2000 VOLVO S70 Complaints

2000 VOLVO S70 NEEDED A THROTTLE BODY MODULE INSTALLED. I UNDERSTAND THIS VEHICLE HAS HAD A NUMBER OF COMPLAINTS ABOUT TIS MODULE. I ALSO UNDERSTAND THAT CALIFORNIA IS ASKING VOLVO TO EITHER HAVE A RECALL OR EXTEND THE WARRANTY. *NM

I OWN A 2000 VOLVO S70 AND THE THROTTLE MODULATOR (?) FAILED AND HAD TO BE REPLACED AT JUST OVER THE 100K MILE MARK. THE CAR IS SERVICED REGULARLY AND NOT MISHANDLED. I FELT VOLVO SHOULD HAVE REPLACED THIS PART WITHOUT COST TO ME. HOWEVER, THEY DID NOT AND IT COST ME ALMOST $1,000 FOR THE REPAIRS. I HAVE A FRIEND WHO HAD THE SAME PROBLEM WITH HER VOLVO AND SHE GAVE ME THIS WEB SITE. HENCE MY COMPLAINT. *NM

DT: THE CONTACT STATED ENGINE SPUTTERED AND CHOKED, THEN IT EVENTUALLY STALLED. THE ELECTRICAL THROTTLE SYSTEM ( ETS ) LIGHT ILLUMINATED. SHE TOOK THE VEHICLE TO DEALER FOR SERVICE. THE ETS AND EXHAUST/CRANKCASE EMISSION CONTROL MODULE (ECM) WERE REPLACED. THE VEHICLE WAS OPERATING CORRECTLY. THE VEHICLE HAS BEEN TO THE DEALERSHIP FIVE TIMES SINCE SEPTEMBER 2005. *AK

DT: CONTACT'S WIFE WAS DRIVING ON THE INTERSTATE AND VEHICLE SPEED SLOWED DOWN TO ALMOST NO SPEED AT ALL. SHE WAS ABLE TO GET THE VEHICLE OFF THE RAMP. THE VEHICLE WAS TAKEN TO VOLVO DEALERSHIP IN JUNE OF 2005 TO BE CHECKED. HE WAS TOLD AT THAT TIME THE THROTTLE BODY NEEDED TO BE CLEANED. THE VEHICLE RAN FINE UNTIL SEPTEMBER, 22,005. THIS TIME THE VEHICLE WAS TAKEN TO A VOLVO MECHANIC, THE THROTTLE BODY WAS REPLACED AT THIS TIME. THE VEHICLE WAS UNDER WARRANTY AT THAT TIME .THEN ON NOVEMBER 12, 2005 HE WAS PULLING OUT OF A PARKING PLACE AND THE THROTTLE BODY WENT OUT AGAIN. THIS, IN TURN, ALMOST CAUSED A SERIOUS ACCIDENT. ON NOVEMBER 14, 2005 HE TOOK THE CAR BACK TO THE MECHANIC AND HE WAS TOLD THAT THE THROTTLE BODY THAT WAS REPLACED IN SEPTEMBER 2005 WAS DEFECTIVE FROM VOLVO. THE VEHICLE IS NOW AT A REPAIR SHOP HAVING THE THROTTLE BODY REPLACED AGAIN. THE VEHICLE IS NO LONGER UNDER WARRANTY.*AK UPDATED 12/16/2005. *NM

ADD TO NHTSA ACTION NUMBER : PE05041 I WOULD LIKE TO ADD MY COMPLAIN TO ABOVE CASE. FIRST TIME MY CAR JUST STALLED ON A HIGHWAY. LUCKLY FOR ME, I MANAGED TO AVOID AN ACCIDENT. IT HAPPENED BACK IN FEBRUARY OR MARCH OF 2003, WHEN MY CAR HAD APPROXIMATELY 65,000 MILES. LAST WEEK "CHECK ENGINE" LIGHT CAME OFF AND I TOOK MY CAR FOR A CHECK-UP. DEALER TOLD ME THAT ETM IS FAILING. MY CAR NOW HAS 104,000 MILES, THUS LESS THAN 40,000 SINCE LAST FAILURE. DEALER REFUSED TO FIX THIS AND QUOTED ME REPLACEMENT COST OF APPROXIMATELY $1,100. NOW I HAVE TO DRIVE EVERYDAY AND WAIT IN FEAR WHEN ETM WILL FAIL AGAIN.

