2004 VOLVO XC70 Complaints

WHILE DRIVING AT ANY SPEED NOTED RUMBLING NOISE FROM LEFT FRONT END WITH RIGHT HAND TURN. FOUND TO HAVE BROKEN LEFT FRONT SPRING. MECHANIC INFORMS ME THAT THIS IS A COMMON PROBLEM IN VOLVOS. *TR

WHILE MY CAR WAS PARKED INSIDE MY GARAGE THERE WAS A SUDDEN "BANG". THE FOLLOWING MORNING I DISCOVERED WHILE BACKING OUT OF GARAGE THAT THE DRIVER SIDE COIL SPRING HAD BROKEN. HAD I BEEN DRIVING WHILE THIS HAPPENED IT WOULD HAVE RESULTED IN THE SHREDDING OF THE FRONT DRIVER SIDE TIRE POSSIBLY RESULTING IN A SEVERE ACCIDENT. THE REASON I OWN VOLVO IS PRINCIPALLY DYE TO IT'S REPUTATION FOR SAFETY. IN FACT, VOLVO USES THE TERM SAFETY IN ALL IT'S ADVERTISING. THIS IS A GRAVE FLAW AND I ASK NHTSA TO INVESTIGATE WEATHER THIS IS A COMMON FLAW IN THE 2004 VOLVO XC70 AND OTHER VOLVO'S WITH THIS COIL SPRING. *TR

ENGINE HESITATION UPON ACCELERATION AND SUDDEN TRANSITION INTO THE "REDUCED ENGINE PERFORMANCE" MODE WHICH WAS EXTREMELY DANGEROUS ON THE FREEWAY. THE INCIDENT HAPPENED SEVERAL TIMES WITH THE FAILURE CODES POINTING TO THE "ETM". IN OTHER CASES THE ENGINE WAS SURGING AFTER START AND THEN WENT BACK TO THE "LIMP" MODE.

TL* THE CONTACT OWNS A 2004 VOLVO XC70. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES. THE CHECK ENGINE LIGHT ILLUMINATED WHILE THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE MECHANIC TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE FUEL PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 178,000 AND THE CURRENT MILEAGE WAS 182,000.

WHILE BACKING OUT OF A PARKING PLACE, I FELT A SENSATION OF GOING OVER A BUMP. I STOPPED THE CAR AND EXAMINED AROUND AND UNDER THE CAR. NO OBJECT OR "BUMP" ITEM WAS SEEN. I DROVE SLOWLY AND EXPERIENCED METALLIC NOISES COMING FROM THE CAR. UPON HAVING THE CAR CHECKED BY MY REGULAR GARAGE, IT WAS DETERMINED THAT THE EMERGENCY BRAKE HAD BROKEN. I HAVE HAD IT REPLACED (VERY EXPENSIVE) AND THE MECHANIC SAID HE HAD NEVER SEEN THIS TYPE OF EMERGENCY BREAK DAMAGE BEFORE. OTHER OWNERS OF THIS VEHICLE MAY BE HELPED BY THIS INFORMATION. *TR

WHILE DRIVING ON SMOOTH SURFACE- HEARD A SUDDEN LOUD SOUND AS IF SOMETHING LARGE DROPPED ON THE ROAD. CAR CONTINUED TO DRIVE NORMALLY EXCEPT WITH A LOUD CLUNKY SOUNDS HEARD OVER BUMPS. LESS THAN 5-MILES LATER, WHEN I PULLED OVER TO THE GARAGE- I RECOVERED A PIECE OF THE SPRING COIL WHICH DROPPED: THE DRIVER SIDE COIL SPRING HAD BROKEN/FAILED INSTANTANEOUSLY. THIS UNCOMMON PROBLEM APPEARS TO BE COMMON WITH XC70 OWNERS- AND COULD RESULT IN POTENTIALLY SERIOUS ACCIDENTS. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC70. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS THE VEHICLE MADE A THUMPING SOUND AND DECELERATED. ALSO, ALL OF THE LIGHTS ON THE INSTRUMENT PANEL TURNED OFF AND THE BRAKE LIGHTS AND TURNING SIGNALS FAILED. THE CONTACT MENTIONED THAT ALL OF THE LIGHTS AND INSTRUMENT PANEL WERE OPERATING NORMALLY AFTER A FEW HOURS. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE AND ADVISED THE CONTACT THAT THE INSTRUMENT PANEL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 79,918.

THE CAR WAS GOING 60-63MPH DOWN THE HIGHWAY THERE WAS A SUDDEN HARD CLUNK IN THE TRANSMISSION AND MY GUAGE CLUSTER WENT DEAD AND LOST ALL POWER OPTIONS. WAS ALMOST HIT AS I TRIED TO PULL OVER WITH NO BLINKERS, FLASHERS, ETC. AFTER ABOUT 10 MINUTES I TRIED TO START THE CAR AGAIN AND THE DASH CAME BACK BUT SRS WARNING WAS UP ON THE INFO CLUSTER. TOOK MY CAR TO THE REPAIR SHOP (AUTHORIZED VOLVO REPAIR) AND WAS TOLD THERE WERE NO CODES PRESENT. THEY DROVE THE CAR FOR A WEEK AND SAME THING HAPPENED TO THEM. THEY SUGGESTED THAT THE CEM VOLVO PART NUMBER 30657629 WAS NO GOOD. TO REPLACE IT WOULD BE 1300$ AFTER SOME RESEARCH I FOUND THAT THERE ARE A LOT OF OTHER VOLVO OWNERS WHO HAVE HAD THIS SAME OCCURRENCE, AND EVEN BEEN IN ACCIDENTS DUE TO THIS FAILURE AT DIFFERENT INTERVALS IN MILEAGE RANGING FROM 50K AND UP. SEEMS TO ME THERE SHOULD BE A RECALL AND SOME REPAIRS MADE TO THE CEM ON THE V70, XC70, S90, S40 ETC AS THEY ALL SEEM TO DO IT. *TT

TL* THE CONTACT OWNS A 2004 VOLVO XC70. WHILE PARKED, THE CONTACT NOTICED A FUEL ODOR COMING FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP) BUT AS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS INCLUDED IN AN EXTENDED WARRANTY BUT THE VEHICLE HAD ALREADY EXCEEDED THE MILEAGE REQUIREMENTS. THE FAILURE MILEAGE WAS 151,000. UPDATED 04/19/12*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED BY THE DEALER AT A REASONABLE PRICE. VOLVO PAID FOR THE PARTS. UPDATED 04/27/12

DURING ACCELERATION THE GEARING SLIPS BETWEEN 1ST AND 2ND GEAR CAUSING A VERY HARD SHIFT (DUE TO ENGINE ACCELERATION) WHEN THE 2ND GEAR ENGAGES. IT IS DANGEROUS AT TIMES IN ICE OR SNOW. *TR