2013 VOLVO XC60 Complaints

Windshield leaks water into cabin. Volvo dealership charged $190 to diagnose problem. Told me I need a new windshield but they do not do glass replacement or repairs. They said sealant is bad at top of windshield. This is the original factory windshield. They referred me to a independent glass company who quoted $900 - $1285 for replacement. Cannot repair only install new windshield. This seems to be a known problem with Volvo cars and the sealant that was used at factory? Not covered by insurance. Car was parked outside during rain.

During a heavy rain storm, I noticed water running down the inside of the windshield. It impaired my vision.

The accelerator got stuck and and the engine went full power. It would not shut off and the overheated.

Factory installed windshield is leaking profusely due to faulty adhesive/primer. This is a well known issue that causes havoc on vital electronic systems and should be a national recall. The loose windshield bond can cause the windshield to detach during a crash. The failed windshield bond compromises the structural integrity of the roof.

"During airbag deployment, the driver’s hand was burned with blistering. I believe hot gas or chemicals vented abnormally. This caused a painful injury requiring treatment."

Faulty seal in OEM windshield sealant/silicone causing water to leak on the inside of car, headliner, and inner windshield. Can cause visibility issues and mildew.

The windshield has come loose at the top allowing water to get into the vehicle when it rains. Water pools on the floor of driver’s side, the headliner gets wet, and the interior smells moldy.

The component or system that failed is the driver side door controls for all four windows and both side mirrors. My safety is at risk as I am unable to adjust my mirrors manually or electronically in order to see. I am also unable to roll down any of the windows in the vehicle from the driver door in the event of an emergency. Yes, the problem has been confirmed by the Volvo service center. According to my local Volvo service center, this is a common problem in Volvos and they are very familiar with the repair needed to correct. The problem is that the driver door wiring is zip-tied together and over time, as the driver door opens and closes, the zip tie chafes the insulation off of the wiring causing the copper part of the wires to be exposed and twisted together. There are no warning lights reporting this issue, only that the window and mirror controls stop working. The following video link between 9:38-12:16 explains this issue in Volvos. I am writing to advocate for a vehicle recall. I believe this is a manufacturing flaw which could have been avoided by simply using electrical tape and not a zip tie. The repair has been quoted at $800. Driver side door entry is an essential function and should not be a cause for an electrical fire or drivers’ and passengers’ safety. Link: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car came to a complete stop without a reason. This happened while exiting the freeway and no cars or objects were in front of me. I was very lucky that I did not have a car behind me or this would have caused a collision. After the car stopped the message "auto braking by City Safety" appeared on my dashboard

The vehicle came to a stop in two different occasions (6 months apart) without a reason. The first occasion was while exiting the freeway, there was no car or object in front of me. The second time I had gone over a manhole and the car screeched to a halt on a city street. I was very fortunate that in both occasions I did not have a car behind me or this malfunction would have caused a collision. After the car stopped I was able to continue driving. After the car stopped the message "Auto braking by City Safety" appeared on the dashboard.