2000 VOLVO S70 Complaints

2000 VOLVO S-70 CAR STALLED WHILE TRAVELING AT ANY SPEED. I HAD TO SPEND $1200 TO HAVE THE ELECTRONIC MODULE THAT REGULATES THE AIRFLOW AND GAS TO THE ENGINE REPLACED. I DID SOME RESEARCH AND FOUND THIS TO BE A COMMON PROBLEM WITH THIS MODEL. VOLVO IS AWARE OF THE PROBLEM, BUT IS NOT RECALLING OR REIMBURSING CAR OWNERS. *NM

MY 2000 VOLVO S70 HAD A MALFUNCTION OF THE ELECTRONIC THROTTLE CONTROL MODULE AND I ALMOST GOT REAR ENDED ON THE HIGHWAY WHEN THE CAR HAVE AN ABRUPT LOSS OF SPEED. I TOOK THE CAR TO A VOLVO DEALER AND WAS CHARGED $1,500 TO REPLACE THE MODULE ABOUT 5 WEEKS AGO BUT IT LOOKS LIKE THE CAR IS STARTING TO MALFUNCTION AGAIN. *JB

2000 VOLVO S70 ELECTRONIC THROTTLE FAILURE.*MR THE CONSUMER STATED THE FAILURE OF THE ELECTRONIC THROTTLE LEAVES THE DRIVER WITH UNEXPECTED LOSS OF THROTTLE CONTROL. *JB

VEHICLE EXHIBITS "HESITATION AND STUTTERING" DURING BOTH ACCELERATION AND MAINTAINING STEADY SPEED. ETS WARNING LIGHT HAS APPEARED AND THEN RESET TWICE. TUNE-UP AND FUEL CHANGES WERE TESTED WITH NO CHANGE IN ISSUE. ETS WARNING LIGHT AND ON-BOARD DIAGNOSTICS INDICATED ELECTRONIC THROTTLE MODULE FAILURE AND REQUIRED REPLACEMENT. I HAVE THE OLD PART AND THE DIAGNOSTIC PRINTOUTS. AFTER RESEARCHING THIS ISSUE, IT APPEARS THAT THIS IS A COMMON AND PREMATURE FAILURE ITEM ON VOLVO CARS FROM 1999 THRU 2001 MODEL YEARS. SINCE THIS IS A CRITICAL SFAETY COMPONENT THAT CAN FAIL WITHOUT NOTICE (AT THE WORST POSSIBLE TIME), IT SHOULD BE AS RELIABLE AS OTHER CRITICAL COMPONEENTS SUCH AS THE ABS OR SRS/AIRBAG SYSTEMS. THIS DOES NOT APPEAR TO BE THE CASE.

MY 2000 VOLVO S70 IS EXPERIENCING ENGINE TROUBLE OVER THE LAST FEW MONTHS. I HAVE BEEN TOLD BY A REPAIR SHOP THAT IT IS THE ELECTRONIC THROTTLE MODULE CAUSING THE PROBLEM. AFTER NUMEROUS PHONE CALLS TO SEVERAL OTHER SHOPS AND DEALERS, AS WELL AS INVESTIGATIONS OVER THE INTERNET, IT APPEARS THAT THERE IS A DEFECT IN THE MODULE THAT WILL CAUSE THE CAR TO GO INTO A "CRIPPLE MODE" AT ANY GIVEN POINT. THIS HAS HAPPENED TO ME. VOLVO APPARENTLY DOES NOT BELIEVE THAT IT IS A PRODUCT DEFECT, BUT RATHER IT IS A MAINTENANCE ISSUE. I HAVE HAD THE MODULE CLEANED BUT IT HAS NOT HELPED THE PROBLEM. I DO NOT BELIEVE THAT A SITUATION SUCH AS THIS, WHICH WILL COST ABOUT $1,000 TO FIX, CAN BE CONSIDERED A MAINTENANCE ISSUE. THE CAR HAS LESS THAN 60,000 MILES.

ELECTRONIC THROTTLE FAILURE (ETS), CAR STOPPED RESPONDING TO THROTTLE INPUT WHILE DRIVING ON HIGHWAY, CAR NEEDS TO BE FIXED BUT I CAN'T AFFORD THE OUTRAGEOUS COST OF THE REPAIR $1100.

