2009 VOLKSWAGEN ROUTAN Complaints

THE VEHICLE'S RIGHT-REAR AXLE TRAILING ARM BROKE WHILE DRIVING AT A VERY LOW SPEED. THE BREAK IS VERY CLEAN AND IS LOCATED NEAR THE FRONT OF THE TRAILING ARM'S CUTOUT AREA, JUST BEHIND THE TRAILING ARM MOUNTING BRACKET.

DRIVING DOWNHILL, FOOT OFF ACCELERATOR. ABRUPT LOSS OF ENGINE POWER FOLLOWED BY LOSS OF POWER STEERING AND BRAKING. VEHICLE UNDER KNOWN RECALL AND HAS BEEN "FIXED". THIS INCIDENT HAS NOW OCCURRED 3-4X SINCE THE RECALL FIX, NEARLY IDENTICAL CIRCUMSTANCES APPROX EVERY 1-3 MONTHS. VW KEPT THE VEHICLE FOR > 2 WEEKS, UNABLE TO IDENTIFY THE PROBLEM, VEHICLE WAS RETURNED TO ME WITHOUT ANY NEW ATTEMPTS AT FIXING IT. I WILL BE RETURNING IT TO VW AND TAKING IT OUT OF SERVICE.

VEHICLE LOSES POWER, LOSING POWER STEERING, BRAKES, ETC. WARNING LIGHTS ILLUMINATE. ABLE TO RESTART ENGINE BY SHIFTING INTO NEUTRAL AND TURNING KEY TO START. ***HAPPENS MULTIPLE TIMES APPROX EVERY 1-3 MONTHS, RANDOM*** TAKEN IN FOR RECALL FIX FOR THIS KNOWN PROBLEM IN 2015. HAS HAPPENED NOW 3-4X SINCE THE RECALL FIX. EXTENDED TESTING BY VW HAS NOT ESTABLISHED A REASON. MULTIPLE ATTEMPTED FIXES, NO CHANGE TO THE LOSS OF POWER. LAST HAPPENED 9/6/2015, TRAVELING 40MPH DOWNHILL IN GEAR, ABRUPT LOSS OF POWER, FOLLOWED BY LOSS OF POWER STEERING AND LOSS OF POWER BRAKES. AGAIN, ABLE TO RESTART BY SHIFTING INTO NEUTRAL AND TURNING THE KEY TO START.

IN TURNING INTO A PARKING LOT I HEARD A "PING" IN THE REAR OF THE VEHICLE. I IMMEDIATELY FELT A LOSS OF CONTROL IN THE REAR SUSPENSION. IT WAS CLEAR THAT THE VEHICLE WAS NOT ROADWORTHY AT THAT POINT AND WE HAD IT TOWED TO A REPAIR SHOP. WE WERE INFORMED THAT THE REAR AXLE HAD BROKEN.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BRAKE PEDAL FAILED TO RESPOND WHEN DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,300.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

2009 VOLKSWAGEN ROUTAN. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL REPAIRS. *SMD THE CONSUMER STATED THE DEALER HAD HIS VEHICLE FOR TWO WEEKS TO PERFORM THE IGNITION RECALL. HOWEVER, ON JUNE 15, 2015, THE PROBLEM RETURNED, WHEN THE VEHICLE STALLED WHILE DRIVING. *JB

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING WHEEL JERKED AND THE VEHICLE SHUT OFF. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

ON 6/21/15, I WAS DRIVING ON THE HIGHWAY WITH CRUISE CONTROL SET AT APPROXIMATELY 75MPH. I WAS NOT ACCELERATING, NOR HAD MY FOOT ON THE GAS OR BRAKE PETAL. WITHOUT ANY WARNING, THE GAS PETAL PUSHED TO THE FLOOR AND THE VEHICLE BEGAN ACCELERATING QUICKLY. I IMMEDIATELY TURNED ON MY HAZARDS AND TURNED OFF THE CRUISE, BUT THE VEHICLE CONTINUED TO ACCELERATE IN EXCESS OF 100MPH. I FEARED COLLIDING WITH OTHER DRIVERS ON THE TWO-LANED HIGHWAY, AND BEGAN BRAKING AGAINST THE CAR'S ACCELERATION, WHICH WAS QUITE DIFFICULT. I PUSHED THE BRAKE PETAL DOWN AS HARD AS I COULD, WHICH STOPPED FURTHER ACCELERATION; BUT DID NOT SLOW THE VEHICLE QUICKLY. THE VEHICLE CONTINUED TO REV UP AND TRIED RELENTLESSLY TO ACCELERATE AGAINST MY BEST EFFORTS TO BRAKE. I WAS ABLE TO MOVE THE VEHICLE TO THE GRAVEL SHOULDER. ONCE I WAS ABLE TO SLOW THE VEHICLE TO AROUND 20MPH, I TURNED OFF THE VEHICLE AND COASTED TO A STOP. THERE WAS A STRONG SMELL OF SMOKE FROM THE BRAKES. I BELIEVED THE PROBLEM WAS RELATED TO A CRUISE CONTROL MALFUNCTION OR A RELATED SENSOR. I DISCONTINUED USING THE CRUISE AT ANY TIME. HOWEVER, ON 7/9/15, THE SAME PROBLEM OCCURRED. THIS TIME, THE CRUISE WAS NOT SET, AND THE VEHICLE WAS TRAVELING AT APPROXIMATELY 50MPH IN HEAVY TRAFFIC DURING RUSH HOUR ON A THREE LANE FREEWAY. THE SAME STEPS NOTED ABOVE SLOWED THE VEHICLE AFTER IT BEGAN ACCELERATING OUT OF CONTROL, MAKING IT DIFFICULT TO NAVIGATE THROUGH THE SURROUNDING VEHICLES. THE GAS PETAL WAS AGAIN STUCK TO THE FLOOR AND COULD NOT BE PULLED UP. AFTER THE SECOND OCCURRENCE, THERE IS LIKELY SIGNIFICANT DAMAGE TO THE BRAKES AND/OR ENGINE. I CONTACTED A VOLKSWAGEN DEALERSHIP, THAT PLANS TO DIAGNOSE THE VEHICLE. I AM FEARFUL OF DRIVING THE VEHICLE TO THE DEALERSHIP, BUT WAS INSTRUCTED BY THE VW SALES MANAGER TO BRING THE VEHICLE IN FOR INSPECTION AND BE SURE TO TURN THE KEY TO "OFF" OR "ACCESSORY" SHOULD THE PROBLEM OCCUR AGAIN.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.