2021 VOLVO XC40 Complaints

I was driving this car on Highway 99 on 7/11/2025. The dashboard flashed the message " Stop safely The vehicle will stop Propulsion system failure." I cut the lane and stopped my car on the Highway 99 shoulder. Just right, my car stopped on the Highway shoulder; it disabled itself and couldn't move at all. The gear shift can't shift to neutral (N). From the first message appearing on the dashboard to the car being disabled takes just a couple of seconds. When it happened, it was about 6:30 pm, rush hour. If I had not had a chance to drive the car immediately to the highway shoulder, the vehicle would have stopped in the lane, and I would have been crashed into by the cars behind me. This could lead to a catastrophic traffic accident. I want to mention that when the message appears on the dashboard, there is no sound alert. When people drive on the highway, their eyes are most likely focused on the road. Without a sound alert, people may not be aware of the message present. I contacted to the manufacturer on the 7/13, Sunday, they said they will open the case to investigation. As I report this incident, I have not heard from them yet. I uploaded the message photo that appears on the dashboard when the incident happened. Let me know if you need any information from me. Thank you!

On July 1st 2025, while slowly reversing out of my driveway at approximately 3–4 mph, the vehicle’s collision detection system errantly detected an imminent collision. Despite there being no obstacles, vehicles, pedestrians, or objects in the vehicle’s path, the system abruptly engaged the automatic emergency braking (AEB). This sudden and forceful braking caused me to experience whiplash due to the unexpected jolt. There was no prior warning or indication of a malfunction, nor any alert from the vehicle indicating why the braking occurred. After exiting the vehicle and inspecting the surroundings, I confirmed there were no obstructions behind or near the vehicle. This appears to be a false positive detection by the vehicle’s collision avoidance system. This incident raises serious concerns about the reliability and safety of the AEB system, particularly in low-speed reversing situations. An erroneous activation of this kind can result in injury to the occupants, potential rear-end collisions (in other traffic scenarios), and may also contribute to driver mistrust of critical safety features.

The contact owns a 2021 Volvo XC40. The contact stated that while reversing, the back over prevention screen image malfunctioned and started flickering before displaying a blank screen. During the failure, the message "Camera Unavailable" was displayed. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was recently repaired under NHTSA Campaign Number: 25V282000 (BACK OVER PREVENTION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 36,000.

After having the rear camera software update to address the safety recall on 05/28, the “camera unavailable” problem persists. This vehicle has underpowered chipset in the IHU and the entire IHU should be subject to recall.

Turning out of parking lot , car started pulsing, and stopped. Propulsion failure box popped up. Thankfully no cars behind us (young daughter in car seat)or was not attempting to merge on highway. Tow truck manually pulled car as no electric (cannot unlock or open trunk), completely shut down.

The 12-volt battery has failed on 5 occasions. Each time, I tried to unlock the vehicle after being away from it for a short period (e.g., 5-40 minutes). I had to use the manual key to unlock the vehicle, but the vehicle wouldn't start. I had the vehicle towed 4 times. One time it started on its own. I have taken the vehicle to my Volvo dealership 3 times for this issue. The most recent time this happened the dealership instructed me to have Volvo Roadside Assistance tow the vehicle to the dealership, even though the vehicle was 91 miles from the dealership. The tow operator confirmed to me that the car wouldn't operate, and that she reported this to the dealership. Still, because the dealership has be unable to replicate the problem, it refuses to replace the 12-volt battery system. There have been no warning lights. This is a safety issue because it has occurred at night, far from my home and outside of mobile phone coverage. I am also concerned that it may occur while I am driving, although that has not occurred.

-The forward automatic braking system/City Safety has misfired multiple times in all weather conditions, on surface streets and on the highway. -This causes automatic braking which could cause an accident. -The car is currently at the dealer for inspection since 10/25/2024. It is now 11/5/2024. -There was a message on the dash saying that the dashboard screen was blocked- this began a few months ago. This issue with the automatic braking began after my last service for an oil change about two months ago.

The check engine light has been on my vehicle since April 1, 2024. I have taken it in twice to a Volvo dealership and they cannot give me an answer as to why this is happening. They reset it and it comes right back on after a few miles. They tell me when they get an answer they will call me back in to have it fixed. It still has not been fixed.

When using the power liftgate, in normal day to day use, the strut had seized and the lift gate was stuck open. As we were parked, we attempted multiple times and different ways to lower the lift gate by the buttons provided for their lift gate, the key fob and by manually attempting to close. The lift gate would not close nor latch and it appeared to be misaligned. When we called Volvo Santa Ana Ca, Mina, a representative who assisted, advised to hold the center button to reset the electricals. That did not work. He then advised to manually push the lift gate closed in order to drive it to them and be serviced. When advised by Mina, a Volvo associate, the liftgate still would not close and we were only able to close it half way before taking it to them to be examined and serviced as it is still under warranty. This became a HUGE health and safety issue when using a component of the car that is expected to function flawlessly day in and day out. If this had happened in our garage, we would not be able to get out. After a few attempts we drove the car to Volvo Santa Ana Ca, and dropped it off, they took several days to respond to let us know what was happening. The service department director, Mark, had advised that the strut seizure causing the lift gate to not function is a common occurrence and that the struts would be covered by the warranty but the liftgate WOULD NOT BE; as it was no longer aligning (due to faulty, defective strut) and thus Mark claimed it was on us, to replace or repair. This was absolutely ridiculous. The defective part of the Volvo is what caused the issue. If one is covered then both should be. We did not get into an accident. We were parked. There is absolutely no damage to the liftgate prior to this date. We then opened a case with Volvo customer service and they also denied it. We feel this is unethical and a health and safety issue that Volvo does not care about nor care to inform their customer that faulty struts are common.

In approximately May of 2023, my vehicle experienced "propulsion system failure" per a dash board light, and would not drive. I had it towed to Volvo and they told me that it was a known defect that required a software upgrade. They upgraded the software. In May of 2024, the car had a second propulsion system failure. The Volvo dealer found the error code and light on the dash, followed diagnostic procedures and saw that the software is up to date. They opened a case with Volvo and Volvo informed them that they are aware that propulsion system failures are occurring even with the updated software installed. They are planning an upgrade but have not yet completed it or made it available. Thus, Volvo knows that the propulsion system can fail, including when the car is in driving, and has not advised consumers or corrected the problem.