2019 VOLVO XC40 Complaints

While entering a parking spot my car suddenly accelerated and crashed into the wall in front of me in spite of my pushing my brakes 100%. The car never went into the automatic braking system before I applied the brakes, the seat belt never engaged and the air bags on the driver's side did not deploy. If I had not braced myself against the steering wheel my chest would have sustained a major injury. I am being treated for pain in my neck, arm and leg as a result of the crash. The sudden unintended acceleration has occurred in prior years of this model and after my model year as well and have been reported to NHTSA. Both my insurance and the manufacturer inspected the car. There were no warning messages or symptoms of a problem before this incident.

I was involved in an accident with my 2019 Volvo xc40. I believe the cause of the accident was due to the emergency braking system that activated when I hit water that accumulated on the road I was traveling. I was accelerating and the braking caused the vehicle to swerve uncontrollably resulting in some minor body damage to the passenger side as contact was made with some roadside objects. Unfortunately the incident caused over $10,000.00 in front end damages, which is covered by my insurance. This emergency braking i. e. forward collision avoidance automatic emergency braking, has the possibility of causing a more severe accident. I believe a software update was instituted, but the Volvo dealership never mentioned this update when I had my car serviced the past 3 years.

Front seat belts came on suddenly while stopped at light. Bruised front passengers neck. No car in front or near in rear.

The first incident happened back in Oct 2022. I took the car to local Volvo dealer, Rusnak Pasadena, and they said I needed the secondary battery replaced. They replaced it and the car worked for a few weeks until the alarm regarding the power steering failure came on again while my wife was turning left. I brought the car home carefully since it was a short distance from home. My wife was very scared because she almost had an accident and she doesn’t want to drive it any more….We didn’t drive the car for more than a month. On Jan 5, 2023, I took the car to the Rusnak dealer in Pasadena Ca. and they diagnosed it as: “Internal failure in power steering rack” needed replacement (see attached). They quoted me more than $3,350 to be fixed and they were not sure if warranty of 4 years would cover it. We then took it to JK Volvo Specialists, who I have known for years . They made a special order via Rusnak Volvo for the steering gear unit and it took two weeks to get it …See attached invoice that details the repairs needed to be replaced and total cost of $2500. This caused us to have to rent a car for a week, while we waited for the part to arrive. An additional $235. We believe that the failure of this electrical power steering, was not due to our neglect or error, and according to NHTSA report which states : “Electrical system malfunctions run deep enough to put people in danger, and in fact Campaign number 18V00000 states that some models, such as xc40, have faulty Vehicle Connectivity Module software..."

The contact owns a 2019 Volvo XC40. The contact stated while driving at various speeds, while his wife was seated in the passenger’s side front seat using an orthopedic back support, the air bag warning light illuminated. The contact stated that while not using the back support, the air bag sensor worked as designed. The contact stated that his wife used the back support due to physical issues and had used the lumbar support cushion to ease pain. The contact drove the vehicle to a dealer who advised that the only way to stop the sensor from being deactivated by the lumbar cushion was deactivating the sensor which was illegal. The manufacturer had been informed of the failure. The vehicle was not repaired. The failure mileage was approximately 26,000.

Earlier today I submitted a complaint, NHTSA Tracking Number 11498747. Would it be possible to send this back to me as I would prefer to modify it? Please do not post it now. Thanks, Craig Wenger [email protected] 910-471-7653

The vehicle has approximately 16,000 miles on it. It began to shudder in the front end when the brakes were applied at any speed. I contacted the dealer, Parkway Volvo of Wilmington, NC concerning the problem and was told that the vehicle had just gone out of warranty. On December 16, 2022, I took the vehicle to Derhams Alignment and Auto Repair, Wilmington NC to have the problem diagnosed. They found that the discs of the disc brakes on all four wheels were warped. They recommended replacement of these to repair the problem. Following this I took the car to Parkway Volvo on December 19, 2022, for a second opinion. Parkway came back with the same diagnosis and recommended that the discs be turned to straighten out the surface. I had this done at a cost of $420, and it repaired the problem. There is no reason that a vehicle with 16,000 miles should have warped discs unless it is abused, which this one has not been. I believe that the brake discs are made from inferior steel. I have been driving Volvos for over 20 years and the discs last well over 100,000 miles without an issue. I believe that Volvo is no longer using Swedish steel and instead importing the discs. The Volvo dealer made a number of excuses for the reason for the warping, one being that we have not used the car enough and/or that the electronic emergency brake warps the back discs if the car is parked to long. The car is garaged and parked on a level surface, without the emergency brake on. Also, this does not explain the front disc warping. I do not think that any of their excuses are reasonable, and I believe that Volvo should replace the discs with properly manufactured and safe ones without a charge. I am unable to find the receipt from Derhams Alignment at the moment, but would be glad to get a duplicate and submit it if you need it. Sincerely, Craig A. Wenger

Driver was stuck on ice pulling into a driveway, car got traction and driver thought they were on the brake but was on the gas. The vehicle ran into the garage going 9.9 mph (we have the EDR) and the steering wheel airbag and knee airbags deployed. The knee airbag caused a significant compound fracture of the lower tibia and fibula. Accident happened on 1/20 and orthopedics tried to repair using bone grafts, rods and screws. She has been non weight bearing since then and now on 7/27 it has been recommended to amputate the lower leg.

I WAS BACKING OUT OF MY DRIVEWAY AND MY BACKUP ALARM FAILED TO SOUND AS WELL AS MY BACKUP BREAKING SYSTEM. THE RESULT WAS ME BACKING UP INTO A PARKED VEHICLE. THE FAILURE OF THE SYSTEM WAS REPORTED TO THE VOLVO DEALERSHIP AND THEY DENIED THAT THE SYSTEM WAS NOT WORKING PROPERLY. SEVERAL MONTHS LATER WE RECEIVED A LETTER IN THE MAIL STATING THAT THERE WAS A RECALL FOR MY VEHICLE AND THAT THE BACK UP SYSTEM WAS NOT ALARMING OR BREAKING CORRECTLY AND FAILED TO ALARM OR BREAK INTERMITTENTLY. VOLVO DENIED THAT THE PROBLEMS WERE RELATED, HOWEVER THE RECALL CLEARLY STATED EXACTLY THE PROBLEM I HAD REPORTED EARLIER.

VOLVO'S PILOT ASSIST SYSTEM DISENGAGES WITHOUT ANY WARNING OR ALARM. THIS HAPPENS WHENEVER LANE MARKINGS ARE NOT VISIBLE OR IF THE CAMERA SYSTEM IS BLOCKED BY SUNSHINE. HOWEVER, IN ANY SCENARIO, THE PILOT ASSIST SYSTEM MUST ALERT DRIVER IF IT'S DISENGAGING. THE SYSTEM DISENGAGED MULTIPLE TIMES WITHOUT WARNING WHEN I WAS DRIVING ON HIGHWAY WITH PILOT ASSIST ON AND TILL NOW VOLVO HASN'T TAKEN ANY ACTION TO FIX THIS PROBLEM. *TR