2010 TOYOTA PRIUS Complaints

Component failed: Brake actuator and accumulator on a 2010 Toyota Prius. It is available for inspection upon request. Safety: ABS, traction, and brake lights turned on suddenly in the middle of rush-hour traffic, followed by a spongey, hard-to-press pedal. Braking distance and efficiency was greatly impacted, and driving to a safe turn-out was extremely dangerous as I feared the brakes would give out entirely at any moment. The problem has been reproduced and confirmed by a dealership. UNKNOWN. Requested an inspection by the manufacturer but their "Customer Support Program" for the brake actuator and accumulator expired 10 years after the car's production date. After speaking to both the dealership and corporate, they have informed me that there is nothing else they can do in regards to reimbursement or satisfying the complaint. The only symptom of the problem prior to failure was a periodic hissing noise coming from the brakes. When the car was brought in for the catalytic converter in late 2025, the dealership failed to diagnose any issue with the brake booster system at that time.

To Whom It May Concern, I am writing to formally complain about the way Toyota has handled the problems with my 2010 Toyota Prius and my repeated requests for assistance. I have been a loyal Toyota customer and have purchased two new Toyota vehicles because I trusted Toyota's quality and expected good customer service. Unfortunately, after years of contacting Toyota, I have repeatedly been given the runaround without receiving a meaningful resolution. I am now facing a serious and expensive brake system problem. The vehicle requires replacement of the brake booster with master cylinder and the brake booster vacuum pump, with an estimated repair cost of approximately $4,000. This is a major safety-related repair, and I believe Toyota should properly investigate the issue and consider warranty coverage or financial assistance. I am also experiencing a serious problem with the paint, which is melting/deteriorating. I have contacted Toyota about these issues before, but the company has not provided the assistance I expected. It is extremely disappointing that after purchasing two new Toyota vehicles, this is the type of customer service I have received. I should not have to repeatedly contact Toyota or file complaints before my concerns are taken seriously. I am requesting that Toyota review my vehicle's history, my previous complaints, the brake system failure, and the paint problem and provide a fair resolution, including consideration of reimbursement or assistance with the approximately $4,000 brake repair. I hope Toyota will take this matter seriously and respond in writing. If Toyota is unwilling to resolve these issues, I will consider escalating my complaint to the appropriate consumer-protection and regulatory agencies.

ABS light came on 6 months ago as well as ((!)) light. As soon as those lights came on, the brakes had an increased stopping distance and it became harder to get the car to come to a complete stop. I have seen a few Prius owners in my area also having the same problem with their Prius. For my car, the ABS light would come on, then turn off for 300 or so miles, then turn back on and stay on for about 300 miles. That has lasted for 6 months. I had almost gotten in an accident yesterday after getting brake lines fixed for 4th time, and we determine the actuator and accumulator are both bad. I have also seen a lot of Prius owners with the same code. Where I am at, my shop is quoting me $2300 for the fix in total. That is absurd.

The contact owns a 2010 Toyota Prius. The contact stated that while driving at an undisclosed speed, a strong and unusual odor was detected inside the vehicle with no warning lights illuminated. The contact further stated that the following day, upon entering the vehicle, both the contact and the contact’s spouse experienced headaches, nausea, and cognitive discomfort. Concerned about possible exposure to harmful fumes, the contact inspected the vehicle and determined that the vehicle’s battery appeared to be inoperable. The vehicle was taken to a dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The contact expressed concern that the failure presents a serious safety hazard due to potential exposure to toxic fumes within the cabin. The contact noted that the situation could have been more severe if a child had been present in the vehicle at the time of the incident. The failure mileage was approximately 75,000.

My 2010 Prius has experienced the following error codes: C12341 and C1391, prompting the dealer to recommend replacing the brake booster assembly and master cylinder for $3938.89. This is a known issue with this vehicle and a Customer Support Program (CSP) was issued back in 2018, stating that if this vehicle displayed these codes, the repairs would be at no charge to the customer. Toyota extended this coverage to 10 years from date of first use or 150,000 miles (whichever came first). I never receied the notice. The details of the CSP are below. (I found on the internet.) "Toyota has received reports indicating various brake system related warning lamps illuminate due to internal malfunctions. The Brake Booster and Brake Booster Pump are covered by Toyota’s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever occurs first). However, because we at Toyota care about each customer’s ownership experience, Toyota is now offering a voluntary Customer Support Program that applies to various brake system related warning lamps of covered vehicles as a result of internal malfunctions, regardless of whether the vehicle is out of warranty. The timing of any repair under this voluntary Customer Support Program is subject to parts availability. The Customer Support Program will be offered for all vehicles until November 30, 2019, regardless of mileage. In addition, the Customer Support Program will be available for 10 years from the date of first use, or 150,000 miles whichever occurs first." My vehicle has about 132,000 miles and just displayed theses codes. Since it is 16 years old, the CSP has expired. It being a known issue, and one related to such a safety concern, I emplore you to make this a formal recall rather than a mere suggestion of repair. Back in 2018, my vehicle was not displaying these codes so was ineligible for the repair. Upon further research I am finding hundreds of Prius owners with the same issue. Clearly this is a defect in manufacturing.

