2000 VOLVO S70 Complaints

I HAVE A 2000 VOLVO S70 WITH THE ELECTRONIC THROTTLE MODULE PROBLEM. MY CAR EXHIBITS THE CLASSICS SYMPTOMS ALREADY NOTED IN NHTSA'S FINDINGS. I JUST WANT TO ADD MY NAME TO THE LIST OF COMPLAINTS THAT VOLVO IS NOT DOING ENOUGH TO FIX THE PROBLEM. THE VOLVO DEALERSHIP I HAVE BEEN TAKING MY CAR TO (IN FIFE, WA) FOR CHRONIC ETS LIGHT COMING ON, CAR RUNNING ROUGH, STALLING, ETC. WILL NOT REPLACE THE ELECTRONIC THROTTLE MODULE EVEN THOUGH THE LIGHT KEEPS COMING ON, THE CAR KEEP STALLING AND RUNNING ROUGH, AND GOING INTO LIMP MODE WHILE DRIVING AT HIGH SPEEDS. I HAVE ASKED THEM IF IT NOT THE ETM THEN WHAT IS IT? AND THEY ONLY TOLD ME TO CHANGE THE AIR FLOW SENSOR WHICH I DID AND THE PROBLEM KEEPS COMING BACK OVER AND OVER. I AM BEYOND FRUSTRATED AND CONCERNED FOR MINE AND MY CHILDREN'S SAFETY BECAUSE THE CAR WILL LOSE THROTTLE POWER ON THE FREEWAY GOING 60 MPH. WHEN ARE THEY GOING TO JUST RECALL THE DARN THING. WHAT CAN I DO. I CALLED 1800-VOLVO CUSTOMER SERVICE AND THEY ROUTED ME RIGHT BACK TO THE SAME DEALERSHIP WHO WON'T FIX ANYTHING IN THE FIRST PLACE! ELIZABETH LARSON *TR

TL*THE CONTACT OWNS A 2000 VOLVO S70. WHILE DRIVING APPROXIMATELY 45 MPH, THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. APPROXIMATELY THREE MONTHS LATER, THE ELECTRONIC THROTTLE SYSTEM (ETS) LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY CLEANED THE ETS. WHEN THE CONTACT WENT TO RETRIEVE THE VEHICLE, THE ETS LIGHT ILLUMINATED AGAIN AND THE VEHICLE WAS LEFT AT THE DEALER. THE CURRENT MILEAGE WAS 78,728 AND FAILURE MILEAGE WAS 78,528.

TL*THE CONTACT OWNS A 2000 VOLVO S70. WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED TO 15 MPH (AT THE LOWEST). THE CONTACT FREQUENTLY NOTICED THE FAILURE AND ALSO OBSERVED THAT THE TACHOMETER WOULD FLUCTUATE UP AND DOWN. SHE TOOK THE VEHICLE TO A MECHANIC, WHO RETRIEVED AN ERROR CODE AND REFERRED HER TO THE DEALER. THE DEALER RETRIEVED THE FAILURE CODE FOR THE THROTTLE POSITIONING SENSOR. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN ID NUMBER 06V441000 (VEHICLE SPEED CONTROL). SHE CONSULTED SIX DIFFERENT DEALERS AND THEY ALL STATED THAT THE PARTS NEEDED FOR THE REPAIR WERE ON BACKORDER FOR APPROXIMATELY SIX WEEKS. THE CLOSEST DEALER INFORMED HER THAT THEY HAVE YET TO RECEIVE PARTS, EVEN AFTER THE SIX WEEK DEADLINE. THE MANUFACTURER COULD NOT PROVIDE ANY ADDITIONAL INFORMATION. THE CURRENT MILEAGE WAS APPROXIMATELY 90,000 AND FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 10/03/08 *BF THE CONSUMER STATED THE VEHICLE HESITATED DURING ACCELERATION AND DECLERATION AT HIGHWAY SPEEDS. UPATED 10/07/08. *JB

