1999 VOLVO S80 Complaints

DT: THE CONTACT STATES WHILE DRIVING ON THE INTERSTATE THE VEHICLE ACCELERATED AND EXPERIENCED A LOSS OF POWER. THE ENGINE DID NOT STALL, BUT OPERATED AT A REDUCED SPEED. THE ENGINE SLOWLY RESUMED POWER AND THE CONTACT WAS ABLE TO PROCEED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE PROBLEM WAS WITH THE ELECTRONIC THROTTLE CONTROL MODULE. VOLVO OFFERED NO COST ASSISTANCE. THE CONSUMER HAD THE ETM REPLACED. *AK UPDATED 12/27/2005. *NM

DT: WHEN THE SURGING HAPPENS THERE ARE NO NECESSARILY WARNING MESSAGES. THE FIRST TIME THE THROTTLE MODULE WAS REPLACED THERE WERE SOME MESSAGES ON THE DASH, BUT FOR ITEMS NOT RELATED TO THE THROTTLE MODULE. THE SECOND TIME THERE WERE NOT ANY MESSAGES UNTIL THE CAR DIED AND WOULD NOT START. THE THIRD TIME THE CAR STARTED TO SURGE , AND BROUGHT THE CAR TO DEALER BEFORE IT GOT TOO BAD. BASICALLY, IT WOULD BE NECESSARY TO REPLACE THROTTLE MODULE A FOURTH TIME. THE CONTACT ONLY HAD TO PAY FOR 1 REPLACEMENT, AND THEN IT WAS REPLACED 2 MORE TIMES BY THE DEALER AT NO COST. FROM THE TIME THE SURGING STARTED TO THE CAR STALLED. THE CLEANING OF THE THROTTLE MODULE WILL KEEP THE CAR RUNNING GOOD. IT SEEMED THAT THE CONTACT HAS TO CLEAN IT EVERY 6 MONTHS. IT STARTED TO SURGE. ABOUT 8000 - 10000 MILES. THE LAST TIME IT WAS REPLACED WAS 5/14/04 ,AND I THE CONTACT CLEANED IT TWICE SINCE THEN. VOLVO TOLD THE CONTACT THAT THEY WOULD NOT WARRANTY IT ANY MORE BECAUSE THE CONTACT DECLINED TO HAVE THEM DO $1000 WORTH OF WORK THAT DID NOT NEED TO BE DONE. THE CONTACT ENDED UP DOING THE WORK HIMSELF, AND THERE WAS NOTHING WRONG WITH THE PARTS THEY SAID WERE BAD. *AK

DT:THE CONTACT STATED THIS VEHICLE WAS EXPERIENCING THE SAME PROBLEMS MENTIONED IN NHTSA INVESTIGATION PE05-041. THIS HAS HAPPENED MANY TIMES. THE LAST TIME THIS HAPPENED THE VEHICLE WAS TRAVELING ABOUT 40 MPH ,AND IT LOST POWER/STALLED. THE VEHICLE WAS PULLED OVER WITHOUT INCIDENT. THE VEHICLE WAS RESTARTED IMMEDIATELY, AND WOULD NOT GO FASTER THAN 20 MPH. THE VEHICLE WAS TAKEN TO A SERVICE STATION. THEY WERE UNABLE TO ASSIST THE CONTACT. THE VEHICLE WAS TAKEN THE DEALER. THE PROBLEM WAS DIAGNOSED AS THE ETM BY THEIR COMPUTER ERROR NOTICE. HE WAS NOT THE ORIGINAL OWNER. THE PROBLEM HAS NOT BEEN FIXED. THE MANUFACTURER HAS BEEN CONTACT, AND THEY OFFERED NO ASSISTANCE. *AK

ENGINE MISS FIRING AND EMISSION LIGHT ON. LATER ENGINE RUNNING GOOD BUT CRUISE CONTROL WOULD NOT WORK AND TEXT MESSAGE 'ENGINE SYSTEM FIX NEXT SERVICE' WITH ORANGE WARNING LIGHT ON. TOOK TO VOLVO DEALER AND THEY REPLACED THE ETM FOR NO CHARGE. THEY KEPT THE OLD PART BECAUSE THEY HAD REPLACED THE ORIGINAL ONE. *NM

THE THROTTLE SURGES AT IDLE AND WHILE DRIVING. SOMETIMES NO POWER AND SOMETIMES IT JUST TAKES OFF. DEALER SAYS ITS THE ELECTRONIC THROTTLE BODY. STATED THEY HAVE REPLACED A NUMBER OF THESE. *NM

CAR HAS ON NUMEROUS OCCASION LOST COMPLETE POWER AND WILL BASICALLY JUST IDLE. THIS HAS HAPPENED BOTH WILL STARTING FROM A DEAD STOP AS WELL AS AT HIGHWAY SPEEDS. THIS ON SEVERAL OCCASIONS HAS ALMOST RESULTED IN ACCIDENTS DUE TO HIGH TRAFFIC VOLUME AT THE TIME OF FAILURE. CAR IS CURRENTLY AT SHOP FOR REPAIR WITH ESTIMATE OVER $1000. *JB

FUEL ODOR IN VEHICLE, AND FUEL LEAKING UNDER VEHICLE. FUEL PUMP ASSEMBLY HAS STRESS CRACKED AT FUEL PRESSURE LINE. FUEL PUMP ASSEMBLY REQUIRED TO REPAIR LEAK. REPLACED FUEL PUMP. *JB

HAD TAKEN MY S80 TO THE VOLVO DEALERSHIP A NUMBER OF TIMES COMPLAINING OF ENGINE HESITATION AND STALLING. VOLVO"S DIAGNOSTIC COMPUTER SYSTEM "VADIS" OUTPUT CODES CLEARLY SHOWED DEFAULT CODES INDICATING A FAULTY MODULE. THE SERVICE MANAGER AT THIS STEADFASTLY REFUSED TO REPLACE THE MODULE "DUE TO COST". I WARNED HIM OF THE POTENTIAL CONSEQUENCES OF TRYING TO OPERATE THIS VEHICLE WITH UNRELIABLE ENGINE FIRING AND THE ASSOCIATED "STALLING" THAT OCCURS WITHOUT WARNING. I EXPRESSED MY CONCERNS TO HIM ABOUT THE DANGER THAT THIS PROBLEM PRESENTED FOR ME AND OTHER VEHICLES WHICH I HAD EXPERIENCED DURING PREVIOUS "STALLINGS". UNFORTUNATELY, AFTER TREMENDOUS RESEARCH AND A NUMBER OF PHONE CALLS BEFORE I COULD BRING THIS INFO TO BEAR TO FORCE THE DEALERSHIP TO HONOR THEIR WARRANTY I EXPERIENCED A "STALLING" EVENT WHILE DRIVING ON THE EXPRESSWAY WHICH LEAD TO A SINGLE CAR ACCIDENT,RESULTING IN A TOTAL LOSS OF MY CAR. *NM

DT:THE CONTACT OWNS A VOLVO S80 VEHICLE. IT INTERMITTENTLY STALLED/ DIED, AND LOST POWER. THE ELECTRONIC THROTTLE MODULE FAILED AND WAS CLEANED THREE TIMES. *AK THE LINE SEAL AND GASKET WERE REPLACED DUE TO AN OIL LEAK. THE TOP ENGINE TORQUE ARM WAS CRACKED. *JB

VEHICLE SURGES IN RPM WHILE DRIVING,VEHICLE STARTED BY NO ACCELERATION WARNING LIGHT ON ENGINE MALFUNCTION. SHUT OFF WHILE DRIVING. *NM