2003 VOLVO S60 Complaints

THE DASH INFORMATION SYTEM WILL RANDOMLY GO BLANK AND DISPLAY SRS AND BRAKE FAILURE, ALONG WITH ALL INFORMATION LIGHTS BLINKING ON AND OFF. ALSO THE ANALOG GAUGES LIKE THE SPEEDOMETER AND FUEL GAUGE WILL GO TO "0" AND EMPTY OR JUST MOVE ERATICALLY TO ANY NUMBER OR POSITION WHILE DRIVING. AT NIGHT SOMETIMES THE ENTIRE DASH OR INFORMATION CENTER WILL GO BLACK (NO LIGHTS AT ALL) AND ON ODD OCCASIONS ONE HEADLIGHT MAY GO OUT AND COME BACK ON. *TR

DASHBOARD INSTRUMENT CLUSTER GOING ON AND OFF-HAD IT TESTED SEVERAL TIMES-STAYS OFF--NO GAUGES OR LIGHTING-THIS IS A COMMON PROBLEM WITH ALL VOLVOS AND I AM THINKING IT IS A SAFETY ISSUE-AND WHY HAD IT NOT BEEN RECALLED YET?? THIS IS A REPAIR THAT I HAVE TO FIX-AS IT IS ALMOST 1500 DOLLARS---VOLVO FORUMS HAS SEVERAL HUNDRED PEOPLE COMPLAINING OF THIS--BEFORE I GET REPAIR I AM WONDERING IF VOLVO SHOULD CONTRIBUTE--- *TR

WHILE DRIVING OUT OF A PARKING LOT AND ACCELERATING TO 35 MPH, ENTIRE DASHBOARD BLACKED OUT. NO SPEEDOMETER, NO ODOMETER, NO GAS GAUGE,NO MESSAGE. RADIO, WINDOWS, AND AIR CONDITIONING CONTINUED TO WORK NORMALLY, AS DID HEADLIGHTS, INTERIOR LIGHTS, AND TURN SIGNALS. I TURNED OFF ENGINE AND THEN RESTARTED CAR. SAME SYMPTOMS. THE THIRD TIME I RESTARTED CAR I RECEIVED MESSAGE ON PANEL, SRS/AIRBAG SERVICE URGENT LIGHT COMES ON AND STAYS ON. I COULD NOT RETRIEVE ANY OTHER INFORMATION REGARDING AVERAGE SPEED, HOW FULL GAS TANK IS, ETC. I JUST WENT OUT TO MY CAR, WHICH HAS BEEN PARKED FOR ABOUT 21/2 HOURS SINCE THE INCIDENT, TO GET THE MILEAGE FOR THIS REPORT AND PANEL LIGHTS HAVE DISAPPEARED AGAIN! I WILL GET CAR TO MECHANIC TOMORROW, BUT I FEEL THIS IS A VERY DANGEROUS SITUATION TO BE IN,AND ESPECIALLY WITH NIGHT TIME OR HIGH SPEED HIGHWAY DRIVING! MY MILEAGE IS APPROXIMATELY 94,000 MILES. I COULD NOT GET A READING FROM MY ODOMETER AS THE PANEL IS BLACKED OUT AGAIN! *TR

THE ENTIRE INSTRUMENT PANEL WENT DEAD, AND WILL NOT COME BACK TO LIFE. THE TACHOMETER, ODOMETER, SPEEDOMETER AND FUEL GAUGE ARE OFF AS THOUGH THE CAR IS OFF. SEVERAL MECHANICS HAVE QUOTED ME $1200+ TO REPLACE THE ENTIRE INSTRUMENT PANEL. THE INSTRUMENTS WENT DEAD WHILE I WAS ON THE INTERSTATE AND LEAVE ME WITHOUT THE INFORMATION I NEED TO SAFELY DRIVE. VOLVO SHOULD RECALL THESE VEHICLES AND REPLACE THE FAULTY PARTS, THERE A QUITE A FEW FORUMS ON THE INTERNET WHERE OTHER VOLVO DRIVERS HAVE THE SAME INSTRUMENT FAILURE. *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING APPROXIMATELY 30 MPH, THE SRS AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL UNTIL THE KEY WAS REMOVED FROM THE IGNITION SWITCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND AN AUTHORIZED DEALER WHO BOTH ADVISED THAT THE DRIVER INFORMATION MODULE WITHIN THE COMPUTER SYSTEM WOULD NEED TO BE REPLACED. THE TECHNICIAN INFORMED THE AIR BAG WOULD NOT DEPLOY DURING AN IMPACT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 126,000. THE VIN WAS UNAVAILABLE.

