2005 VOLVO XC90 Complaints

VOLVO XC90 2005, TURNING SIGNAL ACTS DANGEROUSLY. SOMETIMES IT WORKS BUT MOST TIME NO ACTION HAPPENS. COMPLETELY DEAD AND RESTARTING CAR SOMETIMES FIX THE PROBLEM. MULTIPLE CASES OF DANGEROUS INCIDENTS DUE TO NO SIGNAL. *TT

VOLVO XC90 2005 LOW BEAM BULB FAILURE ERROR AND ONE BEAM TURNS OFF. THEN COMES BACK ON, AND SOMETIMES ALL LIGHTS GO OFF. VERY DANGEROUS AT NIGHT. IF YOU TURN THE HEADLIGHT DIAL TO ANOTHER SETTING THEY WILL COME BACK ON, BUT THEN BLINK OFF AGAIN, AND SOMETIMES OFF COMPLETELY. THE BIGGEST ISSUE IS THE INTERMITTENT OCCURRENCE OF THIS. THE CAR IS NOT SAFE TO DRIVE. *TR

PURCHASED USED 2005 VOLVO XC90 IN SPRING OF 2010. DURING THE NEXT YEAR EXPERIENCED VERY INTERMITTENT ELECTRICAL ISSUES. EXAMPLES ARE LOCKS NOT WORKING, BLINKER, RADIO. THESE ISSUES LITERALLY ONLY HAPPENED A COUPLE TIMES. IN APRIL 2011 HAD BIYEARLY SAFETY AND EMISSIONS DONE AT LOCAL DEALERSHIP (NON VOLVO) AND IT DID NOT PASS EMISSIONS. NEXT DAY TOOK MY VOLVO XC90 TO WEISS VOLVO AND IT PASSED EMISSIONS (WITHOUT ME KNOWING THEY CLEARED ERRORS ON THE CAR TO GET IT TO PASS. THIS MUST BE THE REASON IN EUROPE THAT DEALERSHIPS CAN'T INSPECT THEIR OWN MAKE OF CARS) ON JULY 17 2011 I WAS DRIVING DOWN THE HIGHWAY WITH MY 1 YEAR OLD IN THE BACK SEAT. RADIO WENT OUT. A FEW MINUTES LATER ALMOST EVERYTHING IN THE CAR SHUT DOWN EXCEPT FOR THE ENGINE. LOST A/C (IT WAS 110 THAT DAY), LOST POWER STEERING, BRAKING WAS INTERMITTENT, NO BLINKERS, NO HEADLIGHTS, NO LIGHTS IN INTERIOR, WHILE I WAS AT FULL SPEED ON THE HIGHWAY. I AM NOT SURE IF ENGINE WAS INTERMITTENT OR NOT BECAUSE I GOT OFF AS SOON AS I COULD. I WAS VERY CLOSE TO WEISS VOLVO SO DROPPED IT OFF THERE AGAIN ON THE DATE OF THE TOTAL FAILURE. CALLED VOLVO CUSTOMER CARE ON JULY 18 2011 TO FILE COMPLAINT. WEISS VOLVO CALLED BACK AND TOLD US CAR WOULDN'T START. CALLED BACK LATER IN THE DAY AND SAID THEY SAW THAT EVERYTHING WENT OUT AND CAR WAS FULL OF CODES. WEISS SENT IN AN ESTIMATE FOR $1500 TO REPLACE ECM. I ASKED WEISS TO PERFORM AN EMISSIONS TEST (BY MO LAW MANUFACTURER'S CARS MUST PASS EMISSIONS TEST UP TO 80K MILES AND MY CAR HAD 61K) I RESEARCHED ECM AND FOUND VERY SIMILAR STORIES TO MINE AND BROUGHT THIS UP TO VOLVO NA. VOLVO NA TOLD WEISS VOLVO TO "RESET" MY CAR (AGAIN WITHOUT MY PERMISSION). THE CAR THEN WAS FUNCTIONAL AFTER RESET. WEISS THEN "TESTED" MY CAR FOR ALMOST 3 WEEKS TO FIGURE OUT THE DESIGN FLAW FOR A TOTAL OF 451 MILES. THE MECHANIC TOLD ME IT WAS THE ECM BUT VOLVO NA SAID IT WAS VARIOUS OTHER REASONS AND WOULDN'T REPLACE IT. CAR STILL BROKE. REACHED LIMIT. *KB

TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIANS STATED THAT THE TRANSMISSION HAD TO BE REPLACED. AFTER THE REPLACEMENT, THE FAILURE RECURRED APPROXIMATELY 40,000 MILES AFTER THE TRANSMISSION WAS REPLACED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

