2005 VOLVO XC90 Complaints

TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE FUEL TANK WHEN HE WAS DRIVING 25 MPH. THE CONTACT REFERENCED RECALL 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP) BUT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 64,000.

BALANCE SHAFT FAILURE ON 2005 VOLVO XC90 V8 WITH 115K MILES. UNBELIEVABLE THAT VOLVO WILL NOT ISSUE A RECALL FOR THIS. BALANCE SHAFT FAILED TODAY AT JUST UNDER 115K MILES... UNBELIEVABLE... AND I THOUGHT IT WAS JUST AN INTERNET RUMOR. IF YOU HAVE A 2005 XC90, SELL IT NOW! SERIOUSLY, THIS IS UNACCEPTABLE FOR A $50,000 VEHICLE, AND EVEN MORE UNACCEPTABLE FOR VOLVO NOT TO ISSUE A RECALL. NEEDLESS TO SAY, I SERIOUSLY DOUBT WE WILL EVER BUY ANOTHER VOLVO AGAIN SIMPLY BECAUSE THEY SHOULD HAVE ISSUED A RECALL FOR THIS PROBLEM. SHOULD HAVE STUCK WITH THE GERMANS (AUDI OR BMW), OR DARE I SAY IT THE JAPANESE, OR EVEN THE AMERICANS! I CAN REPLACE A LOT OF WHEEL BEARINGS ON A YUKON FOR WHAT THIS BALANCE SHAFT IS GOING TO COST ME. VOLVO NEEDS TO MAKE IT RIGHT WITH EVERY OWNER OF A 2005 XC90. VOLVO KNOWS OF THIS PROBLEM AND THAT IS WHY THEY ISSUED A TSB TO DRILL A DRAIN HOLE IN THE BLOCK, BUT THEY NEED TO STEP UP AND ISSUE A RECALL OR, AT THE VERY LEAST IF AN OWNER COMES INTO THE DEALERSHIP WITH THIS PROBLEM, THEY NEED TO FIX IT AT NO CHARGE. IT WAS THEIR MISTAKE, OWN UP TO IT AND FIX IT! *TR

I WAS DRIVING WITH MY DAUGHTER ON A VERY LONG BRIDGE AT NIGHT IN MY 2005 VOLVO XC90. THE CHECK ENGINE LIGHT CAME ON AND WHILE THE CAR STAYED ON, IT APPEARED TO HAVE LOST POWER. I HAVE HAD OTHER ELECTRICAL PROBLEMS WITH THE CAR AND HAVE HAD IT TO THE DEALER 3 TIMES BUT THEY SAY THEY CAN'T FIND ANYTHING WRONG WITH IT. THIS WAS BY FAR THE MOST DANGEROUS INCIDENT! AFTER DOING SOME INTERNET RESEARCH, I HAVE READ HUNDREDS OF REPORTS SIMILAR TO MINE. THERE IS A DEFINITE ISSUE WITH THIS CAR AND IT SHOULD BE RECALLED. *TR

TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE HEADLIGHT WOULD SHUT OFF INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPLACE THE CEM UNIT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

OCTOBER 10, 2010 PURCHASED CASH 2005 XC90 V8. WENT THROUGH SAFETY AND EMISSION SERVICE FOR REGISTRATION-- OKAY. OCTOBER 22 HEARD A STRANGE NOISE FROM ENGINE, CALLED VOLVO DEALERSHIP TO REQUEST SERVICE. DIDN'T DRIVE ON OCTOBER 23, 2010. ON SUNDAY, OCTOBER 24, WENT OUT TO MOVE THE CAR FOR OPPOSITE SIDE PARKING AND TO GAS UP FOR DRIVE TO SERVICE CENTER. CAR STOPPED AT SERVICE STATION, AND HAD TO BE TOWED TO DEALERSHIP. DEALERSHIP DIAGNOSTICS OCTOBER 25, 2010 CONFIRMED: NOISE IS FROM EITHER BROKEN CONNECTING ROD OR BALANCE SHAFT....ADVICE TO CUSTOMER "NEEDS ENGINE" AT A COST OF $14,000+. THE CAR DID NOT COME WITH A WARRANTY AND EVEN NOW THE DEALER IS BECOMING INCREASINGLY EVASIVE--AS HE SAYS HE WAS THE OWNER/DEALER AT THE TIME OF SALE, AND AS INDIVIDUAL SELLER REGISTERED IN ANOTHER STATE AND NOT NEW YORK, SO DOES NOT HAVE TO HONOR WARRANTY OR ASSUME RESPONSIBILITY. CALL VOLVO NORTH AMERICA ON OCTOBER 26, 2010 WITH NO KNOWLEDGE OF OUR OWNERSHIP, (STILL HAVEN'T RECEIVED TITLE TO CAR). RESPONSE WAS --NO WARRANTY NO ASSISTANCE WITH THIS COUNTER BALANCE OR ANY OTHER ISSUE BEYOND 4 YEAR/50,000 MILES. CONCERN: BEFORE PURCHASE WHEN ASKING THE DEALER NO MENTION NOR WHEN RESEARCHED NO REVELATION OF THE COUNTERBALANCE SHAFT BEING AN ONGOING ISSUE FOR THE 2005 XC90 V8. HOWEVER, FURTHER EVIDENCE CLEARLY SHOWS DESIGN FLAWS IN THE ORIGINAL YAMAHA ENGINES, AND A SLIGHT COVERT ATTEMPT BY VOLVO TO FIX IT VIA ITS LIMITED EDITION TECHNICAL SERVICE BULLETIN(TSB) TO DRILL THE HOLE IN THE SHAFT TO LET BUILD UP MOISTURE ESCAPE. ADDITIONALLY, VOLVO'S SECOND ATTEMPT TO SLIGHTLY ADDRESS THE COUNTER BALANCE ISSUE IS EVIDENCED VIA ITS LIMITED AND PAY-TO-GET TSB INFORMING DEALERSHIPS NOT CONSUMERS 'OF NOT WASHING THE ENGINE,' WHICH MAY LEAD TO MOISTURE BUILD UP AND TOTAL ENGINE FAILURE. OUR ATTEMPTS ARE NOW BEING MADE FOR VOLVO TO MAINTAIN ITS SLOGAN OF "SAFETY FOR LIFE." WE WANT THE SAFETY ATTRIBUTE TO BE EFFECTIVE AND USEFUL WHEN THE CAR IS OPERABLE, AND NOT WHEN THE CAR IS INOPERABLE. *TR

