2001 VOLVO S60 Complaints

TRANSMISSION FAILURE WHILE DRIVING 0 THIS HAS HAPPENED AT BOTH LOW AND HIGH SPEEDS. THIS IS THE FORTH TIME IN TWO YEARS THAT MY VOLVO S60 2.4 HAS HAD THIS TYPE OF FAILURE. THREE TIMES BEFORE IT HAS SUPPOSEDLY BEEN REPAIRED - BUT YET AGAIN IT THE TRANSMISSION HAS FAILED. THREE TIMES IN HEAVY TRAFFIC SITUATIONS - THREE TIMES PUTTING MYSELF IN JEOPARDY. VOLVO SEEMS INCAPABLE OF FIXING THIS VERY DANGEROUS PROBLEM.AK

FOR BOTH OUR 2001 VOLVO S60 2.4T AND OUR 2003 VOLVO XC90 2.5T AWD, THERE HAVE BEEN UNSUCCESSFUL ATTEMPTS TO REPAIR A TRANSMISSION DEFECT (ESSENTIALLY SAME TRANSMISSION IN BOTH VEHICLES PER VOLVO TECH SUPPORT). BETWEEN 2ND AND 3RD THERE IS. *AK INTERMITTENT/UNPREDICTABLE FAILURE TO ENGAGE 3RD IN TIMELY FASHION WITH RESULTANT LOSS OF ACCELERATION AS VEHICLE IS FUNCTIONALLY IN NEUTRAL FOR 0.5 TO 2.5 SECONDS. THIS IS EXTREMELY DANGEROUS, ESPECIALLY WHEN PULLING ON TO A HIGHWAY. WE HAVE EXPERIENCED 2 NEAR COLLISIONS (ALMOST BEING STRUCK FROM BEHIND). VOLVO TECH SUPPORT ACKNOWLEDGES A FLAW IN DESIGN CAUSING SERVO FLUID AIR LOCK IN THE 2001 MODEL. A NEW TRANSMISSION IS SCHEDULED TO BE REPLACED FOR OUR S60, BUT IF THE PROBLEM IS STILL OCCURING IN OUR 2003, WILL THIS CORRECT THE PROBLEM? THE XC90 THEY SAY CAN BE REPAIRED WITH "UPGRADED SOFTWARE" INSTALLATION (WHICH IS SCHEDULED FOR THAT VEHICLE) BUT THIS REMEDY FAILED WHEN PERFORMED ON THE 2001. WE HAVE LET THE DEALER KNOW WE FEEL BOTH VEHICLES ARE UNSAFE WITH THIS PROBLEM AND WE ARE NOW STUCK WITH THEM TRYING TO REMEDY BOTH GLARING SAFETY DEFECTS.

PIRELLI FOUR SEASONS P6, TIRE SIZE P235/45 R 17, DOT NO. XBCUC236, I HAVE HAD THREE INSTANCES WHERE THE TIRES HAVE EXPERIENCED SUDDEN DEFLATION WHILE PARKING ALONG A VALLEY CURB. NO DAMAGE TO THE TIRES BUT HAD TO HAVE THEM REMOUNTED AND BALANCED. I HAVE ALSO HAD TWO INSTANCES WHERE THE TIRES HAD SUDDEN DEFLATION WHILE DRIVING, ONCE AT 35 MPH AND ONCE AT 70 MPH. IN BOTH INSTANCES, I WAS NOT IMMEDIATELY AWARE OF THE DEFLATION AND THE TIRES WERE RUINED AS THEY WERE DRIVEN FLAT. THERE WAS NO OTHER DAMAGE TO THE TIRES AND THERE HAD NOT BEEN ANY IMPACTS TO THEM PRIOR TO DEFLATION. THE TIRES WERE PROVIDED AS ORIGINAL EQUIPMENT ON MY 2001 VOLVO S60. *LA

FRONT WHEEL BEARINGS HAVE BEEN REPLACED 4 TIMES NOW WITH ONLY 17,000 MILES ON VEHICLE (2 LEFT & 2 RIGHT).

