2004 VOLVO V70 Complaints

2000 V70XCAW CROSS COUNTRY WAGON ETM SYSTEM FAILED. *TS THE AC HOSE COMPRESSOR CONDENSER WAS REPLACED. THE VEHICLE WAS LEAKING GAS AND THE O-RING SEAL ON THE PUMP SENDER WAS REPLACED. THE FRONT PASSENGER WINDOW WAS INOPERABLE WHEN TRYING TO USE THE MASTER CONTROLS. THE DEALER REPLACED THE MODULE SWITCH. THE ENGINE WOULD WHINE AT HIGHWAY SPEEDS WHILE ACCELERATING. THE BATTERY, OIL PAN, UPPER TORQUE MOUNT, ANGLE GEAR, ROTORS, FUEL PUMP, FUEL TANK, FUEL SEAL AND STRUTS WERE ALL REPLACED. THE CV BOOT WAS LEAKING. THE TURBO CHARGER WAS REPLACED BECAUSE OF AN OIL LEAK. *JB

VOLVO V70 2004 WAGON - DRIVING ON CITY STREETS. CAR STALLED 3X AND LOST STEERING CONTROL 2 X. HAD IT TOWED TO DEALER (POWER VOLVO, TORRANCE CA) BUT THEY COULD NOT DUPLICATE PROBLEMS (ALL 3 INCIDENTS HAPPENED WITHIN 10 MINS OF EACH OTHER WHEN I WAS DRIVING). TOLD ME THE NEXT DAY THE THROTTLE WAS "STICKING" AND THEY WOULD "CLEAN" IT. THIS MAKES ME NERVOUS DUE TO THE PAST THROTTLE PROBLEMS WITH VOLVOS, AND ALSO BECAUSE I HAVE A 4 YEAR OLD CHILD, AND AM 9 MO. PREGNANT. THOUGHT YOU GUYS SHOULD KNOW! *JB

2004 VOLVO V70 ACCELERATED AT HIGH SPEED WHEN PLACED ON DRIVE AND CONSUMER COULD NOT STOP THE VEHICLE USING THE BRAKE. CONSUMER AIR BAGS DID NOT DEPLOY. *TS THE VEHICLE TRAVELED OVER A CEMENT BARRIER BLOWING OUT THE TWO REAR TIRES. THE CONSUMER HAD TO TURN OFF THE VEHICLE'S IGNITION TO STOP THE VEHICLE. THE MANUFACTURER SENT SOMEONE TO INSPECT THE VEHICLE BUT THEY WERE UNABLE TO FIND ANYTHING WRONG. *NM

IN THE SUMMER OF 2004 I THOUGHT I FELT MY BRAKES FREEZE UP, BUT JUST THOUGHT IT WAS ME, THINKING "I'M IN A YEAR OLD VOLVO, THERE'S NO WAY THAT COULD HAVE HAPPENED." A FEW MONTHS LATER IT DID HAPPEN AND I TOOK IT TO THE DEALERSHIP WHERE THEY REPLACED THE MASTER CYLINDER. THAT WAS 11/19/04. ON 2/28/05 I RETURNED THE VEHICLE TO THE DEALERSHIP AGAIN FOR THE SAME PROBLEM. THIS TIME THEY REPLACED THE MASTER CYLINDER AND BOOSTER. THEN, THE END OF APRIL I WAS GETTING ON THE HIGHWAY GOING ABOUT 50 MPH, AND HAD TO APPLY MY BRAKES, AND THEY FROZE UP AND I GLIDED FOR A FEW SECONDS BEFORE THEY RELEASED AND I WAS ABLE TO PUSH DOWN ON THEM (THIS IS WHAT HAPPENED THE OTHER TIMES.). VOLVO AGAIN REPLACED THE MATER CYLINDER AND BOOSTER (AND THEY TOLD ME THEY REPLACED ANOTHER PART THAT HAD TO DO WITH THE PUMPING MECHANISM (?) "JUST IN CASE." THE CAR MADE IT 4 1/2 MONTHS BEFORE IT HAPPENED AGAIN. I WAS GETTING ONTO A HIGHWAY 9/9/05, GOING ABOUT 60-70 MPH, WHEN THE CAR IN FRONT OF ME APPLIED HIS BRAKES. I APPLIED MINE, AND FOR A SPLIT SECOND THEY FROZE. I ACCELERATED AGAIN ALMOST IMMEDIATELY AND THEN HAD TO SLOW AGAIN. THIS TIME THE BRAKES FROZE FOR ABOUT 3-4 SECONDS BEFORE THEY RELEASED AND I WAS ABLE TO SLOW DOWN. IT IS IN THE SHOP NOW AND VOLVO ASSURES ME THAT THIS HASN'T HAPPENED IN A NEW CAR BEFORE. MY QUESTION IS: CAN THEY RECALL SOMETHING THEY CAN'T EVEN FIX??? *NM

