2001 VOLVO S60 Complaints

IN VOLVO 2001 S60 T5. THE CAR SOMETIMES STOP ACCELERATING FOR SECONDS, AND THEN SUDDENLY IT CLICKS WITH A JOLT AFTER ABOUT A SECOND AND THE CAR LURCHES FORWARD. THE PROBLEM SEEMS TO BE HAPPENING WITH A LOT OF PEOPLE DUE TO A PROBLEM WITH THE VALVE BODY AS THE DEALER AND ANOTHER MECHANIC SUGGESTED (TRANSMISSION PART). THIS REQUIRE REPLACEMENT OF TRANS. VALVE BODY, SEALING KIT AND TCM UPGRADE. THEN TRANS OIL FLUSH. A TOTAL COST OF $2488 QUOTED FROM GALPIN VOLVO VAN NUYS CALIFORNIA. BELOW IS A PAGE SHOWING DIFFERENT CUSTOMERS ARE HAVING THE SAME PROBLEM. HTTP://WWW.MATTHEWSVOLVOSITE.COM/FORUMS/VIEWTOPIC.PHP?P=20617. *TR

I DRIVE A 2001 VOLVO S60. I PURCHASED IT NEW IN 2002. IT HAS A TOTAL OF 35,000 MILES. I DRIVE THE CAR SHORT DISTANCES AND IN TOWN ONLY. IT STARTED GIVING ME PROBLEMS A COUPLE OF WEEKS AGO WITH JERKING FORWARD. THE "TRANSMISSION REQUIRED" "CHECK ENGINE" MESSAGES CAME ON TODAY. I IMMEDIATELY BROUGHT IT TO A VOLVO DEALER WHO COULD NOT EXPLAIN TO ME WHAT THE PROBLEM IS UNTIL AFTER THEY PERFORM A DIAGNOSTIC TEST AT A COST $122.00. I FELT THAT I HAD NO OTHER RECOURSE BUT TO LEAVE IT WITH THEM. I DON'T FEEL THAT MY CAR SHOULD EXPERIENCE TRANSMISSION PROBLEMS SINCE THE CAR IS ONLY 7 YEARS OLD AND IS NOT DRIVEN FOR LONG DISTANCES. THANK YOU FOR YOUR CONSIDERATION. *TR

WHILE STOPPING AT A TRAFFIC LIGHT, I NOTICED ALL THE WARNING LIGHTS ON THE LOWER RIGHT SIDE OF THE INSTRUMENT PANEL CAME ON AND IMMEDIATELY WENT OFF, NO OTHER INDICATIONS. WHILE WAITING AT THE LIGHT, EVERYTHING APPEARED NORMAL. WHEN THE LIGHT CHANGED TO GREEN, I PUSHED ON THE GAS PEDAL TO PULL AWAY AND NOTHING HAPPENED. THE CAR WOULD NOT ACCELERATE AT ALL. NO LIGHTS WERE ON. I PUSHED TO GAS PEDAL TO THE FLOOR AND BACK UP AND THEN HALF WAY DOWN, ABSOLUTELY NOTHING WORKED. IT WOULD NOT GO ANY FASTER THAN IDLE. NO INCREASE IN RPM'S AT ALL, NO MATTER WHAT POSITION THE GAS PEDAL WAS IN. I'M IN THE FAST LANE AT RUSH HOUR AND COULD ONLY GO ABOUT 4 MILES PER HOUR. I MANAGED TO WORK MY WAY OVER THE SIDE OF THE ROAD AND PULL INTO A PARKING LOT. I STOPPED AND PUT THE CAR INTO PARK. I HEARD A "CLICK" AS IF A RELAY WAS RESET. I THEN PUT THE CAR INTO REVERSE AND IT SEEMED TO WORK. I PUT IT IN DRIVE AGAIN AND EVERYTHING APPEARED TO WORK OKAY AFTER THAT. I TOOK IT TO TURNER VOLVO, HERE IN SACRAMENTO, CA AND THEY SAID THEY COULDN'T DUPLICATE THE PROBLEM AND THERE WEREN'T ANY CODES IN THE COMPUTER SO THERE WAS NOTHING THEY COULD DO. THIS WAS AN "EXTREMELY" DANGEROUS SITUATION AND COULD HAVE CAUSED A VERY SERIOUS ACCIDENT, MADE WORSE BY THE FACT THAT MY 5 YEAR OLD NIECE WAS WITH ME AT THE TIME THIS HAPPENED. WE COULD HAVE BEEN KILLED AND TURNER VOLVO SAYS THERE'S NOTHING THEY CAN DO. WELL TURNER, THANKS FOR NOTHING AND FOR TAKING OUR LIVES SO LIGHTLY. MAYBE SOMEDAY A MEMBER OF YOUR FAMILY WILL BE INVOLVED IN AN ACCIDENT CAUSED BY THIS PROBLEM AND THEN WE'LL SEE WHAT YOU THINK. THIS IS AN ONGOING PROBLEM WITH VOLVO'S AND NEEDS TO BE TAKING CARE OF BY THE MANUFACTURER NOT THE PEOPLE WHO TRUSTED YOU ENOUGH TO BUY YOUR CARS. *TR

