2005 VOLVO XC90 Complaints

OUT OF THE BLUE A WELL-MAINTAINED AND WELL CARED FOR 2005 VOLVO XC90 V8 SUV DEVELOPED A SEVERE ENGINE KNOCKING/BANGING SOUND (ALL SERVICE RECORDS COMPLETED AT REQUIRED TIME PERIODS). ACTUALLY SOUNDED LIKE BALL BEARINGS ROLLING AROUND INSIDE THE ENGINE COMPARTMENT. 58,000 MILES ON THE VEHICLE. ENGINE WAS SHUT DOWN IMMEDIATELY AND VEHICLE FLATBEDDED TO THE SERVICE DEALER. UPON INSPECTION, THE COUNTERBALANCE BEARING AND SHAFT FAILED. IF ENGINE HAD NOT BEEN SHUT DOWN THERE WAS A VERY REAL POSSIBILITY OF THE BEARING SEIZING AND THE SHAFT HITS THE INSIDE OF THE ENGINE BLOCK BREAKING THE TIMING CHAIN BENDING ALL THE VALVES(I.E. CATASTROPHIC ENGINE FAILURE)! AS THE MANUFACTURER, VOLVO SHOULD BEAR THE FULL MONETARY RESPONSIBILITY WHEN IT COME TO THIS REPAIR. A SERIOUS DESIGN FLAW IN THEIR ENGINE IS THE CAUSE OF THIS FAILURE. THE SERVICE TECH MUST TEAR YOU ENGINE APART (LITERALLY REMOVE THE ENGINE FROM THE VEHICLE AND OPEN THE ENGINE BLOCK!) TO PROPERLY COMPLETE THE REPAIR. VOLVO SHOULD BE PICKING UP THE ENTIRE COST OF THIS FIASCO. PARTS AND LABOR. PERIOD. TO DATE VOLVO MAKING OWNERS PAY FOR THE REPLACEMENT PARTS. THE PARTS ARE BETWEEN $1200-2000. IT IS NOT THE CORRECT WAY FOR A SO-CALLED 'QUALITY AUTOMOBILE MANUFACTURER' TO HANDLE THE SITUATION. WHEN CUSTOMERS PAY $45000-$55,000 FOR AN AUTOMOBILE, THEY EXPECT THE CAR (AND THE ENGINE!) TO LAST A WEE LONGER THAN 55,000-75,000 MILES (SARCASM INTENDED). FRANKLY, THIS WILL BE MY LAST VOLVO. *TR

SAFETY COMPLAINT 'SECOND OCCURRENCE SAME VEHICLE - SUDDEN VEHICLE DISABLED ' 2005 VOLVO XC90 V8 ' FEBRUARY 2011 153,000 MILES. DAUGHTER WITH LEARNER PERMIT DRIVING DOWN BUSY URBAN ROAD AND VEHICLE SUDDENLY STOPPED WITHOUT WARNING IN THE RIGHT OF WAY. VEHICLE HAD TO BE PUSHED TO SIDE OF ROAD SECOND COUNTERBALANCE SHAFT BEARING FAILURE. THIS FAILURE OCCURRED ON THE REPLACED ENGINE FROM THE PRIOR OCCURRENCE ' SEE COMPLAINT NUMBER 10392958. THIS ENGINE HAD 77,000 MILES AT TIME OF FAILURE. THE TIMING CHAIN HAD NOT BROKEN AND THE BALANCER SHAFT, IDLER GEAR COULD BE REPLACED AND ENGINE REPAIRED AFTER THE ENGINE HAD TO BE REMOVED - $3,000 REPAIR. VOLVO WOULD NOT COVER ANY COST EVEN THOUGH A PRODUCT BULLETIN WAS PUT OUT. VEHICLE ALWAYS SERVICED BY VOLVO DEALER AND NO MENTION EVER MADE OF POTENTIAL FOR FAILURE OR THE BULLETIN. RESEARCH NOW INDICATES THIS TO BE A COMMON PROBLEM FOR THIS MODEL YEAR CONFIGURATION. WE HAVE PURCHASED ANOTHER BRAND DUE TO SAFETY CONCERN, FAILURE TO PROVIDE SERVICE BY THE DEALER AND FAILURE OF VOLVO TO ACKNOWLEDGE ANY RESPONSIBILITY. THE % OF 2005 VOLVO XC 90 V8 VEHICLES WITH THIS SAFETY ISSUE AND ENGINE FAILURE RATE NEEDS TO BE ANALYZED. PLEASE REVIEW AND INITIATE AN INVESTIGATION. *TR