There are issues with the brake. Many times the brake pedal goes down to the floor and it losses ability to stop. Apparently there is a common ABS actuator and Brake issues. Toyota will not address the issue

i have have 2 problems, both was recalls, but this one they say expired in 2021 when i bought the car and toyota dealer didnt tell me had recall so i could fix it before it expired. there is a class action lawsuit in the brake booster, master cyclinder actuator abs pump fialing loosing brakes making grrr noises leaking all brake fluid out continously dangerous to drive can cause bad accident wreck since i drive down the hwy alot and this is the only car i have to drive, i also have dc inverter module /sensor that is killing off 3 batteries now that i installed in 3 months, and toyota dealers wont fix unless it shows error but its a recall so since problen should fix this recall but wont pay for it to fix it even though it a recall right now that is not expired. im upset 3 dealers wont do it unless then charge me to do it. when toyotal mfg take it to any dealer and they will fix free but no one will do it. toyota mfg needs to make these dealers fix these 2 recalls on this car that can kill me and my passengers and anyone on the road that i could hit by not haivng controll brakes or the hybrid system shuttong completely down and could even kill a pedestrian with these 2 recalls that dealers wont fix but mfg said they need to everyone with these cars i see are having these same problems. need make the toyota mfg and dealers fix these free of charge before more people get killed injuried or cause more accidents ,

For the last 14 years, a check engine light has been coming on telling me that I have a fuel canister emissions leak because the canister is cracked. In 2016 2.87 million Toyota Priuses were recalled with the fuel canister crack issue. For unknown reasons Toyota has refused to fix this dangerous issue and has told me that my car was NOT included in the recall. I do not believe Toyota is being honest in their continued denial of this dangerous issue and excluding my 2010 Toyota Prius. This issue has been ongoing since the car was new.

While driving my 2010 Toyota Prius, the brake warning lights suddenly illuminated and the brake pedal became soft and unresponsive. Stopping distance increased significantly, and the vehicle required much more pressure to slow down. This created an unsafe situation in traffic and could have easily resulted in a collision. A Toyota dealership diagnosed the issue as a failure of the brake booster and brake booster pump assembly (DTC C1391). This is the same failure Toyota previously acknowledged in Customer Support Program ZJB for 2010–2015 Prius models. My vehicle is experiencing the exact symptoms described in that program, but the support period has expired even though the mileage is well within normal expectations for a hybrid of this age. The sudden loss of braking assist is a serious safety hazard. There was no warning before the failure, and the vehicle became difficult to stop immediately. This appears to be part of a widespread pattern of brake booster failures on this generation of Prius, and the defect poses a risk of crash or injury. I am filing this complaint because this is a safety-critical component that should not fail under normal use, and many other owners have reported the same issue. A review or investigation may be warranted given the frequency and severity of these failures.

brake booster that was a recall that toyota said expired in 2020 when i bought the vehicle and the toyotal dealer didnt inform me of the recall to fix it said everything was fine when it was not, i had a dc inverter sensor brake booster issues and now it ills off my 12volt battery every time i put one in lasts about 1 mth, upset dealer never told me this wjhen took in tel me any recalls or probelms, they said none, they lied to me. it kills off my 12volg agm batteries in the last 7 mths been having braking booster issues problems grrr,,, noise all the time when the car is off too, its killing off my hybrid system and my temathetics module is having issues too because of all this and evey battery i put in the car, i want the ntc gov to have toytota recall fix these problems with my car and not expire the recall they had in 2020 cause now i cant fix my car cause of it, i was lied to by the lavista toyota dealer that it has no probblems in 2020 of august when i bought it no recalls and this recall could have been fixed if they would have been honest. unexpire the recall on my brake booster and my dc inverter and sensors probelms killing off my new batteries all the time. call me right away or email me about this, its a urgent matter life or death situation with this car, since the brakes are failing and i have to drive it every day and toyota mfg or dealer wont fix cause says expired recalls cant fix it.