THE CAR WOULD SUDDENLY CEASE TO ACCELERATE NOT GOING OVER TWENTY MILES PER HOUR. THE CAR WAS TAKEN TO THE VOLVO DEALERSHIP WHERE THE EMT WAS CLEANED. UNDER AN EXTENDED WARRANTY. 10 DAYS LATER THE CAR WITHOUT WARNING WENT INTO THE 'LIMP HOME MODE AGAIN" THE CAR WAS RETURNED TO VOLVO THIS TIME I WAS TOLD THE ENGINE CONTROL MODULE WAS FAULTY AND NEEDED REPLACEMENT AND THE ETM WAS NOT THE PROBLEM THIS PART WAS OUT OF WARRANTY AND WOULD COST OVER $2,000 TO REPLACE OR I COULD TRADE IN THE CAR. I FEEL THAT THIS TOO SHOULD BE TAKEN CARE OF SINE THE ECM DIRECTS THE ACTIVITY OF THE ETM AND WAS NOT INITIALLY IDENTIFIED AS THE PROBLEM IF THIS DOES NOT CORRECT THE PROBLEM SOMEONE COULD BE SERIOUSLY INJURED WHEN TRYING TO MERGE ONTO THE FREEWAY OR CROSSING INTERSECTIONS. *TR

I BOUGHT MY 2001 VOLVO S60 N/A BRAND NEW AT THE END OF 2001. SINCE UP TO ABOUT SEPTEMBER OF 2007, I HAD NO PROBLEMS WITH THE VEHICLE EXCEPT ROUTINE SERVICE. THEN I NOTICED LOUD "CLANGING" AND "METALLIC THUMPING" WHENEVER I WENT OVER ROUGH ROADS AT ANY SPEED. TURNS OUT THAT MY CONTROL ARM BUSHINGS (BE THEY EVER POORLY MADE) CRACKED INTO PIECES. TOOK MY VEHICLE TO MY INDEPENDENT VOLVO SHOP TO REPAIR THE BUSHINGS. THE TECHNICIAN, AFTER THE REPAIRS WERE DONE, NOTIFIED ME THAT THERE WAS A FUEL LEAK COMING FROM THE REAR FUEL TANK AREA. FUNNY THAT IT WAS THAT EXACT WEEK THAT I STARTED TO NOTICE THE GASOLINE SMELL, BE SO EVER FAINT. AS OF TODAY, SEPTEMBER 22, 2008, THE SMELL HAS BECOME VERY STRONG WHERE AS EVEN WITH THE WINDOWS OPEN WHILE DRIVING, I LITERALLY HAVE TO STICK MY NOSE AGAINST THE OPEN WINDOW TO BREATHE IN WHAT SHOULD BE FRESH AIR. *TR

I HAD SLIGHT JERKING AND SLIPPING DURING RECENT TWO YEARS. BUT SINCE THIS MONTH (AUG. 2008), MY 2001 S60 T5 BECOMES WORSE WITH FREQUENT JERKING AND SLIPPING DURING TRAFFIC AND ACCELERATING FROM A STOP. DRIVING WITH THOSE SYMPTOMS IS VERY DANGEROUS. VISITED DEALER SHOP FOR SEVERAL TIMES, THE SUGGESTIONS WERE ALWAYS NEW TRANSMISSION REPLACEMENT WHICH COST OVER $4,000. I WAS ALSO TOLD MANY S60 2001 AND LATER HAVE THE SIMILAR PROBLEMS. I THINK THE VOLVO BUILDER MUST BE RESPONSIBLE FOR THIS SAFETY RELATED BAD PART MANUFACTURER ISSUE. *TR

