2006 TOYOTA TACOMA Complaints

FRAME IS CONTINUING TO RUST AT AN ALARMING RATE. FIRST REPORTED ISSUE IN SEPTEMBER. I HAVE NOT HEARD ANYTHING BACK FROM TOYOTA REGARDING A RECALL. *TR

AT ABOUT 30 MPH, WE HIT A BUMP, AND THE FUEL TANK STRAP FELL OFF OUR TOYOTA TACOMA DOUBLE CAB. WHEN WE BROUGHT THE VEHICLE TO THE TOYOTA DEALER, WHERE WE HAVE HAD THE VEHICLE SERVICED SINCE PURCHASING IT NEW IN 06, WE WERE TOLD THAT THE FRAME IS PERFORATED DUE TO RUST AND THAT THE VEHICLE IS UNSAFE TO DRIVE. THE DEALER SUGGESTED WE CONTACT TOYOTA, WHICH WE DID. BOTH THE CUSTOMER SERVICE REPRESENTATIVE AND HIS SUPERVISOR TOLD US THERE IS NOTHING THEY CAN DO. THE SUPERVISOR ALSO SAID THERE IS NO ONE ELSE ABOVE HER AT TOYOTA WHO TAKES PHONE CALLS. WE HAVE BEEN LOYAL TOYOTA CUSTOMERS, PURCHASING 8 NEW TOYOTA VEHICLES IN THE LAST 30 YEARS. WE PRESENTLY HAVE 3 TOYOTAS, AND WE ARE APPALLED THAT TOYOTA WILL NOT REMEDY THIS SERIOUS SAFETY ISSUE ON THE TACOMA. *TR

NOTICED A LOUD RUBBING NOISE FROM THE RADIATOR FAN HITTING THE SHROUD IN REVERSE. OPENED THE HOOD TO OBSERVE THAT ENTIRE ENGINE WAS LEANING TO THE DRIVERS SIDE. NOTICED FROM UNDER VEHICLE THAT THE DRIVERS SIDE MOTOR MOUNT WAS COLLAPSED INTO THE FRAME BY APPROXIMATELY 3/4 OF AN INCH. FURTHER OBSERVATION INDICATED THAT THE MOUNT APPEARED TO BREAK AT THE WELD AND THEN TEAR THE FRAME IN FRONT AND BEHIND OF THE WELDS FOR THE MOTOR MOUNT. LOOKED ON-LINE FOR SIMILAR OCCURRENCES AND DISCOVERED THAT MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEM WITHOUT ANY RESOLUTION FROM THE MANUFACTURER (TOYOTA). OTHERS ON SIMILAR SITES OBSERVED THAT BETWEEN THE 2006 MODEL YEAR (MINE) AND 2007 MODEL YEARS TOYOTA ADDED A REINFORCEMENT TO THE MOTOR MOUNT INDICATING THAT THEY KNEW OF A PROBLEM BUT WERE NOT WILLING TO ALERT OWNERS TO THE PROBLEM. I HAVE PICTURES OF MY BROKEN FRAME AND A 2007 AND LATER MODEL FRAME TO SHOW WHERE THE ENGINE MOUNTS WERE REINFORCED. *TR

AT ANNUAL INSPECTION MECHANIC NOTED RUST HOLES IN THE FRAME AND CORROSION IN CONNECTIONS OF PLATES TO FRAME. THIS IS OF COURSE A SAFETY HAZARD THAT PREVENTS THE VEHICLE FROM PASSING INSPECTION. DEALER INSPECTED AND CONFIRMED THE CORROSION. WE PURCHASED THE TRUCK NEW. WE LIVE ON A DIRT ROAD WITH NO SALT USE, KEEP THE TRUCK GARAGED IN WINTER, AND DO NOT DRIVE IT REGULARLY IN WINTER. IT IS OTHERWISE A SOUND AND TROUBLE-FREE VEHICLE. *TR

THE FRAME ON MY 2006 TOYOTA TACOMA HAS A RUST HOLE BY THE TRANS CROSS MEMBER. THE FRAME IS ALSO RUSTED VERY BADLY. I DRIVE 150 MILES A DAY ROUND TRIP TO WORK AND ALSO MY FAMILY IN THIS VEHICLE. *TR

FRAME ON MY 2006 TACOMA IS RUSTING/ROTTING OUT(ALMOST A HOLE BESIDE THE TRANSMISSION). TOYOTA WILL NOT ASSIST. I HAVE PIC'S AVAILABLE. *TR

THE FRAME ON MY 2006 TACOMA IS SHOWING MODERATE RUST AFTER 78,000 MILES. I DON'T LIVE IN A COLD WEATHER STATE. I'VE PROBABLY ONLY DRIVEN IT ON SALTED ROADS FOR A COUPLE OF WEEKS IN MAYBE 2 OF THE WINTERS I'VE OWNED IT. THE RUST IS WORST ABOVE WHERE THE REAR LEAF SPRINGS ARE, BUT BASICALLY THE ENTIRE FRAME SHOWS SIGN OF RUSTING. THE TACOMA IS TERRIBLE COMPARED TO THE FORD F-250 THAT WE'VE HAD FOR THE SAME AMOUNT OF TIME WITH MORE THAN 40,000 EXTRA MILES. THE FORD BARELY HAS ANY RUST AT ALL. I'M WORRIED THAT WITHIN 2 YEARS THAT MY FRAME WILL HAVE HOLES IN IT, AND THE TRUCK WILL NOT BE SAFE TO DRIVE. *TR

THE TRUCK WAS TAKEN TO A SERVICE GARAGE FOR THE REQUIRED ANNUAL STATE OF MAINE SAFETY INSPECTION. THE RESULTS DISCLOSED SEVERE RUSTING OF THE FRAME, ENGINE MOUNTS, AND CAB MOUNTS. BECAUSE THERE WERE NO PERFORATIONS IN THE FRAME, THE VEHICLE PASSED INSPECTION. THE MECHANIC ADVISED THAT THE TRUCK IS IN IMMINENT NEED OF FRAME REPLACEMENT. *TR

I BROUGHT CAR IN FOR ROUTINE OIL CHANGE. MECHANIC CALLED ME IN TO SHOW ME THE EXTREME RUST UNDER THE FRAME. IT IS FLAKING OFF IN CHUNKS AND ALMOST RUSTED THROUGH IN SOME PARTS. MECHANIC INFORMED ME THAT THIS WAS NOT NORMAL AND I SHOULD CONTACT TOYOTA FOR POSSIBLE RECALL INFORMATION. I CONTACTED TOYOTA, BUT HAVE NOT HEARD BACK FOR OVER ONE MONTH. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO A MECHANIC TO HAVE ROUTINE MAINTENANCE PERFORMED WHEN THE MECHANIC STATED THAT THE CHASSIS WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR FURTHER INSPECTION BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT WAS UNABLE TO PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 110,000. UPDATED 11/26/13*LJ