CAR WAS DAMAGED GOING OVER A SPEED BUMP (ON PUBLIC RD) AT ABOUT 5 MPH. THERE IS A RECALL IN EUROPE TO FIX THIS PROBLEM (BY REMOVING A BRACKET THAT PRODUCED BELOW THE CARD AND CAN BE FORCED UPWARDS DAMAGING THE EXHAUST AND DRIVESHAFT. THE RECALL HAS NOT BEEN MADE IN USA PLEASE SEE THIS WEBLINK (THAT HAS A COPY OF THE EUROPEAN RECALL NOTICE) HTTP://WWW.SWEDEDEMON.COM/PHPBB2/VIEWTOPIC.PHP?T=385&HIGHLIGHT=P+N+30647428 I HAVE COPIED SOME TEXT FROM THE RECALL BELOW (IT HAS PICTURES ON THE SITE WHICH EXPLAINS THE SITUATION WELL) ISSUED FOR R VEHICLES BUT GOES FOR ALL P2X AWD MODELS. DATED JANUARY 2004. DESCRIPTION, THERE HAVE BEEN REPORTS ABOUT THE FACT THAT S60R AND V70R VEHICLES CAN BE DAMAGED AT THE UNDER SIDE OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS IS CAUSED BY A BRACKET (P/N 30647428) (SEE ATTACHMENT) WHICH IS MOUNTED UNDER THE VEHICLE. THE BRACKET IS ONLY USED FOR PRODUCTION PURPOSE TO KEEP THE EXHAUST SYSTEM IN PLACE AND SERVES NO OTHER FUNCTION. BECAUSE OF THE LOWER RIDE HEIGHT OF THE R VEHICLES THE BRACKET CAN TOUCH THE GROUND IN EXTREME SITUATIONS. WHEN THE BRACKET TOUCHES THE GROUND IT CAN BEND (SEE ATTACHMENT IMAGE) AND SUBSEQUENTLY DAMAGE THE EXHAUST SYSTEM AND THE DRIVE SHAFT (CARDAN). PRODUCT CHANGES, INVESTIGATING IF PRODUCT CAN BE CHANGED IN PRODUCTION. PART RETURN, NO TECHNICAL REPORT, NO SERVICE, VOLVO ADVISES TO REMOVE THE BRACKET WHEN PRESENT ON R VEHICLES DURING SERVICE. THIS TO PREVENT FUTURE DAMAGE. REMARK, THESE BRACKETS ARE PRESENT UNDER ALL P2X AWD VEHICLES. IF THERE IS A CONCERN FOR PROBLEMS THE BRACKET CAN BE REMOVED WITHOUT CONSEQUENCES. *JB

CAR FAILS TO SHIFT UP OR DOWN UNDER ACELERATION AT LOW SPEEDS. THE CAR JUST DOES DO SEEM TO GO INTO GEAR, AND WHEN IT DOES IT JERKS THE CAR HARD.

VOLVO V70--- WE REMOVED THE HANDHOLDS FROM ABOVE THE DRIVER AND FRONT SEAT PASSENGER. MY WIFE, ELLEN, SUFFERED A CONCUSSION WHEN HER HEAD STRUCK THE HANDHOLD ABOVE HER AS SHE WAS DRIVING AND THE CAR WAS HIT IN THE FRONT. NO AIRBAGS DEPLOYED. I FOUND MYSELF BUMPING MY HEAD AGAINST THESE HANDHOLDS EVEN WHILE DRIVING. THESE HANDHOLDS OBVIOUSLY INTRUDE INTO THE HEADSPACE OF THE AUTOMOBILE. I AM SURPRISED THAT VOLVO WOULD USE SUCH IRON-HARD HANDHOLDS WITHOUT PADDING OR WITHOUT A COLLAPSING OR FOLDING MECHANISM. *NM

I AM VERY CONCERNED ABOUT THE VERY POOR QUALITY OF ILLUMINATION PROVIDED BY THE HEADLIGHTS, PARTICULARLY THE LOW BEAM, OF MY 2004 VOLVO V70R. IF I DRIVE ON A HIGHWAY WITH ONCOMING TRAFFIC SUCH THAT I CAN NOT USE MY HIGH BEAMS I WILL BE OVERDRIVING MY LOW BEAMS AT ANY SPEED OVER 30 MPH. I HAVE ALREADY BEEN BACK TO THE DEALER IN BELLINGHAM, WA TO HAVE ADJUSTMENT, BUT TO NO HELP. WORST HEADLIGHTS I HAVE EVER HAD ON A CAR. AND THESE ARE HID SPECIAL LIGHTS!!! *NM

WHILE DRIVING AT ANY SPEED STEERING WAS VERY LOOSE AT TIMES. DEALER STATED FRONT RIGHT TIE ROD WORE OUT COMPLETELY. *AK *NM

PROBLEMS WITH VEHICLE PULLING TO THE RIGHT WHILE DRIVING. *MR THE PROBLEM WAS SO-CALLED CORRECTED, BUT THE FRONT END ALIGNMENT PROBLEM RETURNED. THE VEHICLE HAD BEEN TO THE DEALER 4-5 TIMES TO CORRECT THE STEERING SAFETY ISSUE. ON THE LAST VISIT, THE LEFT FRONT MCPHERSON STRUT SPRING WAS CHANGED. *SC *JB