2003 VOLVO S60 Complaints

MY 2003 VOLVO S60 HAS A SEATBELT WARNING MESSAGE. THE DEALER DIAGNOSED THE PROBLEM AS A FAULTY DRIVER INFORMATION MODULE WHICH WOULD COST 1400 PLUS TAX TO REPAIR. THE CAR IS VALUED AT APPROXIMATELY 4000 AS A TRADE. THERE ARE MANY COMPLAINTS OF FAILURE OF THIS PART EVEN IN MUCH NEWER VOLVOS. *TR

I HAD A SIMILAR ISSUE ABOUT TWO YEARS AGO AND REPLACED THE CATALYTIC CONVERTER. JUST TODAY (9/25/10), MY 2003 VOLVO S60 BEGAN TO IRREGULARLY STALL WHILE DRIVING. WHILE I'M SLOWING DOWN, IT DOWNSHIFTS BY IT SELF, AND JUST DIES, AND WHILE I'M SLOWING DOWN, THE WARNING INDICATORS ON THE DASH ARE NOT LIT, AS IF NOTHING IS WRONG, BUT WHEN COME TO A COMPLETE STOP ALL THE LIGHTS ON THE DASH ARE LIT. THE CHECK ENGINE LIGHT THEN COMES ON, IT WASN'T ON BEFORE THIS HAPPENED. THIS CAN BE VERY DANGEROUS WHEN YOU ARE SLOWING DOWN TO TURN AT AN INTERSECTION. THE CAR STALL, YOU HAVE NO POWER STEERING AND YOU ARE DEAD IN THE MIDDLE OF TRAFFIC. THIS HAPPENED NO LESS THAN 10 TIME WHILE I WAS DRIVING TODAY. *TR

FRONT PASSENGER SIDE DOOR, WILL NOT OPEN FROM THE INSIDE AND WINDOW WILL NOT ROLL DOWN. WINDOW LOCKED IN PLACE AND THE MOTOR STRUGGLES IN ITS ATTEMPT TO ROLL IT DOWN. ALONG WITH THIS A WEEK LATER MY SUN ROOF DECIDED NOT TO OPEN, IN AN ATTEMPT TO OPEN THE SUN ROOF- ALL YOU HEAR IS A LOUD CLICKING SOUND. EVEN THEN IT BARELY CRACKS OPEN. *TR

I HAVE A 2003 S60 VOLVO. WHILE DRIVING 55 MPH THE CAR WOULD GO INTO LIMP MODE AND THE SPEED WOULD QUICKLY DROP TO 10 MPH AND THE MESSAGE REDUCED ENGINE PERFORMANCE WOULD BE DISPLAYED. THE CAR WILL NOT ACCELERATE PAST THAT SPEED. THIS IS VERY SERIOUS SAFETY CONCERN BECAUSE THE QUICK DROP IN SPEED MAY LEAD TO AN ACCIDENT. I TOOK THE CAR TO A VOLVO DEALERSHIP AND WAS INFORMED THE CAR NEEDS THE ELECTRONIC THROTTLE SYSTEM REPLACED. THIS WAS A COMMON PROBLEM WITH OLDER MODELS AND A RECALL WAS ISSUED AFTER A CLASS ACTION LAWSUIT. MY MODEL IS NOT INCLUDED IN THIS RECALL, HOWEVER; IT IS EXHIBITING THE EXACT SAME PROBLEM THAT USUALLY OCCURS WHEN THE CAR REACHES 100,000 MILES. *TR

2003 VOLVO S60 EXPERIENCED "DEATH" OF DRIVER INFORMATION MODULE (DIM), WHICH MONITORS ALL GAUGES ON THE VEHICLE. DEALERSHIP IS ABLE TO REPLACE THE PART FOR $1500! IT NOT AVAILABLE "AFTER MARKET" BY ANOTHER MANUFACTURER. RESEARCH ONLINE SHOWS THIS IS A VERY COMMON PROBLEM AMONG 2001-2003 MODELS. THIS MAJOR SAFETY CONCERN SHOULD BE INVESTIGATED, AS NUMEROUS PEOPLE ARE DRIVING WITHOUT DASH PANEL INFORMATION DUE TO THE EXORBITANT COST. THE PROBLEM BEGAN APPROXIMATELY TWO WEEKS AGO AND CANNOT BE REMEDIED WITHOUT BUYING THE DIM. *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY REPLACED THE ELECTRONIC THROTTLE ASSEMBLY AT THE CONTACTS EXPENSE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 64,000.

THE PASSENGER SIDE FRONT DOOR WILL NOT OPEN FROM THE INSIDE. THE CAR WAS BROUGHT TO GARDEN STATE VOLVO IN WALL, NJ IN MARCH FOR THIS TO BE FIXED. THE MECHANIC "FIXED" THE INSIDE CABLE WITH DUCT TAPE AND CHARGED US $175 FOR THE REPAIR. WITHIN A WEEK THE DOOR WAS BROKEN AGAIN. I CALLED GARDEN STATE VOLVO AND ASKED FOR THE PART TO REPAIR THIS PROBLEM TO BE ORDERED. I HAVE CALLED SEVERAL TIMES AND I HAVE BEEN TOLD THAT THE PART IS BACK-ORDERED AND IS COMING FROM SWEDEN. THIS IS A VERY DANGEROUS SITUATION, IN CASE OF AN ACCIDENT THE DRIVER CAN NOT GET OUT. *TR

2003 VOLVO S60 SEDAN. CONSUMER STATES RECEIPT OF LETTER FROM VOLVO REGARDING EXTENDED WARRANTY NOTICE INFORMING HER THAT THE VEHICLE HAS BEEN FITTED WITH A FAULTY FUEL PUMP *TGW THE CONSUMER STATED INSTEAD OF A RECALL, VOLVO SUGGESTED THAT THE CONSUMER ONLY TAKE THE VEHICLE IN FOR REPAIRS IF SHE SMELLED GAS OR HAD A GAS LEAK. THE CONSUMER STATED VOLVO WAS WILLING TO PUT HER LIFE AT RISK RATHER THAN FIXING THE PROBLEM UP FRONT. *JB

TL*THE CONTACT OWNS A 2003 VOLVO S60. WHEN THE CONTACT ATTEMPTED TO EXIT A PARKING SPACE THE VEHICLE SUDDENLY SURGED FORWARD WITHOUT WARNING. AFTER EXAMINING THE VEHICLE THE CONTACT NOTICED THAT THE DRIVER SIDE FLOOR MAT BECAME STUCK UNDER THE ACCELERATOR PEDAL. THERE WERE NO PRIOR WARNINGS AND THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

BRAKE BOOSTER STARTS LEAKING AIR FROM VACUUM PRESSURE. READ ONLINE THAT THIS IS QUITE OFTEN FROM OTHER VOLVO OWNERS AROUND THE TIME WHEN THE MILEAGE GETS TO BETWEEN 95,000 AND 100,000. REDUCED BRAKING POWER AS A RESULT OF DEFECT. *TW