VEHICLE BEGAN DISPLAYING CONFLICTING SPEED INFORMATION, ALONG WITH INTERMITTENT WARNING LAMPS. SPEEDOMETER FROZE AT CURRENT SPEED DURING DECELERATION, THEN GAUGES BEGAN TO FLUTTER SIDE TO SIDE. *TR

SINCE ABOUT THREE MONTHS AFTER I GOT MY CAR IN 2010 THE ENTIRE DASHBOARD SYSTEM DOES NOT WORK. THE GAUGES DO NOT MOVE OR TURN ON WHATSOEVER AND THE LIGHTS DO NOT COME ON. I HAVE LOOKED ON VOLVO FORUMS AND IT SAYS THAT THE MOTOROLLA CHIP IN THE DASHBOARD IS DEFECTIVE IN ALL OF THE 2001-2003 MODELS. IT IS RATHER SCARY IN MY OPINION NEVER KNOWING HOW MUCH GAS I HAVE OR HOW FAST I AM GOING. *TR

1) ELECTRIC READING OF DASHBOARD GOES COMPLETELY DARK. UNABLE TO DETERMINE SPEED, FUEL, ENGINE TEMPERATURE, ECT. URGENT AIR BAG WARNING LIGHT WENT ON PRIOR TO IT GOING DARK. CAR SKIPS GEARS AND REVS WHEN GAS PEDAL IS PRESSED. 2) RADIATOR COOLING FAN KEEPS RUNNING WHEN CONNECTED EVEN WHEN VEHICLE IS TURNED OFF. IT NEVER TURNS OFF UNTIL BATTERY IS DRAINED. REPLACED ENTIRE UNIT AS WELL AS BATTERY AND STILL HAS THE SAME PROBLEM. VOLVO REPAIR STATED THEY NEVER HAD AN ISSUE LIKE THIS AND ISSUE MAYBE CONNECTED TO FAILED ELECTRICAL SYSTEM. *TR

CAR EXPERIENCES LOSS OF POWER, STALLING, SPUTTERING AND HESITATION WHEN GAS PEDAL IS PRESSED DOWN. SAN LUIS OBISPO SMITH VOLVO AUTHORIZED DEALER COULD NOT FIND ANY CODES TO EXPLAIN THIS. CHECKED TIMING SENSORS, FUEL PRESSURE, RPM CAM SIGNALS, ETH SYSTEM, AIR FLOW METER, MAP SENSOR. ALL CHECKED OUT OK, DEALER SAID ALL SIGNS POINT TO ETA FAILING. CAR STALLS AND LOSES POWER ABRUPTLY, I DO NOT FEEL SAFE DRIVING IT ANYMORE. THERE IS A RECALL FOR MODELS UP TO 2002, THIS 2003 S60 NON TURBO MANUAL SEEMS TO EXHIBIT THE FLAWS OF ELECTRONIC THROTTLE FAILURE. *TR

I AM THE OWNER OF A 2003 VOLVO S60, THIS VEHICLE HAS BEEN A HEADACHE FOR SOME TIME NOW. THE FIRST ISSUE STARTED WITH THE HEADLIGHTS BLOWING OUT. I HAVE HAD THE CAR SINCE 2008 AND THE LIGHTS HAVE BLOWN OUT ATLEAST 10X'S. THE 2ND MAJOR ISSUE I'M HAVING WITH THE VEHICLE IS THE CAR COMPLETELY SHUTS DOWN WITHOUT WARNING WHEN MAKING A TURN OR SOMETIMES SITTING IDLE AT A RED LIGHT. OF COURSE WHEN THE CAR IS HOOKED UP TO A DIAGNOSTIC MACHINE THERE ARE NO ERROR CODES AND SINCE THIS ISSUE HAPPENS WITHOUT WARNING IT NEVER HAPPENS WHEN A SERVICE TECH IS WITH ME. LASTLY, TWO DAYS AGO I STARTED MY VEHICLE AND THE ENTIRE DASH COMPLETELY BLACKED OUT. NONE OF THE GAUGES ARE OPERABLE. I CANNOT SEE WHETHER I HAVE FUEL OR NOT IN IT. I FEEL THAT THE MANUFACTURER OF THIS VEHICLE SHOULD BE HELP RESPONSIBLE FOR THESE ISSUES. I HAVE READ MANY COMPLAINTS, AND THERE WERE MANY VOLVO OWNERS WHO HAVE HAD THE SAME EXACT PROBLEMS I HAVE BEEN EXPERIENCING. THERE NEEDS TO BE A RE-CALL SO THAT THE CONSUMERS WHO HAVE PAID SEVERAL DIAGNOSTIC FEES AND REPAIRS FEES GET REIMBURSED FOR THE FAULTY PRODUCTS OR PARTS BEING USED TO BUILD THESE VEHICLES. *TR