MY DAUGHTER WAS IN A FRONTAL COLLISION WITH ANOTHER CAR (2001 VOLVO S60), THERE WERE NO OTHER PASSENGERS. MOST OF THE DAMAGE WAS TO THE FRONT LEFT OF HER CAR; HOWEVER, ONLY THE PASSENGER SIDE AIRBAG DEPLOYED. HER SPEED BEFORE BREAKING WAS ~50 MPH; THE CAR WAS TOTALED. ALTHOUGH MY DAUGHTER WAS NOT SERIOUSLY INJURED I CONSIDER THIS A SAFETY ISSUE SINCE THE VELOCITY WAS GREAT ENOUGH FOR THE PASSENGER SIDE AIRBAG DEPLOY. ADDITIONALLY, THE SIDE CURTAINS DID NOT DEPLOY. OF WHAT VALUE IS A MALFUNCTION SAFETY DEVICE? OTHER THAN A FAULT LIGHT (WHICH WAS NOT LIT) HOW CAN ONE BE CERTAIN AN AIRBAG IS FUNCTION PROPERLY? *TR

RECENTLY NOTICED CAR WAS DIFFICULT TO START AND CAR SMELLS LIKE GAS. THESE EVENTS SEEMED TO HAVE STARTED AT APPROXIMATELY THE SAME TIME AND THERE HAS BEEN NO PHYSICAL EVENT (CRASH, IMPACT) THAT INITIATED THE COMPLAINT. IT APPEARS TO HAVE STARTED IN MID SUMMER WHERE IT IS OPERATED IN SOUTH FLORIDA, AND I GET IN THE CAR AT 4PM TO 107 DEGREES ON THE TEMP READING. I HAVE DONE NOTHING, BUT HAVE CONCERN ABOUT SAFETY ISSUES AND POSSIBLE FIRE HAZARD. *TR

IN OCTOBER 2007, I INQUIRED OF FIELDS VOLVO OF WAUKESHA WISCONSIN, ABOUT A MALFUNCTIONING TEMPERATURE GAGE. THE GAGE WOULD OFTEN DISPLAY A FAULTY READING, SHOWING THAT THE CAR WAS OVERHEATING WHEN IN FACT IT WAS NOT. WHEN I BOUGHT MY CAR IN FOR AN INSPECTION OF THE MATTER, JASON FISCHER SERVICE ADVISOR, INFORMED ME THAT I NEEDED AN ELECTRONICS BO ( SEE ATTACHED RECEIPT). HE ASSURED ME THAT WAS THE PROBLEM, SO I AGREED TO ALLOW HIM TO REPLACE IT AND WAS CHARGED $537.15 FOR THE PROCEDURE. HOWEVER, A YEAR LATER IN JULY 2008, THE PROBLEM RESURFACED. EVENTUALLY, THE COOLING FAN MALFUNCTIONED AND WOULD NOT SHUT OFF. THIS PROBLEM ALSO CAUSED THE BATTERY TO DRAIN. I TOOK MY CAR TO AUTO WERKS IMPORT CENTRE IN MILWAUKEE, WISCONSIN, WHO THROUGH RESEARCH OF THE PROBLEM, FOUND THAT THERE WAS A RECALL ISSUED FOR THE COOLING FAN IN NOVEMBER 2004. I WAS ALSO CHARGED $200.53 FOR REPLACEMENT OF A TEMPERATURE SENSOR AND THE THERMOSTAT. (SEE ATTACHED RECEIPT) AS A SATISFIED VOLVO CUSTOMER FOR OVER 10 YEARS, I FEEL THAT HAD THOROUGH RESEARCH BEEN DONE PRIOR TO MALFUNCTIONING OF THE COOLING FAN, EXCESS CHARGES COULD HAVE BEEN AVOIDED. I AM THEREFORE SEEKING A PARTIAL REFUND OF MAINTENANCE CHARGES. YOUR IMMEDIATE RESPONSE TO MY REQUEST WOULD BE MOST APPRECIATED. *TR

FAULTY VOLVO S60 TRANSMISSION THE CAR HAS NO GAS/POWER THEN SUDDENLY JERKS INTO 1ST AND 2ND GEAR. THERE WAS TROUBLE EARLY ON WHILE IT WAS UNDER WARRANTY BUT THE DEALERSHIP DOWNPLAYED THE PROBLEM AND DIDN'T TELL ME IT HAD ANYTHING TO DO WITH THE TRANSMISSION. *TR