2006 TOYOTA TACOMA Complaints

The universal joint on the intermediate steering shaft corrodes and seizes causing a potential problem steering. It is a serious safety issue in my opinion. It is an on-going issue.

The contact owns a 2006 Toyota Tacoma. The contact stated that his father had taken the vehicle to a dealer to have NHTSA Campaign Number: 14V604000 (Suspension) serviced. Upon inspection, his father was informed that the recall could not be performed due to the extensive corrosion on the frame of the vehicle. He was also informed that the vehicle was unsafe to drive and was given an estimate of $16,000 for the repair. The manufacturer was then notified of the failure and offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 128,000.

My airbag warning light went off and the horn ceased functioning as well. The dealer charged me $170 to diagnose the problem as a broken spiral cable in the steering wheel. I asked about a recall for this part as there are plenty of other Toyota models with a recall for this same part. I was told that this particular VIN was not part of any campaign (yet). Are they actually different parts on the RAV4 and 4Runners or the same part?? There are plenty of documented failures and testimonials about the Tacoma issue but no recall??? Where does pressure need to come from to initiate one? Another $575 to fix it, what is a glaring safety issue.

The mechanic noticed rust the frame was rusty so recommend I take it to a metal shop to get an estimate for re-welding the frame and they are hesitant to even work on it because of how corroded it is. The cab is almost detached from the frame and the support above the rear axle is about to snap in half.

My frame rusted and broke into where spring hanger bolts to the frame. They are saying n was recalled but time has ran out but I did not receive a recall notice as we moved to another area of the state ( Ashtabula) where we bought a shop for our oilfield business then we moved to ( Cambridge ) and are now renting our first home from my daughter who bought it in New Concord. Sad thing is we had it to repair shop and had new steering, power steering pump, new front axles and no one said hey you should look at this frame it is rotten and I have a picture I can send you if you'd like.So it is totally broke into and the spring hanger is not attached and pushed the bed up and the driver nearly wrecked and we had to haul it back on a trailer.

The contact owns a 2006 Toyota Tacoma. The contact stated that upon inspection it was discovered that the entire subframe had sustained severe rust and corrosion damage. The cause of the failure was not determined. The vehicle was not repaired. The vehicle was taken to the local dealer who advised that the vehicle was too damaged to drive. The manufacturer was not yet notified. The failure mileage was 97,000. The VIN was invalid.

The contact owns a 2006 Toyota Tacoma. The contact stated while driving at various speeds, the vehicle would drift and pull to the left. The vehicle was taken to an independent mechanic who diagnosed that the subframe had experienced severe rusting and corrosion damage and that the structural integrity of the vehicle had been compromised. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 140,000.

The contact owns a 2006 Toyota Tacoma. The contact stated that he was made aware that the sub frame of the vehicle was rusted badly when the vehicle was taken to the dealer for faulty brake lines. The dealer informed the contact that they could not perform the brake line repair due to the sub frame rust. The contact was informed that the sub frame needed to be replaced. The contact stated that another dealer Germain Toyota of Columbus (5711 Scarborough Blvd, Columbus, OH 43232) had sealed and plugged the frame which caused the frame to rust from water damage. The vehicle was later taken to an independent mechanic for the brake line repair and remained at the mechanic. The manufacturer was not made aware of the failure. The failure mileage was approximately 220,000.

The contact owns a 2006 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 14V604000 (Suspension). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The part was available for repair. The contact had not experienced a failure. Parts distribution disconnect.

On June 26, 2021, I took my 2006 Toyota Tacoma to Bennett Toyota for regular maintenance. As part of the inspection, I was notified that the "Frame very rusted, perforation may begin on cab mounts in the next year" and the Service Advisor told me that my car would be unsafe to drive in a year or two. I told the Service Advisor that in 2015, I received a recall notice from Toyota regarding frame rust and took my 2006 Toyota Tacoma to Bennett Toyota to address the issue. On April 22, 2015, Bennett Toyota provided "Corrosion-Resistant Compound (CRC) Application; Remove Rust - Clean Frame - No Rust Perforation Found". Again on March 29, 2018, I requested that Bennett Toyota inspect the frame for corrosion perforation and was notified that "No Significant Perforation Found". The Service Advisor stated that the extended warranty had expired and there was nothing Bennett Toyota could do to address the rusted frame. I then called Toyota and opened case# 210628002014 to request the rusted frame be addressed/replaced/repaired and was told that the extended warranty had expired and there was nothing that Toyota would do to address the issue. I have a Toyota Tacoma with a known issue that is quickly becoming unsafe to drive and have no way to repair/replace the rusted frame.