I'D LIKE TO ADD MY COMPLAINT TO THE LIST OF THOSE ALREADY REPORTING THE ABRUPT LOSS OF ALL ELECTRONICS, INCLUDING WINDSHIELD WIPERS AND ALL DASHBOARD GAUGES, DURING A RAINSTORM. MY ISSUE WAS ALSO IDENTIFIED AS A PREMATURELY CORRODED CENTRAL ELECTRONIC MODULE (CEM) CAUSED BY A DESIGN FLAW ALLOWING WATER TO ACCESS THE CEM CONNECTOR. I'M SHOCKED TO FIND OUT VOLVO KNEW ABOUT THIS IN 2005, WELL WITHIN THE WARRANTY PERIOD FOR MOST OF THESE AFFECTED VEHICLES, AND DID NOTHING TO CORRECT OR EVEN ALERT THEIR OWNERS. I URGE THE NHTSA TO REVISIT THEIR INVESTIGATION, AND FORCE A RECALL IF VOLVO CONTINUES TO REFUSE. I CAN ASSURE YOU AS A DRIVER DURING THIS EVENT, THIS IS INDEED A SAFETY ISSUE, AND I HOPE WE AREN'T WAITING FOR ENOUGH INJURIES OR DEATHS BEFORE YOU GET TO THAT OBVIOUS CONCLUSION.

BRAKES LIGHTS ALWAYS ON. TOOK CAR TO DEALER AND THEY ADVISED THAT WATER HAD LEAKED INTO CEM MODULE AND MAIN WIREHARNESS AND REQUIRED REPLACEMNET AT A COST OF $7000. KNOWN ISSUE TO VOLVO WITH SERVICE BULLETIN SENT TO DEALERS. FOUND INDEPENDENT VOLVO REPAIR SHOP WILLING TO REPLACE MODULE ONLY (SOFTWARE DOWNLOAD FROM DEALER) AND CLEAN BUILD-UP ON HARNESS CONNECTORS. REQUIRING REMOVAL OF PART OF DASH, DRIVER SEAT. TOOK 4 DAYS AT REPAIR SHOP. REPAIR COMPLETED FOR UNDER $2000. *TT

1.JULY 8, 2011. 2005 VOLVO XC90 BALANCE SHAFT BROKE OFF WITHIN CAR ENGINE. HEARD A LOUD SOUND COMING FROM CAR ENGINE, AND LOST A GREAT DEAL OF POWER WHILE DRIVING ON HIGHWAY. 2.FURTHER DAMAGE TO THE VEHICLE ENGINE COULD HAVE BEEN DONE DUE TO ACCELERATING TO GET OF THE HIGHWAY IN ORDER TO AVOID A COLLISION FROM VEHICLES COMING FROM BEHIND. THIS WAS A SCARY LIFE AND DANGEROUS EXPERIENCE. 3.VOLVO HAVING EXPLAINED WHAT CREATED THE PROBLEM TO DATE. THE ENGINE WILL HAVE TO BE PULLED OUT AND ALMOST RE-BUILT AT A COST TO ALMOST $8500.00 EXTENDED WARRANTY I PAID $4,100 FOR IS NOT COVERING FULL COST. I AM RESPONSIBLE FOR OVER $2000 + COST OF CAR RENTALS TO DATE. JULY 28, 2011, CAR IS STILL WITH VOLVO. *TR

1. HEARD MARBLE NOISES UNDERHOOD AFTER 56,000 MILES OF NORMAL DRIVING. WELL MAINTAINED. 2. BALANCE SHAFT BEARING BROKE APART AND PUT OUT METAL SHARDS BETWEEN CYLINDER HEADS. LOUD METALLIC NOISE FROM ENGINE. VEHICLE WAS SHUT DOWN IMMEDIATELY AFTER PULLING OVER TO AVOID ENGINE DESTRUCTION AND TRAFFIC ACCIDENT DUE TO HALTED VEHICLE. HAD TO BE TOWED. 3. BALANCE SHAFT BEARING IS BEING REPLACED. OLD PART (IN PIECES) AVAILABLE FOR ANALYSIS. *TR

DRIVING AT HIGHWAY SPED IN 2005 VOLVO XC 90 WHEN SUNROOF GLASS EXPLODED. GLASS REPAIR FACILITY SAID THERE WAS LIKELY A FLAW IN THE GLASS. VOLVO SAYS NOT LIKELY. IF I HAD HAD THE SHADE OPEN ALL THAT GLASS WOULD HAVE FALLEN ONTO ME/PASSENGERS AND INTO EYES. SHATTERED INTO A THOUSAND LITTLE PIECES. COULD HAVE CAUSED A ACCIDENT AND/OR PERSONAL INJURY. *TT

TRANSMISSION PROBLEM ON 2005 XC90 T6. SLIPPING AND SHIFTING PROBLEMS. FOUND METAL CHUNKS IN TRANSMISSION OIL PAN. REPORTED TO VOLVO NA FOR "GOODWILL" REPAIR OR REPLACEMENT. DENIED BECAUSE VEHICLE HAS OVER 100K MILES. VEHICLE IS ONLY USED ON WEEKENDS AN LONG TRIPS. NOT BEING DRIVEN HARD. VOLVO NOT LIVING UP TO EXPECTATIONS OR REPUTATION. *TR