60,000 MILES ON A 1995 VOLVO XC90 AND THE TRANSMISSION JUST FAILED FOR THE FOURTH TIME. THE TRANSMISSION WAS ALREADY REPLACED THREE TIMES. FAILURE RESULTS IN CAR STOPPING WITHOUT WARNING. ANYTIME, ANYPLACE, IT JUST LOSES POWER. *TR

I HAVE A 2005 VOLVO XC90 T6. BOUGHT THIS CAR BRAND NEW. HAD SO MANY PROBLEMS INCLUDING TRANSMISSION OUT; THE BLINKERS DO NOT WORK. THE QUALITY AND SAFETY OF THIS VEHICLE IS MISLEADING AND THIS IS A HORRIBLE SAFETY ISSUE SINCE BLINKER DON'T WORK. LOOKING INTO IT, SEEMS LIKE THIS IS AN ONGOING ISSUE WITH MANY OWNER OF VOLVO XC90 2005. THEY REALLY NEED TO RECALL THIS BEFORE IT'S TOO LATE AND CAUSE FATALITIES. *TR

VEHICLE HAS DRIVER'S SIDE HEADLIGHT FAILURE. REPLACED BULB WITH CERTIFIED VOLVO REPLACEMENT AND STILL DID NOT WORK. CERTIFIED VOLVO MECHANIC TRACED FUSES AND ALL ELECTRICAL COMPONENTS (5 HOURS PAID SERVICE) AND FOUND THAT A PLASTIC PART DESIGNED TO KEEP WATER OUT OF THE INTERIOR (VIA WINDSHIELD) WAS DEFECTIVE, THEREFORE, CAUSING WATER LEAKAGE TO DAMAGE THE CENTRAL ELECTRICAL MODULE . *TR

I HAVE A 2005 VOLVO XC90 AWD. MY HEAD LIGHTS HAVE INTERMITTENT FAILURES ALMOST EVERY TIME I AM DRIVING AT NIGHT. IT STARTED ABOUT 10 MONTHS AGO AND HAS BEEN GETTING MORE FREQUENT. SOMETIMES LEFT HEAD LIGHT FAILS, SOMETIMES RIGHT HEAD LIGHT FAILS, SOMETIMES BOTH GO OUT. THEY WILL RESUME WORKING, SOMETIMES IF I DO NOTHING, BUT ALWAYS IF I TURN THEM OFF & BACK ON. BUT WILL CONTINUE TO FAIL. THE DEALER SAID THEY CANNOT FIND ANY PROBLEM. *TR

ME AND MY WIFE JUST BOUGHT OUR FIRST VOLVO 4 DAYS AGO!!! AND MY WIFE WAS ON THE HIGH WAY WITH OUR 7 MONTH OLD SON WHEN THE TRANSMISSION FAILED ON HER AND THEY ALMOST GOT INTO A CAR ACCIDENT. THANK GOD SHE WAS ABLE TO PULL OVER ON THE SIDE OF THE HIGH WAY AND CALL AAA AND WE HAD THE CAR TOWED TO THE VOLVO DEALER WERE WE BOUGHT IT FROM BECAUSE THEY GAVE US A 3 MONTH/ 3000 MILE WARRANTY. AND NOW IT'S BEEN 3 DAYS AND WE HAVE NO CAR AND THE DEALER IS SAYING THAT THEY ARE TRYING TO REPROGRAM THE TRANSMISSION. I WISH THAT I WOULD HAVE READ SOME OF THESE REVIEWS ON THIS MODEL CAR. BECAUSE THEY ALL SEEM TO HAVE TRANSMISSION PROBLEMS AND THEY SHOULD HAVE RECALLED THAT PROBLEM. WHAT SHOULD WE DO? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR