it took more effort and I had to push my brakes further towards the floor in order for them to respond. I went to an independent mechanic and got the code C1391 which indicates a brake pump accumulator issue. I went to a Toyota dealership and and had the car inspected. They confirmed the C1391 code and said the brake booster assy with master cylinder pump assy was malfunctioning. However, I was never told by Toyota that this issue meant my brakes could fail at any time. My safety and the safety of others was put at risk because my brakes spontaneously became less responsive, my stopping distance was increased, and they were at risk of spontaneous failure.

I recently had an issue with the brake actuator on my 2010 Toyota Prius, showing error code C1391. This caused reduced braking efficiency, and research shows it’s a common safety concern with Priuses. While there was a recall, it has expired, leaving owners like me without support. I kindly request an investigation to address this critical issue for the safety of all affected drivers.

The contact owns a 2010 Toyota Prius. The contact stated that while her husband was driving 25 MPH, the brake pedal was depressed but the vehicle failed to respond. The contact stated that several unknown warning lights illuminated with an audible chime being heard. The contact's husband pulled over to the side of the road and depressed the brake pedal and the pedal went to the floorboard and the brakes started to respond as needed. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was repaired but the failure persisted. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, and there was an abnormal sound coming from the brakes. The contact stated that the brake pedal went to the floorboard. The contact then towed the vehicle to the residence. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was made aware of the failure and offered a Customer Satisfaction Program Extended warranty repair. The failure mileage was approximately 105,336.

At around 1000,000 miles my Toyota Prius started burning oil like crazy. The dealer did an oil consumption test and confirmed the problem. I had to have my engine rebuilt because the rings were not seating properly. I had to bear all costs even though this is clearly a manufacturing default.

The contact owns a 2010 Toyota Prius. The contact stated while driving at undisclosed speeds, while depressing the brake pedal the vehicle failed to come to a complete stop and the brake pedal was firm. No warning light was illuminated. The vehicle was towed to a local independent mechanic where it was diagnosed and determined that the brake module needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.

My brakes stopped braking but luckily I could drive slowly into a curb in my neighborhood. God knows what could’ve happened if I was on the freeway. All the dash lights came on at the same time so I ran some codes; it came back C1391 - the brake actuator is broken. Toyota will not cover it despite this being a very common issue. My car is undriveable until this gets fixed because it will not break.

Please read the attached file "prius complaint signed" for a full description. I am the owner of a 2010 Toyota Prius, 2ZR-FXE. The warning light came up on my dashboard of my vehicle, so I took my 2010 prius to AutoZone, to get a free diagnostic. The diagnostic indicated the problem code of “C1256” “Accumulator Low Pressure” for the “Anti-Lock Brake System.” See Ex. A (AutoZone Diagnostic). It is available for inspection. According to the safety recall number “D0H”, 2010 prius model “2ZR-FXE” has a “Brake Booster Pump Assembly which can develop a crack inside the accumulator housing. If this occurs nitrogen gas could leak into the brake fluid and gradually cause a loss of power assist. Under certain circumstances, THIS COULD AFFECT STOPPING DISTANCE AND INCREASE THE RISK OF A CRASH.” (Emphasis added). I have noticed that when I brake hard, IT TAKES LONGER TO COME TO A STOP, WHICH THREATENS NOT ONLY MY LIFE, BUT THE LIVES OF MY WIFE AND TWO [XXX] DAUGHTERS WHO ALSO RIDE IN THIS VEHICLE. According to the safety recall, “Toyota dealers will perform an inspection and, if necessary, replace the Brake Booster Pump Assembly at NO CHARGE to the vehicle owner . . .” See id. The safety recall does not explicitly permit dealers or servicers to charge for an inspection with regards to this defect, according to the information provided me. The estimate, provided by DARCARS recommending replacement of the “BRAKE BOOSTER WITH MASTER CYLINDER WITH PUMP[,]” confirms that the issue appears to be that which is covered by the safety recall. Ex. F.; see also Exhibit B Safety Recall (The vehicle has a “BRAKE BOOSTER PUMP ASSEMBLY WHICH CAN DEVELOP A CRACK INSIDE THE ACCUMULATOR HOUSING . . .”). See also Exhibit E Error Code from DARCARS (“C1256 Accumulator Low Pressure”). Nevertheless, DARCARS refused to waive the diagnostic fee of $150 and would not repair the vehicle unless I paid them “$5,150.” See Exhibit F. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Gas Engine had internal destruction Cylinder broke and car became unusable at 158K miles despite being a Hybrid with al Toyota maintenance at Al hendrickson toyota of Coconut Creek, FL. This is Unacceptable and Demonstrate Internal Combustion Engine Failure that fortunately occurred near my house and NOT in the hiway. Please notify Toyota Motor Company because I had to buy a new car and we are SENIORS with limited budget. It is a severe Safety Concern.

Check Hybrid System warning lights came on and I lost all ability to drive vehicle and had to coast to the side of the road.