2004 VOLVO S40 Complaints

I WAS DRIVING HOME AT NIGHT WHEN ALL OF THE GAUGES IN MY CAR WENT OUT COMPLETELY. I HAD NO SPEEDOMETER, NO GAS READING, NO ENGINE HEAT METER, THE MESSAGE CENTER WAS OUT, NO TURN SIGNALS. THIS IS A 2 YEAR OLD VEHICLE THAT WAS PURCHASED BRAND NEW FROM VOLVO IN 2004. I HAD TO DRIVE HOME 60 MILES ON AN EXTREME;Y DARK ROAD WITH NO SAFETY GAUGES- I COULDN'T CALL FOR ROADSIDE AS I WAS ALONE AND AM A WOMAN- I WASN'T GOING TO STOP ON THE SIDE OF THE ROAD TO WAIT FOR ROADSIDE. I WAS TOLD BY VOLVO THAT IT WAS THE DDM MODULE AND THE WIRING HARNESS- MY ELECTRICAL /COMPUTER SYSTEM WENT BAD. HOW IS THAT POSSIBLE IN A BRAND NEW CAR? FURTHERMORE, I WAS 1,000 MILES OVER THE MANUFACTURER'S WARRANTY OF 50,000 MILES- THUS VOLVO CHARGED ME $1,645.00. WITHIN IN MINUTES OF DRIVING THE CAR AFTER IT WAS REPAIRED- THE SERVICE ENGINE LIGHT CAME ON. I WAS TOLD THAT MY SOFTWARE HAD TO BE UPGRADED AND MY THROTTLE CLEANED? I BELIEVE THAT THE ELECTRICAL/COMPUTER SYSTEMS IN THESE CARS ARE NO GOOD. *NM

THE VEHICLE HAS THE FOLLOWING INTERMITTENT ELECTRICAL PROBLEMS. DASHBOARD, RADIO, CLIMATE CONTROLS TURN-OFF BY THEMSELVES. WIPERS ACTIVATE BY THEMSELVES. SRS WARNINGS ARE DISPLAYED. FUEL DOOR BUTTON DOES NOT ACTIVATE. IGNITION WILL NOT ACTIVE SO CAR WILL NOT START. *JB

THE ENGINE DIES INTERMITTENTLY ONCE EVERY SIX MONTHS. THIS NORMALLY HAPPENS WHEN MAKING A RIGHT TURN OR SLOWING DOWN. ALL OF THE WARNING LIGHTS IN THE DASHBOARD LIGHT UP. THE GEAR MUST BE PUT BACK IN PARK, MUST TURN OFF THE IGNITION AND THEN RE-START AGAIN. THE FIRST TIME IT HAPPENED, I THOUGHT IT MIGHT HAVE BEEN A FLUKE, THE SECOND TIME I TOOK IT IN THEY CHANGED A VALVE IN THE ENGINE, THE THIRD TIME THEY KEPT THE CAR FOR 2 WEEKS AND THEY CHANGED THE AIR COMPRESSOR AND POSITIVE/NEGATIVE BATTERY CABLES (THEY HAD A VOLVO OF NORTH AMERICA TECHNICIAN COME DOWN). THE LAST TIME IT HAPPENED WAS FRIDAY, AUGUST 19, 2005. I'VE CALLED THE DEALERSHIP AND THEY DON'T SEEM TO WANT TO TAKE MY CALL.

DURING A FRONTAL DRIVERS SIDE CRASH THE DRIVERS SIDE AIRBAG DID NOT DEPLOY CAUSING INJURY TO THE DRIVER. HOWEVER THE PASSENGER SIDE AIRBAG DID DEPLOY, BUT NO PASSENGERS WERE PRESENT AT THE TIME OF THE ACCIDENT. THE IMPACT OF THE CRASH WAS MOSTLY DRIVERS SIDE. I ALSO BELIEVE THE BRAKING SYSTEM FAILED SINCE MY CAR FAILED TO SLOW LIKE A CAR SHOULD DURING BRAKING.

2004 VOLVO S40 EXPERIENCING PROBLEMS WITH THE REAR TAIL LIGHT ASSEMBLY. *MR THE LEFT REAR TAIL LIGHT ASSEMBLY WAS INTERMITTENT. AT NIGHT THERE WOULD BE NO REAR TAIL LIGHTS. THE RIGHT FRONT PARK LIGHT AND THE YELLOW SIDE MARKER LIGHT HAD GONE OUT AS WELL. THE DEALER REPLACED THE CEM. THE VEHICLE'S BATTERY LASTED 8 MONTHS. *SC

CONSUMER COMPLAINED ABOUT ELECTRICAL PROBLEMS. THE WINDSHIELD WIPERS SUDDENLY CUT ON AND OFF AT TIMES; THE POWER WINDOWS AND DOORS DID NOT WORK, AND GAS GAUGE ALWAYS SHOWED THAT VEHICLE HAD NO FUEL. ALSO, AIRBAG LIGHT CAME ON. FINALLY, THE TRUNK DID NOT OPEN. *AK

CONSUMER IS EXPERIENCING ON GOING PROBLEMS WITH APPLYING THE BRAKE PEDAL AND THE ACCELERATOR PEDAL SIMULTANEOUSLY. THE CONDITION CAUSES THE VEHICLE TO ACCELERATE WHEN APPLYING THE BRAKES. THE VEHICLE HAS BEEN TO THE DEALER. THE DEALER INFORMED THE CONSUMER THAT NOTHING WAS WRONG AND THE VEHICLE MEETS NHTSA SPECIFICATION . *JB

THE CONSUMER STATED THE VEHICLE ACCELERATED WHEN BRAKE WAS APPLIED. A RECALL WAS ISSUED, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS OUTSIDE OF THE REMEDY SCOPE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB. THERE WERE FIVE INCIDENTS WHEN VEHICLE ACCELERATED APON APPLICATION OF BRAKES. INITIALLY TOOK VEHICLE TO VOLVO ON 11/11/2004. THEY RAN ALL TESTS AND COULD FIND NOTHING WRONG. SINCE THEN, IT HAPPENED AGAIN, AND CONSUMER WILL AGAIN REQUEST VOLVO TO CHECK IT. *AK

MULTIPLE FAILURES. AIR BAG SYSTEM, PROBLEM STARTING AND NOISE IN STEERING. *BF THE VEHICLE ALSO HAD AN AIR CONDITION PROBLEM. THE AIR BAG LIGHT ILLUMINATED ON 3 OCCASIONS. THE CONSUMER STATED THE PASSENGER SEAT WAS EQUIPPED WITH A DEVICE THAT WEIGHED PASSENGERS TO DETERMINE IF THE AIR BAG SHOULD BE ACTIVATED. *JB