**APPROX. INCIDENT DATE IS ACTUALLY ONGOING FOR PAST FOUR YEARS.*** I HAVE A 2000 VOLVO S70 WHICH I PURCHASED NEW IN MAY 2000 FROM VOLVO ATHENS, GA. DEALER. I CURRENTLY HAVE 190,000+ MILES. OVER THE PAST EIGHT YEARS I HAVE OWNED THE VEHICLE I HAVE HAD CONSISTENT PROBLEMS WITH THE ETM SITUATION. AT FIRST, BEING NEW TO VOLVO CARS AND REPAIR SITUATIONS, VOLVO DENIED THE ETM PROBLEM AND STUCK IT ON ME TO BE REPAIRED IN NOV. 2004. NOT UNTIL I DESCRIBED MY ISSUES WITH ENGINE FAILURE TO AN INDEPENDENT MECHANIC, WAS I WARNED ABOUT THE ONGOING PROBLEMS IN MY MODEL VEHICLE. SINCE MY INITIAL REPAIR I HAVE ENCOUNTERED FOUR OTHER TIME PERIODS WHEN THE SAME ETM SITUATION BEGINS OCCURRING, TYPICALLY 20-30,000 MILE INTERVALS SINCE THE LASTS SERVICE OF THE SPECIFIC ETM DEFECT. NOW, I AM ON MY FOURTH TRIP IN FOUR YEARS TO THE LOCAL DEALER TO ONCE AGAIN HAVE THE ETM SITUATION REPAIRED. I AM AT 190,000 MILES AND ACCORDING TO THE MANUFACTURER "EXTENDED WARRANTY" ON THIS PROBLEM, MY ABILITY TO HAVE THIS ONGOING SAFETY ISSUE FIXED AT MANUFACTURER COSTS WILL CEASE IN APPROXIMATELY 10,000 MILES. CLEARLY THIS SAFETY DEFECT HAS BEEN AN ISSUE WITH MY MODEL CAR SINCE ITS MANUFACTURE BY VOLVO AND TO DATE NO EFFECTIVE REMEDY HAS BEEN FOUND. I FEEL THIS ISSUE IS A MAJOR SAFETY DEFECT AS MY CAR WILL STALL OR HESITATE THEN SURGE AT ANY GIVEN MOMENT THUS CAUSING A POTENTIAL TRAFFIC ACCIDENT INVOLVING NOT ONLY MYSELF, BUT MY PASSENGERS, AND POTENTIALLY OTHER DRIVERS ON THE ROAD. I AM SICK AND TIRED OF VOLVO NOT TAKING MORE RESPONSIBILITY FOR THIS ISSUE AND FINDING A SOLUTION TO THE PROBLEM, NOT JUST A STOP GAP MEASURE TO APPEASE NHTSA. I HAVE NEVER BEEN CONTACTED BY NHTSA REGARDING THIS ISSUE DESPITE MY ONGOING COMPLAINTS TO MY LOCAL VOLVO DEALER AS WELL AS THE MANUFACTURER SERVICE CENTER. IT APPEARS FROM DOCUMENTATION ON THIS WEBSITE THAT NHTSA HAS GATHERED, OR ATTEMPTED TO GATHER, COMPLAINTS ON VOLVO ETM MATTER AND I WANT TO BE INCLUDED IN SUCH COMPLAINTS. *TR

APPROXIMATELY 26 MONTHS AGO, I WAS EXPERIENCING CONSIDERABLE DIFFICULTY WITH THE STARTING OF MY PASSENGER VEHICLE WITH AN INCREASE FREQUENCY OF THE PROBLEM RE-OCCURRING. SPECIFICALLY, THE ENGINE WOULD TURN BUT WOULD NOT START. IN ORDER TO START THE VEHICLE, I WOULD HAVE TO TURN THE KEY BACK AND FORTH SEVERAL TIMES (3 - 5) UNTIL THE COMPUTER CHIP IN THE KEY SIGNALED THE COMPUTER CHIP IN THE STEERING COLUMN AND THE VEHICLE STARTED. UPON CONTACTING A NEARBY DEALERSHIP (DWYER & SONS, MICHIGAN) AND TROUBLESHOOTING THE PROBLEM, I WAS INFORMED THAT THE ANTENNA RING WITHIN THE STEERING COLUMN WAS BROKEN AND REQUIRED REPLACEMENT AS WELL AS THE IMMOBILIZER AND THE RE-ORDERING OF TWO IGNITION KEYS AND ONE TRUNK KEY. THESE REPAIRS WERE COMPLETED MAY 2006 WITH ONLY A LIMITED PARTS WARRANTY AVAILABLE. APPROXIMATELY FOUR MONTHS AGO, THE PROBLEM BEGAN OCCURRING AGAIN. UPON CONTACTING MICHAEL MULLETT WITH DWYER & SONS, I INFORMED HIM OF THE SAME PROBLEM AND HE RESPONDED THAT THE PARTS WARRANTY WAS ONLY VALID FOR TWELVE MONTHS. DURING A RETURN TRIP TO MICHIGAN, I FOLLOWED UP WITH MR. MULLETT AND SCHEDULED AN APPOINTMENT TO ADDRESS THE PROBLEM. AGAIN, MR. MULLETT DIAGNOSED THE PROBLEM AS THE ANTENNA RING AND IMMOBLIZER AS WELL AS TWO IGNITION KEYS AND A TRUNK KEY WHICH REQUIRED REPLACEMENT AT AN APPROXIMATE COST OF $700.00 (PARTS & LABOR). MR. MULLETT INDICATED THAT THEY (AS A DEALERSHIP) HAVE TO ADDRESS THIS PROBLEM WITH MULTIPLE CUSTOMERS OVER THE YEARS, HOWEVER, VOLVO HAS FAILED TO RECOGNIZE THAT THIS PROBLEM MAY BE MORE WIDESPREAD AMONG ALL THEIR CUSTOMERS. HELP !! TWO IDENTICAL REPAIRS WITHIN 23 MONTHS. I WOULD APPRECIATE YOUR ASSISTANCE IN ADDRESSING THIS PROBLEM IN HOPES OF HAVING IT PROPERLY ADDRESSED AT THE MANUFACTURERS EXPENSE AS WELL AS REIMBURSEMENT OF THE INITIAL REPAIR IN MAY 2006. THANK YOU. *TR

