2005 VOLVO XC90 Complaints

STRONG FUEL ODOR WITHIN CABIN AFTER FUEL FILLUP, THERE IS A RECALL ON FUEL PUMPS DUE TO FIRE RISK ON THIS EXACT MODEL, JUST NOT ON MY VEHICLE. SHOULD I WAIT FOR A FIRE BEFORE A RECALL IS ISSUED? *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE SUDDENLY STALLED WITHOUT ANY WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER WAITING A FEW MOMENTS. THE VEHICLE HAD NOT BEEN INSPECTED BY A DEALER AND WAS NOT REPAIRED. THE DEALER WAS LATER NOTIFIED, BUT THE CONTACT HAD YET TO RECEIVE A RESPONSE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. UPDATED 02/15/12*BF UPDATED 02/27/12

SLUDGE BUILD UP IN THE ENGINE EVEN AFTER SCHEDULED OIL CHANGES. WAS TOLD THE ENGINE/TURBO WOULD HAVE TO BE PLACED AFTER 100,000 MILES. *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS. THE FIRST OCCURRENCE OCCURRED WHILE DRIVING APPROXIMATELY 55 MPH. THE CONTACT WAS ABLE TO SUCCESSFULLY RESTART THE VEHICLE AFTER THE FAILURES OCCURRED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

COUNTER BALANCE SHAFT FAILURE LEADING TO COMPLETE ENGINE FAILURE. DEFECTIVE DESIGN. *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE STOPPED AT A TRAFFIC STOP, THE VEHICLE BEGAN TO SHAKE BACK AND FORTH UNCONTROLLABLY. THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL IN ORDER FOR THE VEHICLE TO STOP SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE FOUR WHEEL DRIVE MOTOR WAS NOT ENGAGING AND WOULD HAVE TO BE REPLACED. THE FOUR WHEEL DRIVE WARNING LIGHT WAS NOT INDICATING THAT THERE WAS A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

THE BALANCER BEARING AND SHAFT ON THE 2005 VOLVO XC90 SUV IS DEFECTIVE IN THE FIRST 6000 VEHICLES MANUFACTURED FOR THAT MODEL YEAR. THE BALANCER SHAFT BEARING CAN GO BAD AT ANY TIME WITHOUT WARNING, CAUSING CATASTROPHIC ENGINE DAMAGE. IF THIS HAPPENS ON A HIGHWAY WHILE TRAVELING AT A HIGH RATE OF SPEED, THE RESULTS COULD BE DEADLY. VOLVO NORTH AMERICA IS AWARE OF THIS AND DOES NOTHING TO ADDRESS THIS SERIOUS, POTENTIALLY DEADLY SITUATION. WE HAVE BEEN WORKING TO GET VOLVO OF NORTH AMERICA TO RECOGNIZE THIS ISSUE AND THEY HAVE DOING NOTHING TO DATE EXCEPT POINT TO MAINTENANCE, WHICH HAS NO IMPACT ON THE PROBLEM. THERE IS NO MAINTENANCE PROCEDURE TO INSURE THIS DOES NOT HAPPEN AND VOLVO WILL NOT PAY FOR DAMAGES. THE REMEDY IN MOST CASES IS AN ENGINE REPLACEMENT WHICH COSTS ABOUT $15,000 , AND AS MENTIONED, VOLVO WILL NOT PAY FOR IT. VOLVO MUST BE FORCED TO RECALL THESE VEHICLES AND FIX THE PROBLEM AND COMPENSATE OWNERS WHO HAVE BEEN IMPACTED. THESE VEHICLES MUST BE RECALLED AND THE PROBLEM MUST BE FIXED BEFORE COUNTLESS LIVES ARE PUT AT RISK BY THIS TICKING TIME BOMB THAT WILL GO OFF. AT 70 MILES AN HOUR , A FAILED ENGINE COULD LEAD TO DEATH. THERE ARE 6000 VOLVO XC90'S WITH THIS PROBLEM. *TR THE DEALER DIAGNOSED THE PROBLEM AS A COMPLETE ENGINE FAILURE DUE TO THE BALANCER BECOMING DAMAGED AND CAUSING CATASTROPHIC ENGINE FAILURE. THE CONSUMER WAS INFORMED IT WOULD COST $ 14,700 TO REPLACE THE ENGINE. UPDATED IVOQ 03/09/12

TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT HEARD A LOUD NOISE EMITTING FROM THE FRONT END OF THE VEHICLE. IMMEDIATELY THERE WAS A SLIGHT LOSS OF ENGINE POWER DURING ACCELERATION. THE MALFUNCTION PROGRESSED AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THE ENGINE WOULD NEED TO BE REPLACED AS A RESULT TO THE ENGINE BALANCE SHAFT FRACTURING. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

HEARD LOUD TICKING NOISE COMING FROM ENGINE AT 86330K MILES. VEHICLE RIDE BECAME SOMEWHAT ROUGH. DIAGNOSED AT VOLVO DEALERSHIP AS BALANCE SHAFT BEARING "PART FAILURE". EST. TO FIX: ~$3800. VOLVO AGREED TO COMPENSATE FOR THE PARTS, APPROX $1500. BALANCE OF $2325.50 PAID BY VEHICLE OWNER. TOOK 1 WEEK FOR VOLVO TO OBTAIN PARTS AS THEY ARE NOT COMMONLY STOCKED OR WERE BACK ORDERED. ON LINE RESEARCH REVEALED THIS TO HAVE BEEN A PROBLEM WITH EARLY 2005 XC90 V8'S. WATER/CONDENSATION/VAPOR IS ABLE TO GET IN AND RUST THE BEARING LEADING TO ENGINE FAILURE. A TSB WAS ISSUED (? WHEN) FOR A FIX TO DRILL A "WEEPING HOLE" IN ENGINE BLOCK TO DRAIN WATER FROM THE BEARING. *TT

A COMPLAINT WAS PREVIOUS FILED REGARDING TO TURN SIGNAL PROBLEM. SITUATION GETTING WORSE. VOLVO XC90 V8 2005; REPLACED CEM UNIT TWO YEARS BACK. RECENTLY FOLLOWING PROBLEMS HAPPENED. 1. TURN SIGNAL STOP WORKING 2. NO HIGH BEAM 3. NO WINDSHIELD WASHING 4. NO CRUISE CONTROL 5. NO VEHICLE INFORMATION FUNCTION PROBLEMS LOOK LIKE ASSOCIATED WITH FAULTY CEM AGAIN. VEHICLE IS VERY RISKY TO DRIVE WITH UNRELIABLE OR NOT-FUNCTIONING TURN SIGNAL. *TR