SAFETY COMPLAINT - SUDDEN VEHICLE DISABLED ? 2005 VOLVO XC90 V8 ? JUNE 2010 130000 MILES. WIFE WAS DRIVING BUSY URBAN ROAD AND VEHICLE SUDDENLY STOPPED WITHOUT WARNING IN THE MIDDLE OF THE INTERSECTION. VEHICLE HAD TO BE PUSHED FROM MIDDLE OF INTERSECTION. COUNTERBALANCE SHAFT BEARING FAILURE. THE TIMING CHAIN HAD BROKEN AND THE ENGINE HAD A CATASTROPHIC FAILURE. REPAY WAS $10,000 WITH A USED 60,000 MILE ENGINE INSTALLED. VOLVO WOULD NOT COVER ANY COST EVEN THOUGH A PRODUCT BULLETIN WAS PUT OUT. VEHICLE ALWAYS SERVICED BY DEALER AND NO MENTION EVER MADE OF POTENTIAL FOR FAILURE OR THE BULLETIN. *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 40 MPH IN RAINY WEATHER, THE DRIVER ATTEMPTED TO TURN ON THE WINDSHIELD WIPERS BUT THEY WOULD NOT ENGAGE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE CENTRAL ELECTRONIC MODULE WOULD NEED TO BE REPLACED BECAUSE RAIN WAS SEEPING INTO THE CENTRAL ELECTRONIC MODULE. THE VEHICLE WAS REPAIRED. UPDATED 05/05/11*LJ UPDATED 05/13/11

I PURCHASED A 2005 XC90 V8 AWD WITH 65000, AFTER A MONTH OR SO I NOTICED HARD SHIFTING, YESTERDAY WE TOOK A TRIP UP THE MOUNTAIN AND I ACTUALLY LOST MY TRANSMISSION FOR A MIN, IT SLIPPED OUT OF PLACE WHILE PASSING A VEHICHLE, RPM SHOT UP TO 5-6K, IT KICKED BACK IN AGAIN ONCE WE SLOWED AND WE PULLED TO THE SIDE TO MAKE SURE IT WOULD STAY IN GEAR BEFORE GOING AGAIN. NOW IT HAS GONE BACK TO HARD SHIFTING OCCASIONALLY. I FEEL VERY UNSAFE AND FOUND LOTS OF REPORTS OF SIMILAR INCIDENTS. CONTACTING VOLVO HAS NOT BEEN HELPFUL AT ALL THEY WANT 7K FOR A NEW CRAPPY BUILT TRANSMISSION. NEW VEH 45K AND NEW TRANSMISSION EVERY 50K MI, WHAT A DEAL THIS CAR IS. I DONT WANT TO WAIT TILL ME OR MY FAMILY IS HURT OR KILLED TO REPORT IT.

TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT BEGAN TO HEAR A KNOCKING NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE BEARING AND CAM SHAFTS WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 126,000 AND THE CURRENT MILEAGE WAS 128,000.

WHILE DRIVING ON THE HIGHWAY IN RAIN, THE HEADLIGHTS OF THE CAR BEGAN FLASHING ON AND OFF (SOMETIMES DRIVERS SIDE, SOMETIMES PASSENGER SIDE, SOMETIMES BOTH) INTERMITTENTLY. I PULLED OVER AND TURNED OFF AND RESTARTED CAR. THIS SOLVED THE PROBLEM FOR A FEW MILES, THEN IT DID IT AGAIN. NOW, THE RIGHT LIGHT IS OUT COMPLETELY, BUT AT LEAST THE LEFT SEEMS TO BE STAYING ON. THIS EXACT SAME THING HAPPENED ONE OTHER TIME. THE DEALERSHIP CLAIMED THEY COULD FIND NOTHING WRONG WITH THE VEHICLE. *TR

2005 VOLVO XC90 COUNTER BALANCE SHAFT BROKE AND SEIZED ENGINE. ONLY 68,000 MILES AND A WELL MAINTAINED VEHICLE! VOLVO REFUSES TO TAKE ANY RESPONSIBILITY FOR THIS POORLY DESIGNED SYSTEM. QUOTED $16,850 PLUS TAX FOR REMANUFACTURED UNIT. INCIDENTALLY, JUST THIS PAST SEPT ALSO HAD TO REPLACE OIL COOLER, THERMOSTAT AND EXPANSION TANK WHEN THE VEHICLE BROKE DOWN AS WERE DRIVING THROUGH VIRGINIA. THIS IS ANOTHER WELL DOCUMENTED ISSUE WITH THIS VEHICLE! *LN

COUNTERBALANCE SHAFT BEARING FAILURE AT 113,000 MILES LUCKILY FAILURE HAPPENED ON THE WAY TO THE REPAIR SHOP. IF THIS WOULD HAVE TAKEN PLACE ON THE HIGHWAY MY WIFE AND KIDS COULD HAVE BEEN SERIOUSLY INJURED. VOLVO KNOWS THIS IS AN ISSUE OR WOULD NOT HAVE RELEASED A TECHNICAL SERVICE BULLETIN ON WAYS TO REMEDY THE PROBLEM BY DRILLING WEEP HOLES IN THE BLOCK TO SHED MOISTURE. THE TRAPPED MOISTURE CAUSES THE BEARING TO RUST AND FINALLY FAIL CAUSING CATASTROPHIC ENGINE FAILURE. VOLVO HAS OFFERED A MERE $3,000.00 TO CORRECT A $15,000.00 PROBLEM. I HAVE READ NUMEROUS TESTIMONIES FROM OTHER 2005 XC-90 OWNERS WITH ENGINE FAILURE ALWAYS FROM THE FAILED COUNTERBALANCE SHAFT BEARING. HOW DO WE FORCE VOLVO TO ISSUE A RECALL BEFORE SOMEONE GETS SERIOUSLY INJURED.

2005 XC90 V8-MANY PROBLEMS WITH CHECK ENGINE LIGHT COMING ON AND CAR LOSING POWER. LOST POWER ON INTERSTATE-CAR WOULD LOSE POWER AND SPEED-NEEDED TOW-HAPPENED TWICE. CURRENT ISSUE CHECK ENGINE LIGHT CAME ON FOLLOWED BY ALL LIGHTS COMING ON STATING BRAKE FAILURE, POWER OVERLOAD, LIMP MODE AND BRAKE FAILURE. DEALER REPLACED ALTERNATOR AT COST OF $1006. 10 DAYS LATER CHECK ENGINE LIGHT AND ANTI SKID LIGHT CAME ON FOLLOWED BY BRAKE FAILURE LIGHT. CAR LOST HEADLIGHTS AND WINDSHIELD WIPERS-9 PM AND SLEETING. DEALER NOW SAYS NEED TO REPLACE CEM AND BATTERY AT A COST OF $3,000 DUE TO WATER IN CEM. IT WAS RAINING OR SLEETING BOTH TIMES THE CHECK ENGINE LIGHT CAME ON. VOLVO REDESIGNED THE COVER TO PREVENT WATER INTRUSION BUT NEEDS TO ISSUE RECALL. VERY DANGEROUS- TICKING TIME BOMB. SOMEONE WILL HAVE AN ACCIDENT ON RAINY NIGHT ON INTERSTATE. PLEASE CONSIDER REQUIRING RECALL-OWNERS OF THIS VEHICLE ARE SPENDING THOUSANDS OF DOLLARS DUE TO VOLVO XC90 V8 DESIGN FLAWS. HOW CAN VOLVO BE ALLOWED TO SELL VEHICLES THAT SHOULD NOT BE DRIVEN OUTSIDE/OR IN THE RAIN. *TR