2006 TOYOTA TACOMA Complaints

I received a Toyota recall notification in Dec 2015 for a frame rust inspection, RO Number 307016. I have since noticed fairly major frame rust, with a long 2-inch by 7-inch opening on the inside of the frame below the driver-side seat. I took the vehicle to Toyota on 20 APR 2026 for a leaf spring recall #302870. I asked them to take a look and was told the recall 307016 had expired. The original recall inspection for rust either failed to identify it or the inspector was inadequate at identifying it.

Voss Toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.

I took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till spring and was a safety hazard. That was Dec. 2024 . The truck has been parked since . Ive had no transportation and can not run right out and buy another truck . I am also not willing to give up the truck either . I have put a lot of hard earned money into this truck believing it to last forever . The motor and train are sound . I do not want to junk the truck . Please , tell me what I can do . Yes . My vehicle is available for inspection upon request.

The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now shows advanced rust and structural weakness, which puts my safety and the safety of others at risk. I am concerned that the recall program was not adequately communicated or tracked, and I am requesting that the NHTSA review this issue for potential reopening or expansion of coverage for affected vehicles like mine. The vehicle is available for inspection if needed. Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2006 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the contact heard a loud noise coming from the rear of the vehicle with no warning light illuminated. The contact stated that while the vehicle was parked, the contact noticed that the rear subframe of the vehicle was fractured. The vehicle was towed to an independent mechanic, where it was diagnosed that the rear subframe of the vehicle failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 230,000.

The contact owns a 2006 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 12V092000 (Air Bags), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 220,000.

The contact owns a 2006 Toyota Tacoma. The contact stated that the vehicle failed the State Inspection because there was a hole approximately 3 inches wide on the driver's side of the vehicle near the catalytic converter. The vehicle was taken to the dealer, who confirmed that the hole was caused by extensive rust and needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was a recall issued twice; however, the recall had expired. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 130,000.

The truck's frame has severely rusted. The frame has deteriorated. It is unsafe to drive as the frame is breaking in half. According to Toyota, this was a huge problem with the 2006 Tacoma. They will not fix the frame or offer any solution. My son can not safely drive this vehicle.

I went in to get my truck worked on & was told it was not safe. The frame is rusted and cracked. I did not receive a recall notification. Now, I have a broken truck and cannot afford to buy another vehicle or pay to repair this one. This is a safety hazard for the other people on the road and a death trap for the owners with vehicles that Toyota will not stand behind.

Toyota Tacoma 2006 TRD, This vehicle was recalled for rust to the frame on 10/03/2018. The frame was replaced by Sheehy Toyota of Fredericksburg, Virginia. The work was done and completed con 02/07/2019. The vehicle supposedly was thoroughly inspected for any problems by the dealership. Then released to me after the work was done. Then in November of 2019 I moved from Virginia to Nebraska. Used this truck to move with and pulled a trailer over 2,000 miles with it. Little did I know my life was in danger due to negligence by the dealers service department. Recently I replaced the rear bumper on this truck. By doing this it fully exposed the trailer hitch system on the truck. This is when I clearly seen that a part of the trailer hitch was completely rusted through. When replacing the frame on this truck the dealership had to notice this severely damaged part. Yet they did not inform me of this situation. If they had, I would have had the part replaced, due to the chance of it breaking which could have caused an accident. This is nothing short of pure negligence on the part of this dealership. People could have been severely injured or killed due to this negligence. I have pictures of this part just the way they left it.