2025 VOLVO EX90 Complaints

Failure of the onboard AC charging component, known as the Grid to High Voltage Converter A (GHCA) or onboard charger module. This vehicle would not charge on AC current, but could only be charged on DC current. This is a safety issue, as you may get stranded without access to a DC capable charger, since AC is the primary source for a majority of EV owners. Problem has been confirmed by the dealer. Volvo seems to be aware of the issue, as this is a common failure point according to other Volvo EX90 owners. Warnings that occur is a red illuminated light near the charge port when it is unable to accept a AC charge due to failure.

My 2026 Volvo EX90, with approximately 3,000 miles, experienced a complete vehicle failure while being used as our family vehicle in Phoenix, Arizona. While my nanny was driving my two young children, including my [XXX], the air conditioning stopped functioning during approximately 110–115°F outside temperatures. After she parked, the vehicle’s displays went dark and the vehicle became completely unresponsive. The exterior door handles also stopped functioning normally. My nanny was unable to open the rear doors from outside to remove the children and had to climb through the front seats into the rear passenger area in order to gain access and get them out of the vehicle. The vehicle would not respond to the key, would not restart, and did not respond to Volvo’s recommended reset procedures. Roadside assistance was required and the vehicle was towed to an authorized Volvo dealership. Several days later, the vehicle remains completely inoperable. The Volvo dealer has been unable to power the vehicle on, establish diagnostic communication with it, or open the doors normally. The vehicle is so immobilized that the dealership must place it on dollies simply to move it around the facility. This appears to involve substantially more than an infotainment failure. The incident involved simultaneous loss of climate control in extreme heat, complete vehicle shutdown, and loss of normal exterior door access while young children were passengers. I am particularly concerned about the potential safety implications if this failure were to occur again in extreme heat or in another situation where occupants needed to exit the vehicle quickly. The vehicle remains at the Volvo dealership for diagnosis, and no root cause has yet been identified. Vehicle: 2026 Volvo EX90 Mileage: Approximately 3,000 miles Location: Phoenix/Scottsdale, Arizona Injuries: None Crash: No Fire: No Police report: No Vehicle towed: Yes INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving the car on a state road (45 mph) the car suddenly notified me of an "electrical fault", a light that looks like a turtle came on, and the vehicle lost power and couldn't go any faster than 5 mph. Another vehicle almost rear-ended me around a blind curve because I was moving significantly slower than normal traffic. I pulled into a parking lot, shutdown and restarted the car and everything seemed fine. It happened again a few minutes later so we started to head back home. But the real issue happened a minute or so after the second fault - the fault cleared itself and all of a sudden the vehicle's speed shot up to over 60 mph with very little throttle response or control from me. I slowed the car down using the brakes and continued home. The fault happened again, and cleared itself again in the same manner but this time while I was turning causing me to almost hit a curb while trying to turn. The car is dangerous. These should be taken off the road permanently.

the vehicle exhibits a persistent defect in which the doors lock and unlock without driver command. Specific effects I have experienced: The vehicle has locked itself while I was exiting, locking me out with the key in my possession. On multiple occasions this has occurred with my child inside the vehicle, with my dogs inside the vehicle, and with personal belongings inside the vehicle, with no ability to unlock it. These incidents have occurred in extreme heat conditions, where the interior of a closed vehicle can reach lethal temperatures within minutes. Volvo telephone support instructed me to call a locksmith. In the referenced conditions this response is not a remedy. It is an unacceptable exposure of a child and animals to serious injury or death. The vehicle has also unlocked itself spontaneously while I was nowhere near it, leaving it and its contents unsecured. Repair history: The vehicle has been presented to an authorized Volvo dealership on 3 occasions for this concern. The dealership's lead engineer performed multiple system resets, none of which resolved the condition. He advised that the vehicle may need to be "put to sleep," that the condition is likely not repairable, and that seat and seat-belt occupancy sensors are the suspected source of the uncommanded locking and unlocking. He further advised that he would document the file in support of a manufacturer repurchase, and that I should move to the 2026 model year, in which he stated these faults have been addressed.

I was parked in a parking lot and when I released my foot from the break, the car accelerated on its own and crashed into the car in front of me. The automatic emergency braking did not deploy. It was most recently a safety risk and put others in the parking lot, particularly the driver in front me, in danger. I have reported this issue to Volvo and they instructed me to get the body of the car repaired and then the dealer will inspect it. I filed an insurance claim with my insurance company and the car is going to be repaired. There were no warning lamps or messages prior to the failure.

