2004 VOLVO XC70 Complaints

ALTHOUGH THE 'CRACKED FUEL PUMP FLANGE' RECALL SERVICE (VOLVO RECALL R220, NHTSA 09V-483) WAS PREVIOUSLY PERFORMED ON MY VEHICLE, THE VOLVO XC70 HAS AN ADDITIONAL 'FUEL SENDING UNIT' ON THE DRIVER'S SIDE OF THE CAR. THIS ADDITIONAL FUEL COMPONENT HAS A SIMILARLY FORMED FLANGE WHICH ALSO DEVELOPS A CRACK. EVEN THOUGH THE UNITS ARE SIMILARLY COMPOSED AND BOTH IN THE SAME ENVIRONMENT, I HAVE BEEN TOLD THE AUXILIARY FUEL SENDING UNIT IS NOT COVERED UNDER VOLVO RECALL 220. EXACTLY AS DESCRIBED IN THE FUEL PUMP RECALL, THE CRACK IN THE DRIVER'S SIDE FUEL SENDING UNIT ALLOWS GASOLINE TO CONSTANTLY OOZE THROUGH THE CRACK AND SLOWLY POUR ONTO THE GROUND AND PUDDLE. IF A FUEL PUMP FLANGE CRACK ALLOWING GASOLINE TO POUR ONTO THE GROUND WAS CAUSE FOR A RECALL, WHY IS THE EXACT SAME PROBLEM IN THE AUXILIARY FUEL SENDING UNIT NOT ALSO A CAUSE FOR RECALL?

I AM ORIGINAL OWNER. CAR HAS 135K MILES. WHILE DRIVING, DRIVER'S SIDE SEAT WARMER ALMOST STARTED FIRE. I SMELLED AND SAW SMOKE FROM SIDE OF SEAT. MELTED SIDE OF SEAT AND LEFT HOLE. I PULLED OVER AND PUT OUT BEFORE ANY FLAMES.

TL* THE CONTACT OWNS A 2004 VOLVO XC70. WHILE DRIVING 30 MPH, THERE WAS AN ABNORMAL ODOR DETECTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. *BF .. CONSUMER STATED VOLVO HAD A RECALL ON FUEL PUMPS IN SOUTHERN STATES ONLY.*JB

TL* THE CONTACT OWNS A 2004 VOLVO XC70. WHILE DRIVING VARIOUS SPEEDS, A FUEL ODOR WAS DETECTED INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO GOODWIN'S VOLVO (91 MAIN ST, TOPSHAM, ME 04086) WHERE IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 163,459. *TT CONSUMER STATED SMELLED GAS FROM, FROM THE BEGINNING, NOBODY COULD SMELL IT BUT MY DAUGHTER AND I FINALLY CHECKED BY USED CAR DEALER, THEY SAID IT WAS A LOOSE CLAMP, WHICH THEY TIGHTENED, I COULD SMELL IT SO THEY RECOMMENDED A SECOND OPINION TOOK IT TO GOODWINS VOLVO. TOPSHAM COPY OF FINDINDS ENCLOSED WHEN I TOOK IT BACK TO RENO MEADOWS AUTO, THEY SAID IT WAS THE VENT TUBE, THEY REPLACED THE COPY ENCLOSED, SEEMS TO BE OKAY NOW. UPDATED 10/15/18*JB

THE FUEL PUMP BEGAN LEAKING FUEL IN HOT WEATHER. IT LEAKS BOTH IF THE CAR IS BEING DRIVEN OR IF IT'S STATIONARY. THERE IS AN EXISTING RECALL THAT SEEMS TO COVER THIS ISSUE. IT IS REFERRED TO AS "RECALL 220" IN VOLVO'S DOCUMENTATION. THE ORIGINAL RECALL LIMITS THE AFFECTED VEHICLES TO ONES WHICH WERE ORIGINALLY PURCHASED IN SPECIFIC U.S. STATES. THIS IS ODDLY ARBITRARY CONSIDERING CARS CAN BE MOVED AROUND AND WARM WEATHER ISN'T EXCLUSIVE TO ANY SPECIFIC LOCATION. I'VE ATTEMPTED TO CONTACT THE MANUFACTURER AND THE NHTSA BUT AM IMMEDIATELY SHUT DOWN DUE TO MY VIN NOT BEING LISTED IN THEIR DATABASE. VOLVO ISSUED DOCUMENTATION TO THEIR SERVICE LOCATIONS ON HOW TO VISUALLY INSPECT A VEHICLE TO DETERMINE IF IT'S AFFECTED. I PERFORMED THOSE STEPS AND BELIEVE MY VEHICLE FITS THE GUIDELINES FOR THE RECALL.