MY FIANCE WENT OUT TO THE VEHICLE WHICH WAS PARKED TO RETRIEVE AN ITEM SHE LEFT IN IT. UPON HER SITTING DOWN IN THE DRIVER SEAT, MIND YOU THE ENGINE WAS NOT ON NOR WAS THE KEY IN THE IGNITION, THE SIDE AIRBAG DEPLOYED STRIKING THE LEFT SIDE OF HER FACE. THE FORCE STUNNED HER FOR A FEW SECONDS, LEAVING HER CONFUSED ON WHAT HAD HAPPENED. HER HEARING WAS ALSO AFFECTED. SHE WENT TO THE EMERGENCY ROOM TO GET CHECKED OUT WHERE IT WAS CONCLUDED THAT SHE SUFFERED A SCRATCHED CORNEA DUE TO THE POWDER RELEASED FROM THE AIRBAG, AS WELL AS HER AQUEOUS RADIUS HUMOR OF HER EYE WAS KNOCKED OUT OF BALANCE FROM THE FORCE OF THE DEPLOYMENT. *TR

ELECTRICAL FAILURES CAUSING DASH TO GO BLANK, WHICH IS NOT SAFE. ALSO, CAUTION LIGHTS AND OTHER ENGINE REPAIR LIGHTS COME ON RANDOMLY. IF YOU GO TO THE INTERNET YOU WILL FIND A PERSISTENT PROBLEM WITH THE VOLVO. I HAVE A FRIEND THAT WAS AN EX ENGINEER FOR GM AND HAS SEVERAL FORD ENGINEER FRIENDS IN DETROIT. HE STATED THEY WERE VERY AWARE OF THE ELECTRICAL PROBLEMS WITH THE VOLVO, MOST OF WHICH BEGAN WITH FORDS PURCHASE OF THE COMPANY. SINCE THEN THE OCCURRENCE OF PROBLEMS HAS STEADILY ROSE THE COST OF REPLACING THE DASH ELECTRONICS AND WIRE HARNESSES ARE COST PROHIBITIVE AND MAY NOT FIX THE PROBLEM. HERE IS JUST ONE OF MANY SOURCES OF COMMENTS FROM OWNERS OF JUST ONE MODEL OF VOLVO. THERE ARE PROBLEMS THROUGHOUT THE LINE AND THE COMPANY IS NOT IN THE FINANCIAL CONDITION TO MAKE A RECALL. SEE THIS LINK: HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0FCAF2/5 I TRIED TO CALL VOLVO OVER A MINOR COST ITEM WHICH IS A POORLY ENGINEERED CUP HOLDER. THEIR RESPONSE WAS THAT SWEDISH PEOPLE DO NOT BRING DRINKS INTO THEIR CARS AND THE CUP HOLDER IS AN AMERICAN ADD-ON. IF THEY TRY THIS COP OUT FOR A $50 CUP HOLDER WHAT WOULD THEY SAY ABOUT A $1000 PLUS ELECTRICAL REPAIR? *TR

ABS CONTROL MODULE ON MANY MODELS OF VOLVO ARE DEFECTIVE AND FAIL AROUND OR AFTER ABOUT 85000 MILES. ALTHOUGH MOSTLY ANNOYING COULD PREVENT PROPER OPERATION OF ABS DURING BRAKING AND POOR BRAKING AS A RESULT WHEN NOT EXPECTED. DEFECTS OF INTERNAL SOLDER CONNECTIONS OF CONNECTOR TO PCB ON THE CONTROL MODULE PRINTED CIRCUIT BOARD IS MAJOR CONTRIBUTOR. THE PROBLEM IS SO WIDE SPREAD THAT MANY INTERNET SITES ARE DEVOTED TO THE REPAIR OF THIS MODULE SINCE IS SO COMMON. SINCE IT IS SO COMMON AND A FAILURE IS VERY LIKELY AND AS A RESULT A REDUCTION OF BRAKING EFFICIENCY THAT IS EXPECTED I WOULD CONSIDER THIS A MAJOR ISSUE AND A RECALL SHOULD BE FOR THIS PROBLEM. *TR

AIRBAG HAS FAILED TWICE. REPLACED UNDER WARRANTY AND FAILED AGAIN. VOLVO CLAIMS NO WARRANTY ON THE REPLACED AIRBAG. *TR

2000 VOLVO S70 WOULD LIKE REIMBURSEMENT FOR BAD REPAIRS. HE HAD REPAIRS AND A RECALL REPAIR DONE THAT WERE NOT DONE PROPERLY AND WOULD LIKE TO BE REIMBURSED FOR THE BAD REPAIRS. *KB