While parked, unoccupied, and locked on a nearly level asphalt residential driveway, the vehicle began moving on its own and traveled approximately 15 feet down the driveway before coming to rest. The movement began several hours after anyone had last operated the vehicle. Conditions were dry at onset with no ice or snow beneath the tires. No driver was present and no input was given. The driveway terminates at a public street. The event was captured in its entirety on a residential exterior security camera. Eleven video files exist and are available for inspection on request. The vehicle itself is also available for inspection. Safety risk: an infant and two dogs are present in the household, and the vehicle traveled toward a public roadway with no occupant able to brake or steer. Had a person or child been in the path, or had the vehicle reached the street, the outcome could have been a serious injury or collision. The failure has not been reproduced or confirmed by any dealer or service center. The event was reported to the manufacturer's customer care in writing in March 2026 and escalated in April 2026. No diagnostic inspection was offered at that time and no response was received for approximately three months. The vehicle was delivered to an authorized dealer in July 2026, and the manufacturer dispatched a field specialist. No root cause has been provided to the owner in writing. Whether the manufacturer identified a cause is UNKNOWN. Prior warning symptoms: beginning within weeks of delivery in December 2025, the vehicle displayed recurring fault messages including headlight fault, system communication fault, emergency call system fault, charging fault, and park assistance fault, on separate and unrelated occasions over several months, documented with date-stamped photographs. Separately, in May 2026 the vehicle suffered a total failure and would not start, with blank displays and non-functioning turn signals, resolved only by a factory reset.

I am submitting this complaint because I believe my Volvo electric vehicle has a serious and recurring safety-related defect that has not been permanently repaired despite multiple repair attempts. Since purchasing the vehicle new, it has repeatedly failed to operate as intended, left me stranded multiple times, and continues to display warning messages while driving. I purchased the vehicle new on November 20, 2025, for approximately $85,000 with zero miles. The first failure occurred on December 4, 2025, at approximately 578 miles when the vehicle stopped charging. Volvo attempted repairs, but the same charging defect returned. The vehicle required additional repairs on January 21, 2026 (1,304 miles), early March 2026 (2,846 miles), and April 27, 2026 (3,810 miles). Despite multiple repairs and component replacements, the same issue continued. By the fourth repair, the vehicle had been out of service approximately 80 days. Volvo later approved a manufacturer repurchase; however, while waiting for the repurchase process, the vehicle developed additional failures where it would completely lose power and become inoperable. The vehicle required towing on multiple occasions, leaving me stranded and without transportation. During a later repair visit, Volvo kept the vehicle for approximately 39 days and stated they could not duplicate the problem and that the vehicle was operating as designed. The day after receiving the vehicle back, the same failure occurred again. The vehicle has now required seven repair attempts. Even after the latest repair, I continue to receive dashboard warnings while driving instructing me to stop the vehicle. Due to the repeated failures, loss of vehicle operation, and unresolved warnings, I have lost confidence in the safety and reliability of this vehicle and have changed my driving habits to avoid being stranded. I believe these recurring failures represent a potential safety defect that warrants investigation by NHTSA.

This vehicle locks itself even with a fully charged key tag inside it. The driver is not able to open the car by lifting any of the door handles. It has occurred 3 separate times. It will only open with a key card. Should the driver not have a key card outside of the vehicle, it must be towed to the dealership for service. The dealer has been advised of the problem, although the service department is unable to identify why or how this occurs. This has happened at various times of the day, including late at night, and we reside in a rural area with very limited alternate transportation. No warning messages appear prior to the problem.

I purchased a 2025 EX90 on XXX. Immediately upon purchase, nearly every time my [XXX] daughter was riding in the middle seat using the integrated booster, the car would alert me that someone was sitting in the other two seats on either side of her. There were also occasions when only one seat alarm would go off. I checked her positioning to confirm that there was nothing on those seats. I took it into the dealership the following Monday. They did a software update, which they stated would resolve the issue. I picked up the car on the evening of XXX. For the next couple of days, it appeared that the issue had been resolved; however, it returned within a couple of days. Additionally, there were two instances, after receiving the car back from being repaired the first time, in which my daughter was riding with me, and her seatbelt failed to engage during rapid deceleration. I was driving on a main arterial street near our home, traveling approximately 35-40 mph. I was using single-pedal mode (EV) and took my foot off the gas pedal to prevent a crash. The car stopped very quickly, and she was thrown forward, nearly missing hitting her head on the back of the passenger seat. Subsequently, while driving the same minor child in a dealership loaner XC90, we experienced a routine quick stop at a very slow speed, and she immediately noted that the XC90 seatbelt was properly tightened. This side-by-side comparison confirms that the EX90's occupant restraint system failed to deploy during a near-crash event. I returned the vehicle on XXX, and the card has been there since. On XXX, Volvo Corporate Engineering reviewed the data and confirmed a diagnosis of faulty radar sensors in the second row. Because the EX90's computer-controlled safety belts rely on these second-row sensors to work properly, this diagnosis from Volvo proves the safety systems in my daughter's row were actively broken during our near-miss collision event. The vehicle is unsafe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S

When in reverse, the infotainment system allows a user to swipe down from the top of the screen to open the notification window which overlays the backup camera, and upon closing the notification window, the backup camera is dismissed and is no longer visible.