VOLVO 2000 S70 66,000 MILES VEHICLE SPEED CONTROL AFTER A TRIP OF 300+ MILES ETS LIGHT AND CHECK ENGINE LIGHT CAME ON AND VEHICLE WENT INTO "LIMP-HOME" MODE [20 MPH] VEHICLE WAS TOWED 100 MILES TO NEAREST DEALER ETM [ELECTRONIC THROTTLE MODULE] TESTED FAILED AND WAS REPLACED BY DEALER ON 10/30/2005 OLD PART NOT AVAILABLE. *JB

THE ETS WARNING LIGHT WENT ON TWO DIFFERENT DAYS LEADING TO MY CALLING MY VOLVO DEALER. I WAS TOLD I MUST REPLACE MY ELECTRONIC THROTTLE MODULE BECAUSE NOT REPLACING IT COULD LEAD TO FAILURE OF THE THROTTLE AND COULD LEAD TO AN ACCIDENT. I HAD TO PAY $971 ON OCTOBER 22 TO HAVE MY DEALER REPLACE THE MODULE AS THE CAR WAS JUST PAST ITS WARRANTY. *JB

DT: THE CONTACT OWNS A 2000 VOLVO S70. WHILE DRIVING AT SPEED OF 25-40 MPH VEHICLE WOULD CUT OUT WHILE IDLING OR SLOWING DOWN. THEN IT WOULD LURCH FORWARD. THE CONTACT WOULD PUT VEHICLE IN NEUTRAL TO TRY AND KEEP THIS FROM HAPPENING. THE VEHICLE IS CURRENTLY DEALER FOR REPAIRS. THIS HAS BEEN GOING ON SINCE AUGUST 2005 AND HAS BEEN GETTING PROGRESSIVELY WORSE. THE PROBLEM WAS DIAGNOSED AS FLUCTUATING IDLE DUE TO ELECTRONIC THROTTLE MODULE FAILURE. *AK *JB

MY CAR WAS JERKING AND STALLING WITHOUT ANY NOTICE. MY WIFE USE TO TELL ME ALL THE TIME THAT IT WAS DOING THAT. THIS WENT ON FOR A FEW MONTHS OR MAYBE EVEN LONGER. I DECIDED TO DRIVE THE CAR AND IT NEVER HAPPENED WITH ME UNTIL I WAS DRIVING ON VACATION TO N.C. AND IT JUST CUT OFF WHILE I WAS WITH MY FAMILY. I HAD TO PUSH THE CAR OF THE ROAD. I CONTINUED TO ATTEMPT TO RESTART THE VEHICLE. IT RESTARTED, AND I WENT TO THE NEAREST VOLVO DEALER AND HAD TO HAVE THE ELECTRONIC THROTTLE MODULE (ETM) REPLACED. $1014 WORTH OF REPAIRS, FROM ONE OF THE BEST CARS KNOWN FOR SAFETY AND RELIABILITY IN THE WORLD AND I FELT HELPLESS. I KNOW THAT THIS IS A DEFECT AND RECALL ISSUE AND WOULD LIKE TO BE REIMBURSED OR GIVEN CREDIT AT A VOLVO DEALERSHIP TO MAKE UP FOR MY LOSS AND JUST MAKE THIS MATTER RIGHT. I STILL HAVE THE INVOICE SERVICE RECEIPT WITH ALL THE INFORMATION ON IT. THE VOLVO DEALERSHIP WHERE THE REPAIRS WERE MADE WAS CROWN VOLVO IN GREENSBORO N.C. THANK YOU FOR ALLOWING ME TO MAKE A COMPLAINT. HOPEFULLY ENOUGH PEOPLE WITH THE SAME PROBLEM CAN MAKE SOME KEY PERSONNEL THINK ABOUT THE SAFETY ISSUES AND RELIABILITY CONCERNS OF THESE VEHICLES. *NM

DT:THE CONTACT STATED WHILE DRIVING IN TRAFFIC VEHICLE LOST POWER. THE VEHICLE SURGED AND LOST MOST OF THE POWER FOR ABOUT FOUR MILES. THE VEHICLE WAS THEN TURNED OFF. A FEW MINUTES LATER, THE VEHICLE RESTARTED. SHE TOOK THE VEHICLE TO THE DEALERSHIP. THE THROTTLE BODY AND A CP VALVE WERE REPLACED AT CONTACT'S EXPENSE. THIS HAPPENED A FEW MONTHS BEFORE, AND THE DEALER MADE MINOR ADJUSTMENTS, BUT DID NOT FIX THE VEHICLE. THE CONTACT WAS THE ORIGINAL OWNER OF THE VEHICLE. *AK