THE CONSUMER EXPERIENCED A PROBLEM WITH THE THROTTLE BODY AND MASS AIRFLOW ON HIS 2000 VOLVO S70. *JB THE POWER STEERING FAILED AND FLUID LEAKED ALL OVER THE DRIVEWAY. THE POWER STEERING PUMP AND RESERVOIR NEEDED TO BE REPLACED. WHY DRIVING, THE AIR DIRECTOR FELL OFF THE BUMPER. *JB *NM

WELL, I'VE ALSO JOINED THE ETS CLUB AT ABOUT 60,000 MILES ON MY S70, 2000, TO THE TUNE OF $860 BUCKS! IT HAPPENED AT THE MOST INOPPORTUNE TIME. WHILE CRUISING SOUTH ON I-95, JUNE 6TH, CAR STARTED TO RUN LIKE IT HAD WATER IN THE GAS. AFTER ABOUT AN HOUR OR SO OF THAT, THE ETS WARNING LIGHT COMES ON, SO I CHECK THE OWNER'S MANUAL, AND IT SAYS TO TURN OFF THE CAR, AND RESTART, AND IF THE LIGHT COMES BACK ON, (YOU'RE IN DEEP DOO-DOO) THEN HEAD FOR A VOLVO DEALER. WELL, IT DID COME BACK ON AND ABOUT AN HOUR LATER, THE CAR GOES INTO THE "LIMP-HOME" MODE OF ABOUT 40 MPH. FORTUNATELY WE WERE ABLE TO "LIMP" INTO WILMINGTON, NC, AND LUCKILY, PARKWAY VOLVO WAS ONLY ABOUT ONE-HALF MILE FROM THE COMFORT INN, WHERE WE CRASHED FOR THE EVENING. PARKWAY VOLVO WAS ABLE TO GET TO MY CAR THE VERY NEXT DAY, REPLACED THE ETS MODULE, AND TO DATE (23 JUN 05) THE CAR RUNS LIKE NEW. THE CUSTOMER SERVICE AND TECHNICAL SKILL OF THE SERVICE MANAGER (BRENT WELLS) ARE SUBERB!!! FORTUNATLEY, I ASKED FOR THE OLD ETS UNIT AND HAVE SINCE LEARNED THAT DON WILSON MIGHT TO HAVE IT. I'M SENDING HIM AN EMAIL ([email protected]) TO SEE IF HE STILL WANTS THEM FOR TESTING). I'M ALSO FILING A COMPLAINT AND WILL SUPPORT A "CLASS ACTION LAWSUIT" ANY WAY POSSIBLE. IT'S UNBELIEVABLE THAT VOLVO WON'T STEP UP TO THE PLATE AND TAKE RESPONSIBILITY FOR THIS "DEFECT"..... DEFECTIVE UNIT HAS THESE MARKINGS: MARELLI, 110541F2A, 00W080201; 9188793; 65CFM2; AH.0082030.K. NOTE: THE BOX THAT THE NEW ONE CAME IS IS MARKED: VOLVO 8644347 "MADE IN ITALY"

2000 S70 - MULTIPLE REPAIRS AND MULTIPLE RECURRING INCIDENTS OF THIS SAME PROBLEM! CHECK ENGINE LIGHT COMES ON, ENGINE RUNS ROUGH, TACH BOUNCES AND POWER DEMINISHES BECOMING A SEVER HAZARD IN HIGH SPEED TRAFFIC. DEALER FOUND THE PROBLEM TO BE "KNOWN ISSUES" WITH THE ELECTRONIC AIR MASS AND THROTTLE SYSTEMS. REPLACED TWICE WHILE UNDER WARRANTY, EXTENDED WARRANTY DENIED, SHORTLY OUT OF WARRANTY AND PROBLEM RETURNS AGAIN. DEALERSHIP NOR VOLVO WILL TAKE ANY CORRECTIVE ACTION ON >$1000 REPAIR (WHICH ACCORDING TO THE SERVICE TECH IS ALMOST GUARANTEED TO RETURN). THIS IS MY THIRD VOLVO, AND CERTAINLY MY LAST.

2000 VOLVO XL70 HEATER BLOWER FAN NOT WORKING AND STARTED SMOKING.*MR THE HEATER BLOWER MOTOR WAS REPLACED. *NM