THE MILEAGE ON THE PERELLI P6 TIRES FOR VOLVO S60 T5 IS ONLY 11,000 MILES. DURING A CRUSING ON THE FREEWAY, THE DRIVER HEARD A LOUD "POP" NOISE INSIDE THE CAR. AFTER THE CAR WAS DRIVEN HOME (WITHIN 5 MILES), THE DRIVER NOTICE A FLAT TIRE SHORT TIME LATER. I WENT TO VOLVO'S DEALER SERVICE DEPARTMENT ON 6/25/03 TO SEE IF I CAN GET SOME ASSISTANCE OR EXPLAINATION ON THE CAUSES OF MY TIRE PROBLEMS. THE SAME THING HAPPENED 2 TIMES BEFORE ON THE OTHER TIRES. I WAS SURPRISED HOW LITTLE HELP I GOT FROM THE SERVICE CONSULTANT WORKING THERE. IT APPEARS THAT THEY DON'T EVEN CARE TO HEAR OR DISCUSS MY PROBLEMS. LATER ON, I FIND OUT INFORMATION FROM NHTSA THAT OTHER DRIVERS ALSO EXPERIENCED PROBLEMS WITH PIRELLI P6. SINCE I DON'T FEEL SAFE DRIVING ON THESE FACTORY INSTALLED TIRES, I DECIDE TO REPLACE THEM THE FOLLOWING DAY.*AK

THROTTLE MODULE FAILED, LEAVING ME PULLING ONTO INTERSTATE, BUT UNABLE TO GO MORE THAN 20 MPH BEFORE CAR DIED. DEALER SAID THAT THEY HAD SEEN 3 OF THESE FAILURES THIS WEEK AND WAS A COMMON OCCURRENCE ON THE S60. *NLM

I RECENTLY BROUGHT MY VOLVO S60 FOR 15000 MILE SERVICE(MY CAR HAD 16200) AND WAS INFORMED THAT I NEEDED 4 NEW TIRES. HOW SHOCKED WE WERE. THE DEALER INFORMED US THAT THIS WAS PIRELLI AND WE MUST CONTACT THEM. I DID AND WAS TOLD TO SEE A AUTHORIZED PIRELLI DEALER. BROUGHT THE CAR IN WAITED AND THEN TOLD ME THEY WILL ONLY TAKE 20%OFF. WHILE I WAITED FOR TIRE DEALER TO RETURN MY CALL BUBBLES FORMED IN THE TIRES. THIS CAN'T BE SAFE . VOLVO PRIDES THEMSELVES ON SAFE CARS. HOW SAFE CAN THEY BE WITH BAD TIRES. PIRELLI AND VOLVO BETTER WATCH OUT. REMEMBER FORD AND FIRESTONE. THEY ARE ONLY A FEW MILES BEHIND. NO FATALITIES YET!!!*JB

WHILE DRIVING, SUN ROOF FAILED TO OPEN AND INTERIOR LIGHTS WOULD NOT TURN ON. BROUGHT TO VOLVO DEALER AND SERVICE MANAGER CLAIMED THE EXXON/MOBIL SPEED PASS THAT WAS ATTACHED TO THE KEY CHAIN CAUSED THE ELECTRICAL INTERFERENCE SUCH THAT THESE ITEMS COULD NOT WORK. IF THIS IS THE CASE, ISN'T THIS A HAZARD FOR THOUSANDS OF OTHER VOLVO DRIVERS WITH SPEED PASS AND VOLVO CARS? WHAT OTHER ELECTRICAL EQUIPMENT COULD FAIL WHILE DRIVING? *CB

THE WINDSHIELD CRACKED WHEN WATER WAS APPLIED TO IT WHILE WASHING THE CAR. *JB

WHEN THE VEHICLE WAS AT IDLE IT SHOOK. THE DEALERSHIP CLEANED THE THROTTLE, BUT THE PROBLEM STILL EXISTED. *NLM AFTER MANY TIMES OF GOING TO THE DEALER FOR REPAIRS, THE TIMING VALVES WERE FOUND TO BE A PROBLEM IN WHICH THEY WERE FRACTURED. ALSO, THE ELECTRICAL BULBS IN THE FRONT AND TAIL HAD FAILED. SCC