THIS COMPLAINT IS FOR A 2004 VOLVO XC70. THIS CAR HAS SOME SERIOUS PROBLEMS WITH ITS VARIOUS MODULES. WHEN DRIVING ON A BUSY INTERSTATE HIGHWAY, THE CAR JERKED AS IF THE TRANSMISSION WAS SLIPPING. AFTER THIS A WARNING LIGHT STATING "BRAKE FAILURE; PULL OVER SAFELY" ILLUMINATED. CAR WENT INTO LIMP MODE WHILE ON THE HIGHWAY IN FAST-MOVING TRAFFIC. GOT CAR TO A PARKING LOT AND WAITED ABOUT 30 MINUTES. CAR STARTED AND I WAS ABLE TO DRIVE IT HOME, ALTHOUGH BEING ABOUT 50 MILES AWAY. CAR WENT IN TO LIMP MORE AGAIN DURING DRIVE AND LOST ALL DASH INDICATORS, INCLUDING TURN SIGNALS, SPEEDOMETER AND ODOMETER. LIGHT FOR "CHECK ENGINE" WAS ILLUMINATED. AFTER MECHANIC RESET CODES, HE STATED THAT IT MIGHT BE THE ECM OR TCM. I SENT OFF THE ECM FOR DIAGNOSIS AND IT CAME BACK WITHOUT ANY ERRORS. I THEN SENT OFF THE TCM AND LEARNED THAT IT NEEDED REPAIR. AFTER RECEIVING THE REPAIRED TCM UNIT, WE RE-INSTALLED AND CAR DROVE FOR A COUPLE OF DAYS. I TOOK THE CAR FOR A 6-HOUR ROUND TRIP DRIVE THIS PAST WEEKEND AND HAD ONE INCIDENT OF THE JERKING, BUT WITHOUT ANY OTHER ISSUES. AFTER LETTING THE CAR SIT IN THE DRIVE FOR AROUND 20 MINUTES, I TRIED STARTING IT ONLY TO GET ANOTHER "CHECK ENGINE" LIGHT AND INOPERABLE DASH INDICATORS (SPEEDOMETER, ODOMETER, TURN SIGNALS, ETC.). TOOK THE CAR TO A VOLVO DEALERSHIP TODAY FOR A DIAGNOSIS. THEY STATED THAT THERE WAS NO CONTACT OCCURRING WITH THEIR COMPUTER DIAGNOSTIC SYSTEM. THEY RECOMMENDED A REPLACEMENT OF THE CEM AS A FIRST STEP WITH NO GUARANTEE THAT THE PROBLEM RESIDES IN THE THAT MODULE. THAT PART INSTALLED IS OVER $1,100. THIS IS MY FIFTH VOLVO, AND UNDOUBTEDLY, THE WORST YET. I AM CONSIDERING JUNKING IT AND LEAVING VOLVO IN MY PROVERBIAL REAR VIEW. IT IS ASTOUNDING THAT VOLVO HAS NOT OFFERED A RECALL AS THIS IS CLEARLY A SAFETY HAZARD. PERHAPS IT TAKES PEOPLE DYING FOR CAR COMPANIES TO OWN UP TO FAULTY BUILDING.

TL* THE CONTACT OWNS A 2004 VOLVO XC70. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND A STRONG FUEL ODOR WAS PRESENT. THE CONTACT STATED THAT THE FAILURE OCCURRED FOR APPROXIMATELY SIX MONTHS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE) BECAUSE IT WAS REGISTERED IN THE PARTICIPATING STATES PER THE RECALL INFORMATION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

THE CAR LOCKS BY ITSELF AUTOMATICALLY WHEN KEY IS IN IGNITION AND YOU STEP AWAY FROM CAR LEAVING YOU LOCKED OUT. ACCORDING TO THE DEALER, THIS IS A "FEATURE" OF THIS CAR. AMONG ALL THE CARS I HAVE OWNED AND DRIVEN THIS IS THE ONLY THAT DOES THIS, VOLVO NEEDS TO CORRECT HIS ISSUE.

STARTED SMELLING GASOLINE WHEN DRIVING, AND NOTED DRIPPING UNDER GAS TANK WHEN PARKED. I REMOVED THE FUEL PUMP COVER IN THE FLOORBOARD, AND THERE IS A LEAK IN THE TOP OF THE FUEL PUMP, THAT DRIPS CONSTANTLY WHILE THE IGNITION IS ON. THIS HAS BEEN REPORTED BEFORE, BUT MY VIN IS NOT LISTED AS ONE OF THE USUAL SUSPECTS.

TL* THE CONTACT OWNS A 2004 VOLVO XC70. WHENEVER THE CONTACT FUELED THE VEHICLE, FUEL BEGAN TO LEAK OUT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 154,000.